可燃垃圾与煤粉混合燃烧特性及动力学分析

张红玉; 江滔; 张元勤

doi:10.13205/j.hjgc.202009029

可燃垃圾与煤粉混合燃烧特性及动力学分析

doi: 10.13205/j.hjgc.202009029

乐山师范学院化学学院, 四川乐山 614004

详细信息

作者简介:
张红玉(1983-),女,博士研究生,主要研究方向为固体废弃物处理与资源化。zhyycj6688@163.com

通讯作者:
张元勤(1963-),男,博士,教授,主要研究方向为热动力学。zyq@lsnu.edu.cn

计量
- 文章访问数: 134
- HTML全文浏览量: 15
- PDF下载量: 3
- 被引次数: 4
出版历程
- 收稿日期: 2019-08-21

CO-COMBUSTION CHARACTERISTICS AND KINETIC ANALYSIS OF COMBUSTIBLE WASTE AND PULVERIZED COAL

College of Chemistry, Leshan Normal University, Leshan 614004, China

摘要

摘要: 采用热重分析法对可燃垃圾、煤粉及其混合燃料的燃烧特性进行了分析。研究结果表明：可燃垃圾的热重曲线在220~500℃内存在2个明显的失重区域，煤粉在300~600℃内只有1个失重区域。可燃垃圾着火性能较好，着火点为220℃，可燃垃圾与煤粉混烧时的着火点较可燃垃圾单独燃烧时略有提高，但明显低于煤粉单独燃烧时320℃的着火点。可燃垃圾和煤粉按照2：1、3：1、4：1、5：1混烧时，基本保持垃圾的着火特性，当可燃垃圾的掺混量 ≤ 80%时，可燃垃圾和煤粉混烧时两者之间存在明显的协同促进作用。可燃垃圾的综合燃烧特征指数为3.91×10^-7/（min²·K³），明显高于煤粉，可燃垃圾的添加能提高煤粉的综合燃烧性能，其中可燃垃圾：煤粉=4：1为掺混比例最佳。燃烧动力学分析结果表明：在220~330℃燃烧阶段，混合燃料的活性高于可燃垃圾，在320~570℃高温燃烧阶段，混合燃料的活性略低于可燃垃圾，但是远高于煤粉。可燃垃圾的掺烧量对2个燃烧阶段混合燃料的活性影响不大。
- 可燃垃圾 /
- 煤粉 /
- 燃烧 /
- 热重分析 /
- 动力学分析
Abstract: In this study, the combustion characteristics of combustible waste, pulverized coal and their mixture were analyzed by thermogravimetric analysis. The results showed that the thermogravimetric curves of combustible waste had two obvious weight loss regions in the temperature range of 220~500℃, and only one obvious weight loss region of pulverized coal in the temperature range of 300~600℃. Combustible waste had good ignition performance, and the ignition point was 220℃. The ignition point of combustible waste mixed with pulverized coal was slightly higher than that of the combustible waste, but it was also obviously lower than that of pulverized coal combustion alone. Mixed combustion basically maintained the ignition characteristics of the combustible waste, when mixed with pulverized coal. When the blending proportion of combustible waste was not more than 80%, there was an obvious synergistic promoting effect between combustible waste and pulverized coal mixed combustion. The comprehensive combustion characteristic index of combustible waste was 3.91×10^-7/(min²·K³), obviously higher than that of the pulverized coal. The addition of the combustible waste could improve the comprehensive combustion performance of the pulverized coal, and the best ratio of combustible waste to pulverized coal was 4:1. The results of combustion kinetic analysis showed that the activity of the mixed fuel was higher than that of the combustible waste at 220~330℃ combustion stage, and the activity of the mixed fuel was slightly lower than that of the combustible waste at 320~570℃ combustion stage, but much higher than that of the pulverized coal. The addition amount of the combustible waste had little influence on activity of the mixed fuel in the two combustion stages.
- combustible waste /
- pulverized coal /
- combustion /
- thermogravimetric analysis /
- kinetic analysis

HTML全文

参考文献(15)

中华人民共和国建设部. CJJ/T 102-2004,城市生活垃圾分类及其评价标准[S]. 北京:中国建筑工业出版社,2004.

PǍTRUTESCU C, VLASE G, TURCUS V D, et al. TG/DTG/DTA data used for determining the kinetic parameters of the thermal degradation process of an immunosuppressive agent:mycophenolate mofetil[J]. Journal of Thermal Analysis and Calorimetry, 2015, 121(3):983-988.

齐琪,袁京,李赟,等.生活垃圾制备RDF工艺参数及其热特性研究[J].中国环境科学, 2017,37(3):1051-1057.

NAGARAJ S, VISHNUVARDHAN C V, GHOSH S, et al. Phase diagram study of CaBr₂-LiBr system using DTA[J]. Journal of Thermal Analysis and Calorimetry, 2014, 115(2):1835-1839.

GHOREISHI K, YARMO M A, ASIM N. Investigation of curing kinetics of diglycidyl ether of bisphenol A and zinc (Ⅱ) complexes using dynamic DSC technique[J]. Journal of Polymer Research, 2015, 22(2):1-12.

PAVLÍK Z, TRNÍK A, KULOVANÁ T, et al. DSC and TG analysis of a blended binder based on waste ceramic powder and portland cement[J]. International Journal of Thermophysics, 2016, 37(3):1-14.

魏琰荣,肖翠微,王乃继,等.补连塔煤低温氧化特性的热重研究[J].洁净煤技术,2016,22(1):77-81.

周家平,唐强,王丽朋,等.污水污泥在富氧环境下燃烧特性的实验研究[J].环境工程学报,2011,4(8):1871-1876.

陈义胜,李姝姝,庞赟佶,等.几种典型城市生活垃圾的热解特性和动力学分析[J].科学技术与工程,2015,15(35):179-184.

廖洪强,姚强,王斌.城市生活垃圾热解失重特性[J].环境卫生工程,2002,10(2):51-53.

蒲舸,王炯,张力.城市生活垃圾可燃成分燃烧特性热重分析[J].重庆大学学报(自然科学版),2009,32(5):598-603.

柏继松,余春江,李廉明,等. 煤和垃圾衍生燃料循环流化床混烧的试验研究[J]. 中国电机工程学报, 2012,32(14):36-41.

徐朝芬,孙学信.用TG-DTG-DSC研究生物质的燃烧特性[J].华中科技大学学报(自然科学版),2007,35(3):126-128.

RASOOL M A, TAVAKOLI B, CHAIBAKHSH N, et al. Use of a plant-based coagulant in coagulation-ozonation combined treatment of leachate from a waste dumping site[J]. Ecological Engineering, 2016,90:431-437.

Qin C, Tian W D, Xiao Y H. Analysis of combustion characteristics of RDF by thermogravimetry[J]. Journal of Combustion Science and Technology, 2004,10:232-236.

施引文献