剩余污泥深度干燥的研究进展

秦岩; 邢奕; 张立国; 洪晨; 胡家硕; 李再兴; 冯丽慧; 张泽; 赵洪君; 孟洁

doi:10.13205/j.hjgc.202003026

剩余污泥深度干燥的研究进展

doi: 10.13205/j.hjgc.202003026

1. 山西大学环境与资源学院, 太原 030006;
2. 北京科技大学能源与环境工程学院, 北京 100083;
3. 河北科技大学环境科学与工程学院, 石家庄 050018

基金项目:

中央高校基本科研业务费资助项目（FRF-TP-18-006C1）。

详细信息

作者简介:
秦岩(1995-),男,硕士研究生,主要研究方向为污水处理及其资源化利用、固体废物减量化及综合利用。1085402303@qq.com

计量
- 文章访问数: 88
- HTML全文浏览量: 3
- PDF下载量: 12
- 被引次数: 0
出版历程
- 收稿日期: 2019-05-02

RESEARCH PROGRESS ON RESIDUAL SLUDGE DEPTH DRYING

1. College of Environmental & Resource Sciences, Shanxi University, Taiyuan 030006, China;
2. School of Energy and Environmental Engineering, University of Science and Technology Beijing, Beijing 100083, China;
3. School of Environmental Science and Engineering, Hebei University of Science and Technology, Shijiazhuang 050018, China

摘要

摘要: 剩余污泥的含水率较高，对污泥进行干燥处理可以极大程度地减少污泥的水分。首先分析了污泥的含水特性和干燥污泥机理，然后分析了主要的污泥干燥方法研究现状，如热风干燥、过热蒸汽干燥、间接干燥、低温热流干燥、热泵干燥、太阳能干燥等。此外，探究了新型的污泥干燥技术及污泥干燥过程中可能产生的污染物，并在此基础上，对污泥干燥技术的发展方向进行了展望。
- 剩余污泥 /
- 含水特性 /
- 干燥机理 /
- 干燥技术 /
- 污染物
Abstract: The moisture content of the residual sludge is generally high. The moisture of the residual sludge can be reduced obviously by drying process, so it is necessary to analyze and summarize the researches about sludge drying technologies. First of all, the moisture characteristics of sludge and the mechanism of drying sludge were analyzed. Then the mainstream sludge drying methods were analyzed, such as hot air drying, superheated steam drying, indirect drying, low temperature heat flow drying, heat pump drying, solar drying, etc. In addition, new sludge drying techniques and contaminants that may be produced during drying sludge were explored. In the end, we forecast the future development direction of residual sludge deepth drying technologies.
- residual sludge /
- moisture characteristics /
- drying mechanism /
- drying technology /
- pollutants

HTML全文

参考文献(60)

MUJUMDAR A S. Hand Book of Industrial Drying[M]. Boca Rat on, FL, USA:CRC Press, 2007.

HUESCAR MEDINA C, PHYLAKTOU H, SATTAR H, et al. The development of an experimental method for the determination of the minimum explosible concentration of biomass powders[J]. Biomass and Bioenergy, 2013, 53:95-104.

YU J L, TAHMASEBI A, HAN Y N, et al. A review on water in low rank coals:the existence, interaction with coal structure and effects on coal utilization[J]. Fuel Processing Technology, 2013, 106(2):9-20.

BEAMISH B, ARISOY A. Effect of mineral matter on coal self-heating rate[J]. Fuel, 2008, 87:125-130.

JIN L Y, ZHANG G M, TIAN H F. Current state of sewage treatment in China[J]. Water Research, 2014, 66:85-98.

HONG J M, XU C Q, TAN X F, et al. Life cycle assessment of sewage sludge co-incineration in a coal-based power station[J]. Waste Management, 2013, 33(9):1843-1852.

TAO T, PENG X F, LEE D J. Skin layer on thermally dried sludge cake[J]. Drying Technology, 2006, 24(8):1047-1052.

LEONARD A, MENESES E, LE TRONG E, et al. Influence of back mixing on the convective drying of residual sludges in a fixed bed[J]. Water Research, 2008, 42(10/11):2671-2677.

CIESLIK B M, NAMIESNIK J, KONIECZKA P. Review of sewage sludge management:standards, regulations and analytical methods[J]. Journal of Cleaner Production, 2015, 90:1-15.

KELESSIDIS A, STASINAKIS A S. Comparative study of the methods used for treatment and final disposal of sewage sludge in European countries[J]. Waste Management, 2012, 32(6):1186-1195.

MANARA P, ZABANIOTOU A. Towards sewage sludge based biofuels via thermochemical conversion:a review[J]. Renewable and Sustainable Energy Reviews, 2012, 16(5):2566-2582.

GUO L, ZHANG B, XIAO K, et al. Levels and distributions of polychlorinated biphenyls in sewage sludge of urban wastewater treatment plants[J]. Journal of Environmental Sciences, 2009, 21(4):468-473.

