预处理对园林垃圾混合物料联合厌氧发酵的影响

徐一雯; 蒋建国; 孟园; 颜未蔚

doi:10.13205/j.hjgc.202011028

预处理对园林垃圾混合物料联合厌氧发酵的影响

doi: 10.13205/j.hjgc.202011028

清华大学环境学院, 北京 100084

基金项目:

水体污染控制与治理科技重大专项（2017ZX07202005）。

详细信息

作者简介:
徐一雯(1994-),女,硕士研究生,主要从事固体废物资源化技术研究。xyw16@mails.tsinghua.edu.cn

通讯作者:
蒋建国(1970-),男,教授,主要从事固体废物处理与资源化利用研究。jianguoj@mail.tsinghua.edu.cn

计量
- 文章访问数: 152
- HTML全文浏览量: 30
- PDF下载量: 7
- 被引次数: 0
出版历程
- 收稿日期: 2019-10-15
- 网络出版日期: 2021-04-23
- 刊出日期: 2021-04-23

EFFECTS OF PRETREATMENT ON ANAEROBIC CO-DIGESTION OF GARDEN WASTE AND OTHER SUBSTRATES

School of Environment, Tsinghua University, Beijing 100084, China

摘要

摘要: 采用超声、微波及碱热预处理技术强化园林垃圾、厨余垃圾与果蔬垃圾联合厌氧发酵产气性能，并以未进行预处理的实验组作为对照。结果表明：4组实验pH值在2 d内迅速降低至7.24~7.45，反应后期可稳定在7.7~8.0，表明厌氧消化系统有较强的稳定性。挥发性脂肪酸（volatile fatty acids，VFA）浓度在第2~4天内达到最大值。乙酸和丙酸是4组实验中VFA的主要成分，两者比例之和在70%以上。VFA浓度在第13天后降低到500 mg/L以下，且以乙酸为主。氨氮（TAN）浓度在前4 d内出现一定波动，随后逐渐升高至2190~2410 mg/L。游离氨氮（FAN）浓度呈先降低后增加趋势，并在第13天后逐渐趋于稳定，为144~209 mg/L。沼气中甲烷比例在第2天后均超过50%，并在第11~12天时达到最大值61.4%~63.8%。修正的Gomperts模型模拟结果表明：预处理技术可缩短反应体系厌氧产沼的适应时间，提高前期产气速率。除此之外，超声预处理与碱热预处理可显著提高基质甲烷产率，由未处理时的396 mL/g分别提高到601，536 mL/g，而微波预处理使得反应体系甲烷产量略有降低。
- 联合厌氧发酵 /
- 园林垃圾 /
- 沼气 /
- 预处理 /
- 产甲烷潜力
Abstract: Ultrasound, microwave and alkali-thermal pretreatment were applied for enhancing biogas production by anaerobic co-digestion of garden waste, kitchen waste and fruit and vegetable waste. The experiment without pretreatment served as the control. The results showed that pH values of the four experiments rapidly decreased to 7.24~7.45 within 2 days and then increased to 7.7~8.0 at the end of reactions, indicating that anaerobic digestion systems were relatively stable. The concentrations of VFA reached the maximum within 2~4 days, of which acetic acid and propionic acid were the main components, accounting for more than 70%. After 13 days, VFA concentrations decreased to below 500 mg/L, and mainly acetic acid remained. There were some fluctuations of TAN concentrations during the first 4 days, which then gradually increased to 2190~2410 mg/L at the end. While the concentrations of FAN firstly decreased, then increased and stabilized to 144~209 mg/L after 13 days. The proportion of methane in biogas all exceeded 50% after the 2nd day and reached the maximum value of 61.4%~63.8% on the 11th~12th day. According to simulation results of the modified Gomperts model, pretreatments could shorten the adaption period and enhance gas production at early stage. Ultrasonic pretreatment and alkali-thermal pretreatment could significantly increase the methane yield, from 396 mL CH₄/g VS to 601 mL CH₄/g VS, 536 mL CH₄/g VS, respectively, while microwave pretreatment slightly decreased the methane yield.
- anaerobic co-digestion /
- garden waste /
- biogas /
- pre-treatment /
- biochemical methane potential

HTML全文

参考文献(32)

SHI Y, GE Y, CHANG J, et al. Garden waste biomass for renewable and sustainable energy production in China:Potential, challenges and development[J]. Renewable & Sustainable Energy Reviews, 2013,22:432-437.

Brown S. Putting the landfill energy myth to rest[J]. Biocycle, 2010,51(5):23-35.

ABREU A A, TAVARES F, ALVES M M, et al. Garden and food waste co-fermentation for biohydrogen and biomethane production in a two-step hyperthermophilic-mesophilic process[J]. Bioresource Technology, 2019,278:180-186.

CARDONA L, LEVRARD C, GUENNE A, et al. Co-digestion of wastewater sludge:choosing the optimal blend[J]. Waste Management, 2019,87:772-781.

孙健, 万顺刚, 罗文邃. 堆肥预处理对园林废弃物厌氧消化的影响[J]. 环境工程, 2014,32(3):100-105.

YANG L C, XU F Q, GE X M, et al. Challenges and strategies for solid-state anaerobic digestion of lignocellulosic biomass[J]. Renewable & Sustainable Energy Reviews, 2015,44:824-834.

