草酸浸出和太阳光催化回收赤泥中的铁和铝

黄荃莅; 黄魁; 卢远桓; 刘玉玲; 熊昊; 董海丽

doi:10.13205/j.hjgc.202112030

草酸浸出和太阳光催化回收赤泥中的铁和铝

doi: 10.13205/j.hjgc.202112030

广西大学资源环境与材料学院, 南宁 530004

基金项目:

广西大学科研基金(XJZ140336)

国家自然科学基金(21767003)

广西大学广西有色金属及特色材料加工重点实验室开放基金(GXKFJ12-16,GXKFJ16-03)。

详细信息

作者简介:
黄荃莅(1995-),女,硕士研究生,主要研究方向为固体废弃物处理与处置。huangquanli0612@qq.com

通讯作者:
黄魁(1981-),男,副教授,主要研究方向为固体废弃物处理与处置。khuang@gxu.edu.cn

计量
- 文章访问数: 245
- HTML全文浏览量: 65
- PDF下载量: 3
- 被引次数: 0
出版历程
- 收稿日期: 2020-11-10
- 网络出版日期: 2022-03-30
- 刊出日期: 2022-03-30

RECOVERY OF IRON AND ALUMINUM FROM RED MUD BY OXALIC ACID LEACHING AND SOLAR PHOTOCATALYSIS

School of Resources, Environment and Materials, Guangxi University, Nanning 530004, China

摘要

摘要: 系统研究了草酸浸出赤泥中铁和铝的过程,探究了草酸浓度、反应时间、反应温度和液固比对铁和铝浸出率的影响。在此基础上,利用响应面实验优化浸出过程,同时采用太阳光照射草酸浸出液,将草酸铁还原成草酸亚铁沉淀,实现浸出液的回收再利用。结果表明:回归方程模型显著,草酸浸出赤泥的最佳工艺条件为草酸浓度为0.30 g/mL,液固比为14∶1,反应温度为95℃,反应时间为150 min。在此条件下,铁和铝的浸出率分别为87.76%和74.60%。太阳光照射催化浸出液420 min内,总铁含量从1.152 g/L下降至0.173 g/L,85%以上的草酸铁以草酸亚铁沉淀形式得以回收。再通过调节pH,过滤及蒸发结晶后可回收滤液中的铝和草酸。这为赤泥中铁和铝的回收提供了新的技术路线选择。
- 赤泥 /
- 草酸浸出 /
- 响应面 /
- 有价金属
Abstract: The process of extraction of iron and aluminum from red mud by using oxalic acid leaching was investigated systematically. The effect of oxalic acid addition, leaching time, leaching temperature and liquid to solid ratio on the leaching efficiency were investigated respectively, and the response surface method was used to the optimize the preparation process based on the single-factor experiment results. The Fe(Ⅲ) oxalate in the leaching solution was reduced to Fe(Ⅱ) oxalate by using sunlight irradiation. The experiment results showed that the regression equation model was of great significant. The optimized processing conditions for leaching rate were as follows: the oxalic acid concentration of 0.30 g/mL, the liquid-solid ratio of 14∶1, reaction temperature of 95 ℃, reaction time of 150 min. Under the optimal conditions, the leaching rates of iron and aluminum were up to 87.76% and 74.60%, respectively. The total iron concentration decreased from 1.152 g/L to 0.173 g/L in the extracted solution, and more than 85% Fe(Ⅲ) oxalate was transformed into the Fe(Ⅱ) oxalate crystallite within 420 min by using sunlight irradiation. The aluminum and oxalic acid in the filtrate could be recovered by means of adjusting pH value, filtration, and evaporation crystallization successively. The study provides new technical routine for the recovery of iron and aluminum from red mud.
- red mud /
- oxalic acid leaching /
- response surface /
- valuable metals

HTML全文

参考文献(24)