LIU J Z, WANG R K, GAO F Y, et al. Rheology and thixotropic properties of slurry fuel prepared using municipal wastewater sludge and coal[J]. Chemical Engineering Science, 2012, 76:1-8.

RADJENOVIC J, PETROVIC M, DAMIA B. Fate and distribution of pharmaceuticals in wastewater and sewage sludge of the conventional activated sludge (CAS) and advanced membrane bioreactor (MBR) treatment[J]. Water Research, 2009, 43(3):835-841.

FYTILI D, ZABANIOTOU A. Utilization of sewage sludge in EU application of old and new methods-A review[J]. Renewable and Sustainable Energy Reviews, 2008, 12(1):116-140.

YAN J H, DENG W Y, LI X D, et al. Experimental and theoretical study of agitated contact drying of sewage sludge under partial vacuum conditions[J]. Drying Technology, 2009, 27(6):787-796.

STEFANAKIS A I, TSIHRINTZIS V A. Dewatering mechanisms in pilot-scale Sludge Drying Reed Beds:effect of design and operational parameters[J]. Chemical Engineering Journal, 2011, 172(1):430-443.

BENNAMOUN L. Solar drying of wastewater sludge:a review[J]. Renewable and Sustainable Energy Reviews, 2012, 16(1):1061-1073.

KELESSIDIS A, STASINAKIS A S. Comparative study of the methods used for treatment and final disposal of sewage sludge in European countries[J]. Waste Management, 2012, 32(6):1186-1195.

PETERS B. Mechanical dewatering and thermal drying of sludge in a single apparatus[J]. Drying Technology, 2010, 28(4):454-459.

TUAN P A, MIKA S, PIRJO I. Sewage sludge electro-dewatering treatment:a review[J]. Drying Technology, 2012, 30(7):691-706.

LI B, WANG F, CHI Y, et al. Adhesion and cohesion characteristics of sewage sludge during drying[J]. Drying Technology, 2014, 32(13):1598-1607.

KOTWALIWALE N, BAKANE P, VERMA A. Changes in textural and optical properties of oyster mushroom during hot air drying[J]. Journal of Food Engineering, 2007, 78(4):1207-1211.

SUN G Y, CHEN M Q, HUANG Y W. Evaluation on the air-borne ultrasound-assisted hot air convection thin-layer drying performance of municipal sewage sludge[J]. Ultrasonics Sonochemistry, 2017, 34:588-599.

DI FRAIA S, MASSAROTTI N, VANOLI L, et al. Thermo-economic analysis of a novel cogeneration system for sewage sludge treatment[J]. Energy, 2016, 115:1560-1571.

ARLABOSSE P, CHAVEZ S, LECOMTE D. Method for thermal design of paddle dryers:application to municipal sewage sludge[J]. Drying Technology, 2004, 22(10):2375-2393.

BENNAMOUN L, ARLABOSSE P, LEONARD A. Review on fundamental aspect of application of drying process to wastewater sludge[J]. Renewable and Sustainable Energy Reviews, 2013, 28:29-43.

MOON S H, RYU I S, LEE S J, et al. Optimization of drying of low-grade coal with high moisture content using a disc dryer[J]. Fuel Processing Technology, 2014, 124:267-274.

CHEN G H, PO L Y, MUJUMDAR A S. Sludge Dewatering and Drying[J]. Drying Technology, 2002,20(5/5):883-916.

MAKELA M, EDLER J, GELADI P. Low-temperature drying of industrial biosludge with simulated secondary heat[J]. Applied Thermal Engineering, 2017, 116:792-798.

FONT R, GOMEZ-RICO M F, FULLANA A. Skin effect in the heat and mass transfer model for sewage sludge drying[J]. Separation and Purification Technology, 2011, 77(1):146-161.

RUIZ T, WISNIEWSKI C. Correlation between dewatering and hydro-textural characteristics of sewage sludge during drying[J]. Separation and Purification Technology, 2008, 61(2):204-210.

ALEJANDRO S, KATIA P, SEREMETA. Advantages and challenges of the spray-drying technology for the production of pure drug particles and drug-loaded polymeric carriers[J]. Advances in Colloid and Interface Science, 2015, 223(10):40-54.

LEONARD A, BLACHER S, MARCHOT P, et al. Convective drying of wastewater sludges:influence of air temperature, superficial velocity, and humidity on the kinetics[J]. Drying Technology, 2005, 23(8):1667-1679.

SLIM R, ZOUGHAIB A, CLODIC D. Modeling of a solar and heat pump sludge drying system[J]. International Journal of Refrigeration, 2008, 31(7):1156-1168.

CHAUHAN P S, KUMAR A, TEKASAKUL P. Applications of software in solar drying systems:a review[J]. Renewable & Sustainable Energy Reviews, 2015, 51:1326-1337.

SALIHOGLU N K, PINARLI V, SALIHOGLU G. Solar drying in sludge management in Turkey[J]. Renewable Energy, 2007, 32(10):1661-1675.

