微波与酶联用对印染污泥脱水性能的影响

刘二燕; 薛飞; 许士洪; 李登新

doi:10.13205/j.hjgc.202005003

微波与酶联用对印染污泥脱水性能的影响

doi: 10.13205/j.hjgc.202005003

刘二燕^1,2,
薛飞^1,2,
许士洪^1,2,3,4, ,,
李登新^1,2,3,4

1. 东华大学环境科技与工程学院, 上海 201620;
2. 东华大学国家环境保护纺织污染防治工程技术中心, 上海 201620;
3. 同济大学环境科学与工程学院污染控制与资源化研究国家重点实验室, 上海 201620;
4. 上海污染控制与生态安全研究院, 上海 201620

基金项目:

国家自然科学基金"钢铁联合研究基金资助项目"(U1660107)。

详细信息

作者简介:
刘二燕(1994-),女,硕士,主要研究方向为固体废物处理处置。1130193109@qq.com

通讯作者:
许士洪,男,副教授。shxu@dhu.edu.cn

计量
- 文章访问数: 92
- HTML全文浏览量: 15
- PDF下载量: 4
- 被引次数: 0
出版历程
- 收稿日期: 2019-01-23

EFFECT OF MICROWAVE AND LYSOZYME JOINT TREATMENT ON THE DEWATERING PERFORMANCE OF PRINTING AND DYEING SLUDGE

LIU Er-yan^1,2,
XUE Fei^1,2,
XU Shi-hong^{1,2,3,4
, ,},
LI Deng-xin^1,2,3,4

1. School of Environmental Science and Engineering, Donghua University, Shanghai 201620, China;
2. National Environmental Protection Textile Pollution Prevention Engineering Technology Center, Donghua University, Shanghai 201620, China;
3. State Key Laboratory of Pollution Control and Resource Reuse, School of Environmental Science and Engineering, Tongji University, Shanghai 201620, China;
4. Shanghai Institute of Pollution Control and Ecological Safety, Shanghai 201620, China

摘要

摘要: 比较微波、酶、微波与酶联用处理对印染污泥脱水性能的影响,在单因素考察的基础上,以印染污泥中毛细吸水时间(CST)、沉降曲线、扫描电镜(SEM)及EPS的三维荧光光谱等指标,通过正交试验法优选微波与酶联用预处理对破解印染污泥的最佳条件来表征污泥脱水性能,获得联合预处理最佳条件为:酶解温度40 ℃,加酶量0.09 g/g(TSS),酶解时间3 h,微波功率400 W,微波时间150 s。单因素实验结果表明:单独微波(400 W,180 s)和酶(0.09 g/g(TSS),40 ℃,4 h)处理在适当条件下均能促进污泥的破解和胞外聚合物的溶出,多糖和蛋白质的增长率分别为609%和306%,CST分别下降了12.2%和22.0%;而微波与酶联用溶出多糖和蛋白质和的增长率为1353%,CST下降了49.3%,污泥沉降性能最好。扫描电镜结果显示,微波与酶联用使污泥结构变化明显,污泥菌胶团破裂,絮体结构松散,胞内结合水转化为自由水,有利于污泥脱水。
- 印染污泥 /
- 微波 /
- 酶 /
- 脱水性能
Abstract: On the basis of a single factor study, capillary water absorption time (CST), sedimentation curve, scanning electron microscope (SEM), and three-dimensional fluorescence spectra of EPS in printing and dyeing sludge was explored, and the effect of microwave, lysozyme, microwave and lysozyme joint treatment on the dewatering of printing and dyeing sludge was compared. The sludge dewatering performance was characterized by orthogonal test, and the optimal conditions for the joint treatment were: the enzymolysis temperature was 40 ℃, the amount of lysozyme added was 0.09 g/g(TSS), the enzymolysis time was 3 h, the microwave power was 400 W, and the microwave time was 150 s. The single factor experiment results showed that: microwave (400 W, 180 s) and lysozyme (0.09 g/g(TSS), 40 ℃, 4 h) treatment could promote sludge cracking and dissolution of extracellular polymers; under those two conditions, the growth rate of dissolved polysaccharide and total proteins was 609% and 306% respectively; CST was decreased by 12.2% and 22.0%, respectively. At the same time, the joint treatment of microwave and lysozymes increased the dissolve polysaccharides and total proteins by 1353%, and decreased CST by 49.3%,and sludge sedimentation performance was the best then. SEM results showed: the combination of microwave and lysozyme made the structure of the sludge changed obviously. The sludge bacteria micelle was broken, the floc structure became loose, and the intracellular bound water was successfully converted into free water, which was beneficial to the sludge dehydration.
- printing and dyeing sludge /
- microwave /
- lysozyme /
- dehydration performance

