不同来源底物对厌氧发酵产氢余物产甲烷影响

周雨绮; 曹麒; 许俊超; 刘常青; 卓桂华; 陈建勇; 郑育毅

doi:10.13205/j.hjgc.202109018

不同来源底物对厌氧发酵产氢余物产甲烷影响

doi: 10.13205/j.hjgc.202109018

周雨绮^1,2,
曹麒^1,2,
许俊超^1,2,
刘常青^2,4, ,,
卓桂华³,
陈建勇¹,
郑育毅^1,2

1. 福建师范大学环境科学与工程学院, 福州 350007;
2. 城市废物资源化技术与管理福建省高校工程研究中心, 福州 350007;
3. 福建省环境科学研究院, 福州 350013;
4. 福建师范大学地理科学学院, 福州 350007

基金项目:

福建省科技厅公益类项目（2019R1015-1）；福建省科技厅计划项目（2020N5015）。

详细信息

作者简介:
周雨绮(1997-),女,研究生在读,主要研究方向为环境管理、固体废物处理与资源化。924730750@qq.com

通讯作者:
刘常青(1970-),女,博士,副教授,主要研究方向为固体废物处理与资源化。mylcq@126.com

计量
- 文章访问数: 125
- HTML全文浏览量: 16
- PDF下载量: 5
- 被引次数: 0
出版历程
- 收稿日期: 2021-04-04
- 网络出版日期: 2022-01-21

INFLUENCE OF DIFFERENT SOURCE SUBSTRATE SYSTEMS ON METHANOGENESIS OF RESIDUE FROM ANAEROBIC FERMENTATIVE HYDROGEN PRODUCTION USING COMBINED SLUDGE AND FOOD WASTE

1. College of Environmental Science and Engineering, Fujian Normal University, Fuzhou 350007, China;
2. Fujian College and University Engineering Research Center for Municipal Solid Waste Resourceization and Management, Fuzhou 350007, China;
3. Fujian Academy of Environmental Sciences, Fuzhou 350013, China;
4. College of Geographical Science, Fujian Normal University, Fuzhou 350007, China

摘要

摘要: 通过批式试验将不同来源的污泥与餐厨垃圾进行联合厌氧发酵，研究不同产氢程度的污泥-餐厨垃圾在不同污泥接种量下的产甲烷能力，以寻求产氢余物产沼的最佳条件及有机质转化规律。结果表明：污泥-餐厨垃圾产氢余物的产氢程度与体系产甲烷能力呈正相关，即产氢多余物>产氢少余物>不产氢底物；接种量增大后，体系产甲烷效能降低且各体系间的差异逐渐缩小。30%接种量下的产氢多余物体系产甲烷能力最佳，平均产甲烷速率为0.54 mL/（g·；d），在第27天甲烷占比达到峰值87.04%，有最大累积产甲烷量1659 mL；主要原因是该体系挥发酸降解量大（17565 mg COD/L），占TCOD降解量（35384 mg/L）的50%。
- 产氢余物 /
- 厌氧发酵 /
- 产甲烷 /
- 接种量 /
- 中温
Abstract: This study explored the methane production capacity of different source substrate systems from different residues of anaerobic fermentative hydrogen production using combined sludge and food waste through batch experiments, aimed to seek the optimum methane production conditions and the corresponding changes of the organic contents in the anaerobic system. The results showed that, the hydrogen production of substrate systems was positively correlated with the methane production performance, namely in the sequence of hydrogen production abound systi>hydrogen production deficient systi>non-hydrogen production system; when the inoculation amount increased, the methane production efficiency of the system was decreased, and the difference between the systems gradually got narrowed. Hydrogen production surplus system of 30% inoculation volume had the optimal methane production performance, and the average methane production rate was 0.54 mL/(g·d), reached 87.04% of methane concentration peak on the 27th day, and the highest accumulative methane yield was 1659 mL. It's mainly due to the large amount of TVFA degradation in this system (17565 mg COD/L), accounting for 50% of the degradation of TCOD (35384 mg/L).
- residue of hydrogen production /
- combined anaerobic fermentation /
- methane production /
- inoculation volume /
- moderate temperature

