双极膜电渗析法去除水溶液中Cr(Ⅵ)

戴丽萍; 朱汉权; 柯雄; 陈日耀; 刘耀兴

doi:10.13205/j.hjgc.202111011

双极膜电渗析法去除水溶液中Cr(Ⅵ)

doi: 10.13205/j.hjgc.202111011

1. 福建师范大学环境科学与工程学院福建省污染控制与资源循环利用重点实验室, 福州 350007;
2. 中国检验认证集团福建有限公司, 福州 350015

基金项目:

国家自然科学基金青年基金资助项目（21507069）。

详细信息

作者简介:
戴丽萍(1996-),女,硕士研究生,主要研究方向为膜科学和环境电化学。1325960983@qq.com

通讯作者:
刘耀兴(1983-),男,博士,副教授,主要研究方向为膜科学和环境电化学等。yxliu19830218@fjnu.edu.cn

计量
- 文章访问数: 114
- HTML全文浏览量: 2
- PDF下载量: 5
- 被引次数: 0
出版历程
- 收稿日期: 2020-08-21
- 网络出版日期: 2022-01-26

REMOVAL OF HEXAVALENT CHROMIUM FROM AQUEOUS SOLUTION USING BIPOLAR MEMBRANE ELECTRODIALYSIS TECHNIQUE

1. Fujian Key Laboratory of Pollution Control and Resource Reuse, College of Environmental Science and Engineering, Fujian Normal University, Fuzhou 350007, China;
2. China Certification & Inspection Group Fujian Co., Ltd, Fuzhou 350015, China

摘要

摘要: 运用双极膜电渗析法（BMED）去除模拟废水中的Cr（Ⅵ）并以H₂CrO₄的形式对其进行回收。探究了电解质浓度、电流密度、Cr（Ⅵ）初始浓度对Cr（Ⅵ）去除的影响。结果表明：当Cr（Ⅵ）初始浓度为500 mg/L时，电解质浓度为1 g/L，电流密度为2 mA/cm²时，Cr（Ⅵ）去除率最高为97.6%。当在BMED中串联2个和3个废水室时，可有效降低单位去除能耗，提高电流效率，且所有废水室中Cr（Ⅵ）去除率均>97.0%。随着废水室的数量从1增加到2和3，单位去除能耗分别从19.49×10^-3 kW·h/g降低到7.76×10^-3，4.17×10^-3 kW·h/g，电流效率分别从31.5%提高到125.8%和284.4%。双极膜电渗析法可作为一种从水溶液中去除和回收Cr（Ⅵ）的有效方法。
- 电渗析 /
- 双极膜 /
- Cr(Ⅵ) /
- 回收
Abstract: In the present work, a bipolar membrane electrodialysis(BMED) was used to remove and recover hexavalent chromium[Cr(Ⅵ)] in form of H₂CrO₄ from the simulated wastewater. The effects of electrolyte concentration in wastewater, current density, and initial Cr(Ⅵ) concentration on removal of Cr(Ⅵ) were investigated. The experimental results showed that the electrolyte concentration of 1 g/L and current density of 2 mA/cm² were the optimal experimental conditions when initial Cr(Ⅵ) concentration was 500 mg/L, and the removal rate was 97.6%. A higher current efficiency (CE) and a lower specific energy consumption (SEC) were obtained when two and three wastewater compartment were equipped in the BMED system and Cr(Ⅵ) removal rates in all wastewater compartments were higher than 97.0%. With the increase in the number of equipped wastewater compartment from one to two and three in the BMED system, CE increased from 31.5% to 125.8% and 284.4%, SEC decreased from 19.49×10^-3 to 7.76×10^-3, 4.17×10^-3 kW·h/g Cr(Ⅵ), respectively. Experimental results showed that the BMED was an effective method for the removal and recovery of Cr(Ⅵ) from aqueous solution.
- electrodialysis /
- bipolar membrane /
- Cr(Ⅵ) /
- removal

HTML全文

参考文献(19)