HTML全文

参考文献(19)

LIU J J C. Control aniline pollutants from printing and dyeing industries[J]. China Environ. News, 2015(17): 55-56.

QI Y, THAPA K B, HOADLEY A F A. Application of filtration aids for improving sludge dewatering properties: a review[J]. Chemical Engineering Journal, 2011, 171(2):373-384.

SARAYU K, SANDHYA S. Current technologies for biological treatment of textile wastewater: a review[J]. Applied Biochemistry and Biotechnology, 2012, 167(3):645-661.

RAJAGOPAL R, DANIEL I M, SINGH G. A critical review on inhibition of anaerobic digestion process by excess ammonia[J]. Bioresource Technology, 2013, 143(17):632-641.

CHEN Y G, YANG H Z, GU G W. Effect of acid and surfactant treatment on activated sludge dewatering and settling[J]. Water Research, 2001, 35(11):2615-2620.

TONY M A, ZHAO Y Q, FU J F, et al. Conditioning of aluminium-based water treatment sludge with Fenton’s reagent: effectiveness and optimising study to improve dewaterability[J]. Chemosphere, 2008, 72(4):673-677.

AHMADUN F R, MOLLA A H. Enhancement of bioseparation and dewaterability of domestic wastewater sludge by fungal treated dewatered sludge[J]. Journal of Hazardous Materials, 2007, 147(1/2):350-356.

FENG X, DENG J C, LEI H Y, et al. Dewaterability of waste activated sludge with ultrasound conditioning[J]. Bioresource Technology, 2009, 100(3):1074-1081.

ZHU Y P, LIU H B, FU B, et al. Effect of synergistically adding protease and EDTA-2Na on waste activated sludge hydrolysis[J]. Chinese Journal of Environmental Engineering, 2013, 7(8):3158-3164.

PEI H Y, HU W R, LIU Q H. Effect of protease and cellulase on the characteristic of activated sludge[J]. Journal of Hazardous Materials, 2010, 178(1/2/3):397-403.

BONILLA S, TRAN H, ALLEN D G. Enhancing pulp and paper mill biosludge dewaterability using enzymes[J]. Water Research, 2015, 68:692-700.

WANG Y W, WEI Y S, LIU J X. Effect of H₂O₂ dosing strategy on sludge pretreatment by microwave-H₂O₂ advanced oxidation process[J]. Journal of Hazardous Materials, 2009, 169(1/2/3):680-684.

WANG Y W, XIAO Q C, LIU J B, et al. Pilot-scale study of sludge pretreatment by microwave and sludge reduction based on lysis-cryptic growth[J]. Bioresource Technology, 2015, 190:140-147.

MEHDIZADEH S N, ESKICIOGLU C, BOBOWSKI J, et al. Conductive heating and microwave hydrolysis under identical heating profiles for advanced anaerobic digestion of municipal sludge[J]. Water Research, 2013, 47(14):5040-5051.

WALTER W G. Standard methods for the examination of water and wastewater (11th ed.)[J]. American Journal of Public Health and the Nations Health, 1961, 51(6):940.

路苹, 于同泉, 王淑英, 等. 蛋白质测定方法评价[J]. 北京农学院学报, 2006, 21(2):65-69.

钟方晓, 任海华, 李岩. 多糖含量测定方法比较[J]. 时珍国医国药, 2007, 18(8): 126-127.

王黎明, 夏文水. 蒽酮-硫酸法测定茶多糖含量的研究[J]. 食品科学, 2005, 26(7):185-188.

ZHANG T, WANG Q, KHAN J, et al. Free nitrous acid breaks down extracellular polymeric substances in waste activated sludge[J]. RSC Advances, 2015, 54(5):43312-43318.

施引文献

资源附件(0)

访问统计