HTML全文

参考文献(35)

[1]	ZHANG J X,LI W L,LEE Jonathan,et al.Enhancement of biogas production in anaerobic co-digestion of food waste and waste activated sludge by biological co-pretreatment[J].Energy,2017,137(10):479-486.
[2]	KAI F,HUAN L,ZHOU D,et al.Effect of pre-fermentation types on the potential of methane production and energy recovery from food waste[J].Renewable Energy,2020,146(2):1588-1595.
[3]	SILVA F M S,MAHLER C F,OLIVEIRA L B,et al.Hydrogen and methane production in a two-stage anaerobic digestion system by co-digestion of food waste,sewage sludge and glycerol[J].Waste Management,2018,76(6):339-349.
[4]	LINDNER J,ZIELONKA S,OECHSNER H,et al.Is the continuous two-stage anaerobic digestion process well suited for all substrates?[J].Bioresource Technology,2016,200(2):470-476.
[5]	RAWOOF S A A,SENTHIL K P,VO D V N,et al.Sequential production of hydrogen and methane by anaerobic digestion of organic wastes:a review[J].Environmental Chemistry Letters,2021,19(2):1043-1063.
[6]	XIE S H,WICKHAM R,NGHIEM L D.Synergistic effect from anaerobic co-digestion of sewage sludge and organic wastes[J].International Biodeterioration & Biodegradation,2017,116(1):191-197.
[7]	XIE S H,HAI F I,ZHAN X M,et al.Anaerobic co-digestion:a critical review of mathematical modelling for performance optimization[J].Bioresource Technology,2016,222:498-512.
[8]	CHIU S L H,LO I M C.Reviewing the anaerobic digestion and co-digestion process of food waste from the perspectives on biogas production performance and environmental impacts[J].Environmental Science and Pollution Research,2016,23(24):24435-24450.
[9]	BALDI F,PECORINI I,IANNELLI R.Comparison of single-stage and two-stage anaerobic co-digestion of food waste and activated sludge for hydrogen and methane production[J].Renewable Energy,2019,143(12):1755-1765.
[10]	CHEN Y G,LIU H,ZHENG X,et al.New method for enhancement of bioenergy production from municipal organic wastes via regulation of anaerobic fermentation process[J].Applied Energy,2017,196(6):190-198.
[11]	LI Z P,CHEN Z,YE H,et al.Anaerobic co-digestion of sewage sludge and food waste for hydrogen and VFA production with microbial community analysis[J].Waste Management,2018,78(8):789-799.
[12]	WANG G J,LI Q,CHAOSUI Y W,et al.Biochar triggers methanogenesis recovery of a severely acidified anaerobic digestion system via hydrogen-based syntrophic pathway inhibition[J].International Journal of Hydrogen Energy,2021,46(15):9666-9677.
[13]	LI Y,CHEN Y G,WU J.Enhancement of methane production in anaerobic digestion process:a review[J].Applied Energy,2019,240(4):120-137.
[14]	蒋金和,尹芳,王昌梅.两相厌氧消化产氢产甲烷研究进展[J].环保科技,2019,25(5):46-55.
[15]	HAGOS K,ZONG J P,LI D X,et al.Anaerobic co-digestion process for biogas production:progress,challenges and perspectives[J].Renewable and Sustainable Energy Reviews,2017,76(9):1485-1496.
[16]	MUSTAFA A M,CHEN X,LIN H J,et al.Effect of ammonia concentration on hythane (H₂ and CH₄) production in two-phase anaerobic digestion[J].International Journal of Hydrogen Energy,2019,44(50):27297-27310.
