绝缘油污染土壤微波脱附试验

车凯; 韩忠阁; 郁金星; 陈崇明; 刘松涛; 谷兴家

doi:10.13205/j.hjgc.202202020

绝缘油污染土壤微波脱附试验

doi: 10.13205/j.hjgc.202202020

1. 国网河北省电力有限公司电力科学研究院, 石家庄 050021;
2. 华北电力大学环境科学与工程学院, 河北保定 071003

基金项目:

国家电网公司科技项目“变电站土壤环境污染风险评估与无害化处置关键技术研究”(5204DY19000A)

详细信息

作者简介:
车凯(1985-),男,硕士,高级工程师,主要从事电力环境及场地污染研究。chekai311@163.com

计量
- 文章访问数: 191
- HTML全文浏览量: 33
- PDF下载量: 9
- 被引次数: 0
出版历程
- 收稿日期: 2021-03-17
- 网络出版日期: 2022-04-02
- 刊出日期: 2022-04-02

EXPERIMENTAL STUDY ON MICROWAVE DESORPTION OF SOIL CONTAMINATED BY INSULATING OIL

1. State Grid Hebei Electric Power Research Institute, Shijiazhuang 050021, China;
2. School of Environmental Science and Engineering, North China Electric Power University, Baoding 071003, China

摘要

摘要: 采用微波-热重反应装置,针对绝缘油污染土壤进行微波热脱附试验,考察不同温度下绝缘油脱附效率以及污染土壤失重规律,并在此基础上对土壤中残余绝缘油组分及分布进行分析。结果表明:当温度达到400℃以上时,土壤中绝缘油去除效果较好,绝缘油去除率可达到98.6%,能够满足土壤修复要求。含油土壤随着温度升高主要经历水分挥发、易挥发性有机物析出、难挥发性有机物析出等阶段,在100~200℃阶段,主要是土壤中水分和部分低挥发性有机物析出;在400~500℃阶段,主要是土壤中绝缘油析出。土壤中绝缘油的成分以C12—C21烷烃类化合物和5~6环芳香烃为主,当温度达到400℃以后,绝缘油中各组分逐步被完全脱附,综合考虑脱附效率和经济性原则,绝缘油污染土壤脱附温度以400~450℃为宜。
- 绝缘油 /
- 土壤 /
- 微波脱附 /
- 失重
Abstract: Microwave-thermogravimetric reaction device was used to conduct microwave thermal desorption test for insulating oil contaminated soil. The desorption efficiency of insulating oil and the weightlessness rule of contaminated soil were investigated at different temperatures. Based on this, the composition and distribution of residual insulating oil in soil were analyzed. The results showed that when the temperature was above 400 ℃, the removal efficiency of insulating oil in soil was better, and the removal rate of insulating oil could reach 98.6%, which met the requirements of soil remediation. With the increase of temperature, the oil-bearing soil mainly experienced the stages of moisture volatilization, volatile organic compounds and volatile organic compounds. At the stage of 100~200 ℃, moisture and some low volatile organic compounds in the soil were mainly precipitated. At the stage of 400~500 ℃, the insulating oil in the soil was mainly precipitated. The main components of insulating oil in soil were C12—C21 alkanes and 5~6 cyclic aromatic hydrocarbons. When the temperature reached 400 ℃, each component of insulating oil was gradually desorbed completely. Considering the principles of desorption efficiency and economy, the appropriate desorption temperature for insulating oil contaminated soil was between 400 ℃ and 450 ℃.
- insulating oil /
- soil /
- microwave desorption /
- weightlessness

HTML全文

参考文献(26)

