农业废弃物秸秆用于道路抑尘剂制备的研究

梁文俊; 张志学; 兰童; 任思达

doi:10.13205/j.hjgc.202202026

农业废弃物秸秆用于道路抑尘剂制备的研究

doi: 10.13205/j.hjgc.202202026

北京工业大学区域大气复合污染防治北京市重点实验室, 北京 100124

基金项目:

北京市科学技术委员会科技计划(Z191100009119002)

详细信息

通讯作者:
梁文俊(1978-),男,博士,教授,主要从事大气污染防治技术研究。liangwenj@bjut.edu.cn

计量
- 文章访问数: 294
- HTML全文浏览量: 69
- PDF下载量: 15
- 被引次数: 0
出版历程
- 收稿日期: 2021-03-31
- 网络出版日期: 2022-04-02
- 刊出日期: 2022-04-02

PREPARATION OF ROAD DUST SUPPRESSANT WITH AGRICULTURAL WASTE STRAW

Beijing Key Laboratory of Regional Air Composite Pollution Prevention and Control, Beijing University of Technology, Beijing 100124,China

摘要

摘要: 以玉米秸秆为主要原料,采用纤维素酶对其进行酶解,通过添加环境友好型助剂,制备出一种可用于道路扬尘控制的环保型道路抑尘剂。采用响应面法优化制备了该抑尘剂,并对所制备抑尘剂产品的吸湿保湿性能及表面张力等参数进行了测试表征;以抑尘剂吸水率为评价指标,确定木聚糖酶、酸性纤维素酶、纤维二糖酶和β-葡聚糖酶的最佳质量比为2∶2∶1∶1;以抑尘剂物化性能和实际性能确定出秸秆∶丙三醇∶氯化镁∶α-烯基磺酸钠∶聚丙烯酰胺的最佳质量比为1∶4∶3∶0.05∶0.001(干重)。所开发抑尘剂具有良好的润湿性能及抗蒸发性能,在7.8 m/s风速下,2 h内抑尘率达到100%。
- 秸秆 /
- 纤维素酶解液 /
- 道路抑尘剂 /
- 响应面法
Abstract: An environment-friendly road dust suppressant was prepared by using corn straw as the main raw material, enzymatic hydrolysis of straw with cellulase and environmental-friendly additives. The moisture absorption, moisture retention and surface tension of the dust suppressor were tested and characterized. The response surface methodology was also used to optimize the formula of dust suppression agent and prepare the samples of dust suppression agent. The optimal mass ratio of xylanase, acid cellulase, cellulobiase and β-glucanase was 2∶2∶1∶1, in which the water absorption rate of dust suppression agent was used as the evaluation index. The optimal mass ratio of straw∶glycerol∶magnesium chloride∶α-enyl sulfonate∶polyacrylamide was 1∶4∶3∶0.05∶0.001 based on the physical and chemical properties and practical performance of dust depressant. The developed dust suppressant had good wettability and anti-evaporation performance while the dust suppression rate could reach 100% within 2 hours at the wind speed of 7.8 m/s.
- straw /
- cellulase hydrolysate /
- road dust suppressant /
- response surface method

HTML全文

参考文献(29)