[17]	SRISOWMEYA G,CHAKRAVARTHY M,NANDHINI DEVI G.Critical considerations in two-stage anaerobic digestion of food waste:a review[J].Renewable and Sustainable Energy Reviews,2020,119:10958.
[18]	RAFIEENIA R,GIROTTO F,PENG W,et al.Effect of aerobic pre-treatment on hydrogen and methane production in a two-stage anaerobic digestion process using food waste with different compositions[J].Waste Management,2017,59(2):194-199.
[19]	陈建勇.污泥-餐厨垃圾联合厌氧发酵产氢余物产甲烷研究[D].福州:福建师范大学,2012.
[20]	何美龙.基于基质调理提升污泥厌氧消化产甲烷效能研究[D].福州:福建师范大学,2018.
[21]	LOGAN B E,OH S E,KIM I S,et al.Biological hydrogen production measured in batch anaerobic respirometers[J].Environmental Science & Technology,2002,36(11):2530-2535.
[22]	中华人民共和国建设部.CJ/T 221-2005城市污水处理厂污泥检验方法[S].
[23]	KAYHANIAN M.Ammonia inhibition in high-solids biogasification:an overview and practical solutions[J].Environmental Technology Letters,1999,20(4):355-365.
[24]	MASUKO T,MINAMI A,IWASAKI N,et al.Carbohydrate analysis by a phenol-sulfuric acid method in microplate format[J].Analytical biochemistry,2005,339(1):69-72.
[25]	LI Y Y,JIN Y Y,LI J H,et al.Effects of thermal pretreatment on the biomethane yield and hydrolysis rate of kitchen waste[J].Applied Energy,2016,172(6):47-58.
[26]	PAN Y,ZHI Z X,ZHEN G Y,et al.Synergistic effect and biodegradation kinetics of sewage sludge and food waste mesophilic anaerobic co-digestion and the underlying stimulation mechanisms[J].Fuel,2019,253(10):40-49.
[27]	LIU C Y,LI H,ZHANG Y Y,et al.Improve biogas production from low-organic-content sludge through high-solids anaerobic co-digestion with food waste[J].Bioresource Technology,2016,219(22):252-260.
[28]	杨玉婷,周俊,张雪英,等.接种量及秸秆加入量对城市污泥厌氧发酵产气特性的影响[J].生物加工过程,2015,13(2):13-18.
[29]	蒲贵兵,王胜军,孙可伟.接种量对泔脚发酵产氢余物甲烷化的强化研究[J].中山大学学报(自然科学版),2009,48(1):87-92,97.
[30]	LIU J W,ZHAO M F,CHEN L,et al.The effect of microwave pretreatment on anaerobic co-digestion of sludge and food waste:performance,kinetics and energy recovery[J].Environmental Research,2020,189(20):109856.
[31]	LUO J Y,CHEN Y G,FENG L Y.Polycyclic aromatic hydrocarbon affects acetic acid production during anaerobic fermentation of waste activated sludge by altering activity and viability of acetogen[J].Environmental Science & Technology,2016,50(13):6921-6929.
[32]	PAUDEL S,KANG Y J,YOOC Y S,et al.Effect of volumetric organic loading rate (OLR) on H₂ and CH₄ production by two-stage anaerobic co-digestion of food waste and brown water[J].Waste Management,2016,61(3):484-493.
[33]	CHEN X,YUAN H R,ZOU D X,et al.Improving biomethane yield by controlling fermentation type of acidogenic phase in two-phase anaerobic co-digestion of food waste and rice straw[J].Chemical Engineering Journal,2015,273(11):254-260.
[34]	WANG Q H,KUNINOBU M,OGAWA H I,et al.Degradation of volatile fatty acids in highly efficient anaerobic digestion[J].Biomass & Bioenergy,1999,16(6):407-416.
[35]	GIOANNIS G D,MUNTONI A,POLETTINI A,et al.Energy recovery from one- and two-stage anaerobic digestion of food waste[J].Waste Management,2017,68(10):595-602.