[1]	LONG B B, YE J E, YE Z, et al. Cr(Ⅵ) removal by Penicillium oxalicum SL2:reduction with acidic metabolites and form transformation in the mycelium[J]. Chemosphere, 2020, 253:126731.
[2]	ZHANG L, NIU W Y, SUN J, et al. Efficient removal of Cr(Ⅵ) from water by the uniform fiber ball loaded with polypyrrole:static adsorption, dynamic adsorption and mechanism studies[J]. Chemosphere, 2020, 248:126102.
[3]	ZHAO Z Y, AN H, LIN J, et al. Progress on the photocatalytic reduction removal of chromium contamination[J]. Chemical Record, 2019, 19(5):873-882.
[4]	ZHENG Y R, LIU S G, DAI C M, et al. Study on the influence mechanism of underground mineral element Fe(Ⅱ) on Cr(Ⅵ) transformation under subsurface and groundwater interaction zones[J]. Environmental Sciences Europe, 2020, 32(1):62.
[5]	PARANI S, OLUWAFEMI O S. Selective and sensitive fluorescent nanoprobe based on AgInS₂-ZnS quantum dots for the rapid detection of Cr (Ⅲ) ions in the midst of interfering ions[J]. Nanotechnology, 2020, 31(39):395501.
[6]	TABATABAEI S, RAD B F, BAGHDADI M. Semicontinuous enhanced electroreduction of Cr(Ⅵ) in wastewater by cathode constructed of copper rods coated with palladium nanoparticles followed by adsorption[J]. Chemosphere, 2020, 251:126309.
[7]	XIA S P, SONG Z L, JEYAKUMAR P, et al. A critical review on bioremediation technologies for Cr(Ⅵ)-contaminated soils and wastewater[J]. Critical Reviews in Environmental Science and Technology, 2019, 49(12):1027-1078.
[8]	张立剑, 周睿. 活性炭材料对Cr(Ⅵ)的吸附研究[J]. 水处理技术, 2018, 44(8):49-52.
[9]	石林, 段睿, 杨翠英, 等. 常温还原铁氧体法处理含铬废水[J]. 环境工程学报, 2015, 9(8):3883-3888.
[10]	梅丽娟, 殷仕学, 朴哲, 等. 一种耐Cr(Ⅵ)微生物筛选新方法[J]. 环境科学与技术, 2019, 42(5):41-45.
[11]	ZHENG Y Q, CHENG B, YOU W, et al. 3D hierarchical graphene oxide-NiFe LDH composite with enhanced adsorption affinity to Congo red, methyl orange and Cr(Ⅵ) ions[J]. Journal of Hazardous Materials, 2019, 369:214-225.
[12]	冯西平, 冯婷希. 亚硫酸氢钠处理电镀废水中铬的实验研究[J]. 电镀与环保, 2018, 38(1):64-67.
[13]	MOHAMED A, YU L, FANG Y, et al. Iron mineral-humic acid complex enhanced Cr(Ⅵ) reduction by Shewanella oneidensis MR-1[J]. Chemosphere, 2020, 247:125902.
[14]	CAI Y Y, HAN Z P, LIN X C, et al. Study on removal of phosphorus as struvite from synthetic wastewater using a pilot-scale electrodialysis system with magnesium anode[J]. Science of the Total Environment, 2020, 726:138221.
[15]	陈日耀. 纳米SiO₂改性海藻酸钠/壳聚糖双极膜的制备与表征[J]. 高校化学工程学报, 2012, 26(1):160-164.
[16]	LIU Y X, KE X, ZHU H Q, et al. Treatment of raffinate generated via copper ore hydrometallurgical processing using a bipolar membrane electrodialysis system[J]. Chemical Engineering Journal, 2020, 382:122956.
[17]	HERRERO-GONZALEZ M, DIAZ-GURIDI P, DOMINGUEZ-RAMOS A, et al. Highly concentrated HCl and NaOH from brines using electrodialysis with bipolar membranes[J]. Separation and Purification Technology, 2020, 242:116785.
[18]	İPEKÇI D, KABAY N, BUNANI S, et al. Application of heterogeneous ion exchange membranes for simultaneous separation and recovery of lithium and boron from aqueous solution with bipolar membrane electrodialysis (EDBM)[J]. Desalination, 2020, 479:114313.
[19]	KRAVTSOV V, KULIKOVA I, MIKHAYLIN S, et al. Alkalinization of acid whey by means of electrodialysis with bipolar membranes and analysis of induced membrane fouling[J]. Journal of Food Engineering, 2020, 277:109891.