BROWN D, SHI J, LI Y. Comparison of solid-state to liquid anaerobic digestion of lignocellulosic feedstocks for biogas production[J]. Bioresource Technology, 2012,124:379-386.

GE X M, XU F Q, LI Y B. Solid-state anaerobic digestion of lignocellulosic biomass:recent progress and perspectives[J]. Bioresource Technology, 2016,205:239-249.

BROWN D, LI Y B. Solid state anaerobic co-digestion of yard waste and food waste for biogas production[J]. Bioresource Technology, 2013,127:275-280.

KANG X H, SUN Y M, LI L H, et al. Improving methane production from anaerobic digestion of Pennisetum Hybrid by alkaline pretreatment[J]. Bioresource Technology, 2018,255:205-212.

PENG J J, ABOMOHRA A E, ELSAYED M, et al. Compositional changes of rice straw fibers after pretreatment with diluted acetic acid:towards enhanced biomethane production[J]. Journal of Cleaner Production, 2019,230:775-782.

ZIELIŃSKI M, KISIELEWSKA M, DUDEK M, et al. Comparison of microwave thermohydrolysis and liquid hot water pretreatment of energy crop Sida hermaphrodita for enhanced methane production[J]. Biomass & Bioenergy, 2019,128:105324.

DONG C Y, CHEN J, GUAN R L, et al. Dual-frequency ultrasound combined with alkali pretreatment of corn stalk for enhanced biogas production[J]. Renewable Energy, 2018,127:444-451.

YUAN H R, SONG X C, GUAN R L, et al. Effect of low severity hydrothermal pretreatment on anaerobic digestion performance of corn stover[J]. Bioresource Technology, 2019,294:122238.

MONLAU F, AEMIG Q, BARAKAT A, et al. Application of optimized alkaline pretreatment for enhancing the anaerobic digestion of different sunflower stalks varieties[J]. Environmental Technology, 2013,34(13/14SI):2155-2162.

CHEN Y, CHENG J J, CREAMER K S. Inhibition of anaerobic digestion process:a review[J]. Bioresource Technology, 2008,99(10):4044-4064.

SILES J A, BREKELMANS J, MARTIN M A, et al. Impact of ammonia and sulphate concentration on thermophilic anaerobic digestion[J]. Bioresource Technology, 2010,101(23):9040-9048.

REN N Q, LIU M, WANG A J, et al. Organic Acids Conversion in Methanogenic-phase Reactor of the Two-phase Anaerobic Process[J]. Chinese Journal of Environmental Science, 2003,24(4):89-93.

WANG Y Y, ZHANG Y L, WANG J B, et al. Effects of volatile fatty acid concentrations on methane yield and methanogenic bacteria[J]. Biomass & Bioenergy, 2009,33(5):848-853.

BANKS C J, ZHANG Y, JIANG Y, et al. Trace element requirements for stable food waste digestion at elevated ammonia concentrations[J]. Bioresource Technology, 2012,104:127-135.

SCHNURER A, NORDBERG A. Ammonia, a selective agent for methane production by syntrophic acetate oxidation at mesophilic temperature[J]. Water Science and Technology, 2008,57(5):735-740.

何仕均, 王建龙, 赵璇. 氨氮对厌氧颗粒污泥产甲烷活性的影响[J]. 清华大学学报(自然科学版), 2005,45(9):1294-1296.

KAYHANIAN M. Performance of a high-solids anaerobic-digestion process under various ammonia concentrations[J]. Journal of Chemical Technology and Biotechnology, 1994,59(4):349-352.

RAJAGOPAL R, MASSE D I, SINGH G. A critical review on inhibition of anaerobic digestion process by excess ammonia[J]. Bioresource Technology, 2013,143:632-641.

KRAKAT N, DEMIREL B, ANJUM R, et al. Methods of ammonia removal in anaerobic digestion:a review[J]. Water Science and Technology, 2017,76(8):1925-1938.

LAUTERBOECK B, ORTNER M, HAIDER R, et al. Counteracting ammonia inhibition in anaerobic digestion by removal with a hollow fiber membrane contactor[J]. Water Research, 2012,46(15):4861-4869.

ALAGÖZ B A, YENIGÜN O, ERDINCLER A. Ultrasound assisted biogas production from co-digestion of wastewater sludges and agricultural wastes:comparison with microwave pre-treatment[J]. Ultrasonics Sonochemistry, 2018,40(Part B):193-200.

WANG H, WANG H T, LU W J, et al. Digestibility improvement of sorted waste with alkaline hydrothermal pretreatment[J]. Tsinghua Science and Technology, 2009,14(3):378-382.

PAUDEL S R, BANJARA S P, CHOI O K, et al. Pretreatment of agricultural biomass for anaerobic digestion:current state and challenges[J]. Bioresource Technology, 2017,245(Part A):1194-1205.

KWIATKOWSKA B, BENNETT J, AKUNNA J, et al. Stimulation of bioprocesses by ultrasound[J]. Biotechnology Advances, 2011,29(6):768-780.

HU Z H, WEN Z Y. Enhancing enzymatic digestibility of switchgrass by microwave-assisted alkali pretreatment[J]. Biochemical Engineering Journal, 2008,38(3):369-378.

MARIN J, KENNEDY K J, ESKICIOGLU C. Effect of microwave irradiation on anaerobic degradability of model kitchen waste[J]. Waste Management, 2010,30(10):1772-1779.

施引文献

资源附件(0)

访问统计