SHRIVASTAVA R L, KUMAR V, UNTAWALE S P. Modeling and simulation of solar water heater:a TRNSYS perspective[J]. Renewable & Sustainable Energy Reviews, 2017, 67:126-143.

WANG C Q, ZHANG Z T, LU J, et al. Greenhouse sludge dry treatment[J]. Science & Technology Review, 2010, 28(22):33-38.

TELLEZ C, MARGARITA A, PILATOWSKY F I, et al. Solar drying of stevia (rebaudiana bertoni) leaves using direct and indirect technologies[J]. Solar Energy, 2018, 159:898-907.

MATHIOUDAKIS V L, KAPAGIANNIDIS A G, ATHANASOULIA E, et al. Extended dewatering of sewage sludge in solar drying plants[J]. Desalination, 2009, 248(1/2/3):733-739.

WINKLER M K H, BENNENBROEK M H, HORSTINK F H, et al. The biodrying concept:an innovative technology creating energy from sewage sludge[J]. Bioresource Technology, 2013, 147(7):124-129.

NAVAEE-ARDEH S, BERTRAND F, STUART P R. Emerging biodrying technology for the drying of pulp and paper mixed sludges[J]. Drying Technology, 2006, 24(7):10-16.

ZHAO L, GU W M, HE P J, et al. Effect of air-flow rate and turning frequency on bio-drying of dewatered sludge[J]. Water Research, 2010, 44(20):6144-6152.

TSAI W T, CHANG J H, HSIEN K J, et al. Production of pyrolytic liquids from industrial sewage sludges in an induction-heating reactor[J]. Bioresource Technology, 2009, 99(1):406-412.

SEPTIEN S, SINGH A, MIRARA S W, et al. 'LaDePa' process for the drying and pasteurization of faceal sludge from VIP latrines using infrared radiation[J]. South African Journal of Chemical Engineering, 2018, 25:147-158.

ROZAINEE M, KHAIRUDDIN W, ALI W, et al. Comparison of sludge drying performance between microwave and convective drying[C]//Proceeding of the 5th Symposium of Malaysian Chemical Engineers, 2001:361-367.

BENNAMOUN L, CHEN Z, AFZAL M T. Microwave drying of wastewater sludge:experimental and modeling study[J]. Drying Technology, 2016, 34(2):9-15.

LEE S M, CHOI S Y, NGUYEN D D, et al. Sludge drying using microwave heating with Li₂CO₃-Fe₂O₃-ZnO materials[J]. Journal of Industrial and Engineering Chemistry, 2018, 61:28-31.

PUTRANTO A, CHEN X D. A simple and effective model for modeling of convective drying of sewage sludge:the reaction engineering approach(REA)[J]. Procedia Chemistry, 2014,9:77-87.

HUANG Y W, CHEN M Q. Artificial neural network modeling of thin layer drying behavior of municipal sewage sludge[J]. Measurement, 2015, 73:640-648.

MILHE M, SAUCEAU M, ARLABOSSE P. Influence of operating parameters on sewage sludge drying in a paddle dryer:design of experiments for the determination of hold-up and water content profiles[J]. Drying Technology, 2015, 33(11):1276-1285.

DENG W Y, YAN J H, LI X D, et al. Emission characteristics of volatile compounds during sludge drying process[J]. Journal of Hazardous Materials, 2009, 162(1):186-192.

OHM T I, CHAE J S, KIM J E, et al. A study on the dewatering of industrial waste sludge by fry-drying technology[J]. Journal of Hazardous Materials, 2009, 168(1):445-450.

YI S M, PGILLA S R, SEO Y C, et al. Emissions of polychlorinated biphenyls(PCBs) from sludge drying beds to the atmosphere in Chicago[J]. Chemosphere, 2008, 71(6):1028-1034.

HORTTANAINEN M, DEVIATKIN I, HAVUKAINEN J. Nitrogen release from mechanically dewatered sewage sludge during thermal drying and potential for recovery[J]. Journal of Cleaner Production, 2017, 142:1819-1826.

WENG H X, DAI Z X, JI Z Q, et al. Release and control of hydrogen sulfide during sludge thermal drying[J]. Journal of Hazardous Materials, 2015, 296:61-67.

KARAYILDIRIM T, YANIK J, YUKSEL M, et al. Characterisation of products from pyrolysis of waste sludges[J]. Fuel, 2006, 85(10):1498-1508.

LI B B, FAN H H, YANG A W, et al. Study on sludge drying and gas release characteristics[J]. Bulletin of the Chinese Ceramic Society, 2013, 32(2):205-209.

CHENG G Y, DING J H, JIN Y Y, et al. Study on emission characteristics of volatile organic compounds from thermal drying process of sludge[J]. Journal of North China Institute of Science and Technology, 2017, 14(1):11-16.

施引文献

资源附件(0)

访问统计