[1]	张利祥,高一强,黄建洪,等.赤泥资源化综合利用研究进展[J].硅酸盐通报,2020,39(1):144-149.
[2]	LIU W C,YANG J K,XIAO B.Review on treatment and utilization of bauxite residues in China[J].International Journal of Mineral Processing,2009,93(3/4):220-231.
[3]	YU F Q,LIN H F,WANG C,et al.Recovery of Fe and Al from red mud by a novel fractional precipitation process[J].Environmental Science and Pollution Research,2020,27(13):14642-14653.
[4]	薛生国,李玉冰,郭颖.氧化铝工业赤泥环境影响研究进展[J].中国科学院大学学报,2017,34(4):401-412.
[5]	赵琳,刘含笑,陈招妹,等.氧化铝赤泥的产生、危害及处置方式初探[C]//环境工程2018年全国学术年会,2018.
[6]	滕春英,周康根,宁凌峰,等.盐酸分级浸出赤泥中有价金属元素[J].环境工程学报,2018,12(1):310-315.
[7]	AGRAWAL S,RAYAPUDI V,DHAWAN N.Extraction of Iron values from red mud[J].Materials Today:Proceedings,2018,5(9):17064-17072.
[8]	ZHU D Q,CHUN T J,PAN J,et al.Recovery of iron from high-iron red mud by reduction roasting with adding sodium salt[J].Journal of Iron and Steel Research International,2012,19(8):1-5.
[9]	谢天鉴,谢克强,刘俊场,等.拜耳法赤泥回收有价金属试验研究[J].云南冶金,2020,49(3):68-72.
[10]	吴烈善,苏翠翠,吕宏虹,等.赤泥酸浸出铁、铝的工艺条件研究及其表征[J].工业安全与环保,2014,40(12):71-74.
[11]	高燕.广西平果铝厂赤泥两段酸浸铝铁工艺研究[D].太原:太原理工大学,2014.
[12]	刘付朋,刘志宏,李玉虎,等.锌粉置换镓锗渣草酸浸出过程[J].中国有色金属学报,2017,27(10):2154-2163.
[13]	BISWAS S,CHAKRABORTY S,CHAUDHURI M G,et al.Optimization of process parameters anddissolution kinetics of nickel and cobalt fromlateritic chromite overburden using organic acids[J].Journal of Chemical Technology & Biotechnology,2014,89(10):1491-1500.
[14]	HU P C,ZHANG Y M,LIU T,et al.Separation and recovery of iron impurity from a vanadium-bearing stone coal via an oxalic acid leaching-reduction precipitation process[J].Separation & Purification Technology,2017,180:99-106.
[15]	AMBIKADEVI V R,LALITHAMBIKA M.Effect of organic acids on ferric iron removal from iron-stained kaolinite[J].Applied Clay Science,2000,16(3):133-145.
[16]	YU Z L,SHI Z X,CHEN Y M,et al.Red-mud treatment using oxalic acid by UV irradiation assistance[J].Transactions of Nonferrous Metals Society of China,2012,22(2):456-460.
[17]	YANG Y,WANG X Y,WANG M Y,et al.Recovery of iron from red mud by selective leach with oxalic acid[J].Hydrometallurgy.2015,157:239-245.
[18]	徐丽.太阳光下天然铁砂非均相FENTON反应降解染料废水的研究[D].秦皇岛:燕山大学,2012.
[19]	POZDNYAKOV I P,KEL O V,PLYUSNIN V F,et al.New insight into photochemistry of ferrioxalate[J].The Journal of Physical Chemistry A,2008,112(36):8316-8322.
[20]	MONTEAGUDO J M,DURÁN A,AGUIRRE M,et al.Optimization of the mineralization of a mixture of phenolic pollutants under a ferrioxalate-induced solar photo-Fenton process[J].Journal of Hazardous Materials,2011,185(1):131-139.
[21]	KATSUMATA H,OKADA T,KANECO S,et al.Degradation of fenitrothion by ultrasound/ferrioxalate/UV system[J].Ultrasonics Sonochemistry,2010,17(1):200-206.
[22]	郝帅,李诚,席艺慧,等.拜耳法赤泥中钪的两步盐酸浸出工艺研究[J].环境工程,39(1):136-141,200.
[23]	YANG Y,WANG X Y,WANG M Y,et al.Iron recovery from the leached solution of red mud through the application of oxalic acid[J].International Journal of Mineral Processing,2016,157:145-151.
[24]	PRATO-Garcia D,VASQUEZ-Medrano R,HERNANDEZ-ESPARZA M.Solar photoassisted advanced oxidation of synthetic phenolic wastewaters using ferrioxalate complexes[J].Solar Energy,2009,83(3):306-315.