[1]	周一恒,严家明,吴新忠,等.矿山电力变压器油纸绝缘老化的微观结构及放电特性研究[J].电测与仪表,2020,57(22):40-45 ,54.
[2]	刘佳.废变压器油中污染物及环境风险评价研究[D].保定:华北电力大学,2015.
[3]	侯朝鹏,李永丹,夏国富,等.典型单环和双环芳烃加氢热力学分析[J].石油化工,2013,42(6):625-631.
[4]	韩超,陈彬,刘阁.颗粒污染物对变压器油理化性能的影响[J].石油学报(石油加工),2016,32(6):1156-1163.
[5]	勾立争,刘长波,刘诗诚,等.热脱附法修复多环芳烃和汞复合污染土壤实验研究[J].环境工程,2018,36(2):184-187 ,146.
[6]	ENUNEKU A,OGBEIDE O,OKPARA B,et al.Ingestion and Dermal Cancer Risk Via Exposure to Polycyclic Aromatic Hydrocarbons (PAHs) Contaminated Soils in an Oil Producing Community,Niger Delta,Nigeria[J].Environmental Toxicology and Chemistry,2020,40(1).
[7]	车凯,郁金星,刘松涛,等.河北南部变电站场地土壤中PAHs含量、来源及健康风险[J].中国环境科学,2020,40(11):4865-4874.
[8]	王嫣云,冯真,周泽军,等.油污染场地土壤热解终温试验研究[J].安全与环境学报,2017,17(6):2287-2291.
[9]	邢汉君,蒋俊,李晶,等.有机氯农药污染土壤异位热脱附修复研究[J].湖南农业科学,2019(11):62-64,68.
[10]	赵中华,李晓东,陈彤,等.多氯联苯污染土壤热脱附研究综述[J].生态毒理学报,2016,11(2):61-68.
[11]	刘珑,王殿生,曾秋孙,等.微波修复石油污染土壤升温特性影响因素的实验研究[J].环境工程学报,2011,5(4):898-902.
[12]	林莉.典型化工污染土壤的微修复技术研究[D].武汉:华中科技大学,2010.
[13]	周翠红,王世晗,周怡.响应曲面法优化微波修复二甲苯污染土壤工艺参数[J].环境污染与防治,2020,42(3):259-263.
[14]	吴风光.微波辐射修复Cr(Ⅵ)污染土壤的研究[D].长沙:湖南大学,2013.
[15]	赵涛,马刚平,周宇,等.多环芳烃类污染土壤热脱附修复技术应用研究[J].环境工程,2017,35(11):178-181.
[16]	姚高扬,冯钦忠,陈扬,等.热解析技术处理汞污染土壤研究进展[J].环境工程,2017,35(10):179-183.
[17]	TAI H S,JOU C G.Immobilization of chromium-contaminated soil by means of microwave energy[J].Journal of Hazardous Materials,1999,65(3):267-275.
[18]	刘娜,赵维,赵浩,等.微波修复氯丹污染土壤中氯丹降解的影响因素研究[J].环境污染与防治,2012,34(5):43-47.
[19]	YUAN S H,TIAN M,LU X H.Microwave remediation of soil contaminated with hexachlorobenzene[J].Journal of Hazardous Materials,2006,137(2):878-885.
[20]	LIU X T,ZHANGQ,ZHANG G X,et al.Application of microwave irradiation in the removal of polychlorinated biphenyls from soil contaminated by capacitor oil[J].Chemosphere,2008,72(11):1655-1658.
[21]	林莉,陈静,王玲丽,等.几种敏化剂对微波降解土壤中氯霉素的影响[J].环境化学,2010,29(3):421-424.
[22]	PIETRO P F,GUIDO D G,ALFIO C,et al.Remediation of soils contaminated with pahs and nitro-pahs using microwave irradiation[J].Chemical Engineering Journal,2016,296:162-172.
[23]	王星,王欣,郭斌,等.微波脱附挥发性有机物污染土壤修复技术研究[J].应用化工,2020,49(3):638-640.
[24]	周翠红,王世晗,周怡.响应曲面法优化微波修复二甲苯污染土壤工艺参数[J].环境污染与防治,2020,42(3):259-263.
[25]	魏晓丽,龙军,白风宇,等.直馏石脑油催化裂解反应中甲烷的生成[J].石油学报(石油加工),2014,30(3):379-385.
[26]	赵涛,马刚平,周宇,等.多环芳烃类污染土壤热脱附修复技术应用研究[J].环境工程,2017,35(11):178-181.