[1]	TONG R P,LIU J F,WANG W,et al.Health effects of PM_2.5 emissions from on-road vehicles during weekdays and weekends in Beijing,China[J].Atmospheric Environment,2020,223(C):117258.
[2]	ASKARIYEH M H,VENUGOPAL M,KHREIS H,et al.Near-road traffic-related air pollution:resuspended PM_2.5 from highways and arterials[J].International Journal of Environmental Research and Public Health,2020,17(8):2851.
[3]	牛璨,张文璇,张宪,等.保定市大气细颗粒物的来源解析[J].节能与环保,2021(1):36-38.
[4]	刘小真,任羽峰,刘忠马,等.南昌市大气颗粒物污染特征及PM_2.5来源解析[J].环境科学研究,2019,32(9):1546-1555.
[5]	崔冬冬,薛海涛,于振波.城市扬尘污染控制技术研究[J].科学技术创新,2020(1):29-30.
[6]	FAN T,ZHOU G,WANG G Y.Preparation and characterization of a wetting-agglomeration-based hybrid coal dust suppressant[J].Process Safety and Environmental Protection,2018,113:282-291.
[7]	JIN X,WU L S,LI P,et al.Study on preparation and application effect of high-efficiency wetting type dust suppressant[J].Advances in Environmental Protection,2019,9(1):64-70.
[8]	郑向军,李晋生,薛峰,等.新型环保道路抑尘剂在城市道路的应用[J].环境工程技术学报,2014,4(2):169-172.
[9]	ZHOU G,MA Y L,FAN T,et al.Preparation and characteristics of a multifunctional dust suppressant with agglomeration and wettability performance used in coal mine[J].Chemical Engineering Research and Design,2018,132:729-742.
[10]	WU M Y,HU X J,ZHANG Q,et al.Preparation and performance evaluation of environment-friendly biological dust suppressant[J].Journal of Cleaner Production,2020,273:123162.
[11]	ZHANG H H,NIE W,WANG H K,et al.Preparation and experimental dust suppression performance characterization of a novel guar gum-modification-based environmentally-friendly degradable dust suppressant[J].Powder Technology,2018,339:314-325.
[12]	周治.我国农业秸秆高值化利用现状与困境分析[J].中国农业科技导报,2021,23(2):9-16.
[13]	丁丽.我国农作物秸秆利用现状及对策[J].河南农业,2017(1):23.
[14]	石祖梁,贾涛,王亚静,等.我国农作物秸秆综合利用现状及焚烧碳排放估算[J].中国农业资源与区划,2017,38(9):32-37.
[15]	WEN P Y,XU Y,ZHANG J H.Alkaline incubation improves the saccharification of poplar after sodium chlorite pretreatment with ultra-low cellulase loading[J].Renewable Energy,2021,170:517-524.
[16]	李俊杰,袁勇,曹进军,等.多功能型抑尘剂在露天矿山路面中的应用[J].现代矿业,2020,36(7):209-211 ,256.
[17]	刘正文,谭卓英,李季阳.露天矿山运输道路厚大粉尘抑尘因子选择与性能探究[J].矿业研究与开发,2013,33(3):77-80.
[18]	刘黎明.表面活性剂强化喷雾用水润湿性能的实验研究[J].采矿技术,2021,21(1):167-169 ,176.
[19]	HE J,SHU H,ZHANG L,et al.Preparation of lignite dust suppressant by compound surfactants and effect of inorganic salt on dust suppressant[J].Advances in Materials Science and Engineering,2020:6278703.
[20]	姚俊花.道路抑尘剂在我国城市的应用现状与问题思考[J].环境保护与循环经济,2020,40(3):21-24 ,58.
[21]	蒋耀东,张雪,张雷,等.抑尘剂的研究应用现状及发展趋势[J].化工管理,2017(10):145-148.
[22]	杜翠凤,王远,卢俊杰,等.吸湿型路面抑尘剂配方研制及工业试验[J].东北大学学报(自然科学版),2015,36(6):876-881.
[23]	吴超,周勃.固体卤化物的抑尘性能[J].中南工业大学学报,1996(1):13-17.
[24]	吴超,陈军良.十二烷基苯磺酸钠对氯化钙和水玻璃溶液的渗透性影响[J].中南工业大学学报,1998(3):3-5.
[25]	王庆东,候志斌,许文杰,等.植物内切β-木聚糖酶的研究进展[J].现代农业科技,2020(4):211-213,215.
[26]	袁茂翼,叶发银,雷琳,等.纤维二糖水解酶的研究进展[J].食品与发酵工业,2017,43(10):248-255.
[27]	中国环境保护产业协会.水溶性道路抑尘剂:T/CAEPI 7—2017[S].2017.
[28]	国家铁路局.铁路煤炭运输抑尘技术条件第1部分:抑尘剂:TB/T 3210.1—2020[S].北京,2020.
[29]	戴雯婧,甘延玲,叶绿萌,等.道路施工环保型抑尘剂的制备及其性能评价[J].能源环境保护,2021,35(2):51-57.