燃煤电厂和钢铁厂排放可凝结颗粒物中有机组分研究

邓建国; 王东滨; 刘通浩; 李雪; 杨书文; 段雷; 蒋靖坤

doi:10.13205/j.hjgc.202203003

燃煤电厂和钢铁厂排放可凝结颗粒物中有机组分研究

doi: 10.13205/j.hjgc.202203003

邓建国¹,
王东滨¹,
刘通浩²,
李雪¹,
杨书文¹,
段雷^1,3,
蒋靖坤^1,3, ,

1. 清华大学环境学院, 北京 100084;
2. 中国环境监测总站国家环境保护环境监测质量控制重点实验室, 北京 100012;
3. 国家环境保护大气复合污染来源与控制重点实验室, 北京 100084

基金项目:

国家能源集团科技创新项目(GJNY-19-56)

详细信息

作者简介:
邓建国(1985-),男,硕士,主要研究方向为污染源颗粒物排放。fengxing.luotuo@163.com

通讯作者:
蒋靖坤(1980-),男,教授,博士生导师,主要研究方向为大气污染控制。jiangjk@tsinghua.edu.cn

计量
- 文章访问数: 226
- HTML全文浏览量: 48
- PDF下载量: 6
- 被引次数: 0
出版历程
- 收稿日期: 2021-07-02
- 网络出版日期: 2022-07-07

ORGANIC COMPONENTS IN CONDENSABLE PARTICLE MATTER EMITTED FROM COAL-FIRED POWER PLANTS AND STEEL PLANTS

1. School of Environment, Tsinghua University, Beijing 100084, China;
2. State Environmental Protection Key Laboratory of Quality Control in Environmental Monitoring, China Environmental Monitoring Centre, Beijing 100012, China;
3. State Environmental Protection Key Laboratory of Sources and Control of Air Pollution Complex, Beijing 100084, China

摘要

摘要: 目前我国燃煤电厂超低排放改造已基本完成,钢铁行业正在进行超低排放改造。固定源排放的可过滤颗粒物(filterable particulate matter,FPM)浓度越来越低,可凝结颗粒物(condensable particulate matter,CPM)排放逐渐引起广泛关注。揭示燃煤电厂和钢铁厂CPM中有机组分特征对于认识CPM成因及控制具有重要意义。采用稀释间接法收集了8个燃煤电厂和3个钢铁厂(2个烧结厂和1个焦化厂)烟气中的CPM,测试和分析了其中有机组分特征。结果表明:燃煤电厂CPM中有机组分含量较低,脱硫入口和总排口平均含量分别为0.082 mg/m³(0~0.331 mg/m³)和0.060 mg/m³(0~0.254 mg/m³),占CPM的比例分别为4.95%和10.1%;钢铁厂CPM中有机组分含量和比例均高于电厂,脱硫入口CPM中有机组分平均含量为1.94 mg/m³(0.408~3.98 mg/m³),占比为22.2%,经过污控措施净化后总排口CPM中有机组分平均含量为0.382 mg/m³(0.149~0.572 mg/m³),占比为11.1%。燃煤电厂CPM中有机组分主要为酯类,钢铁厂CPM中有机组分主要为烷烃类和烷酸类。2类固定源CPM中有机组分占比均相对较低,其无机组分减排工作应予以更多重视。
- 钢铁厂 /
- 燃煤电厂 /
- 可凝结颗粒物(CPM) /
- 稀释间接法 /
- 有机组分
Abstract: Nowadays, the retrofit of ultra-low emission has been finished in most coal-fired power plants, and are in process in iron and steel plants in China. The concentration of filterable particulate matters (FPM) has been greatly reduced and condensable particulate matters (CPM) have aroused more attention. The fraction of organic matter in CPM emitted from coal-fired power plants (CFPPs) and iron and steel plants remained controversial, which was important to understand the formation mechanism and to promote the emission control of CPM. We collected CPM samples by in-direct dilution method in eight CFPPs and three iron and steel plants (including two sintering and one coke making plants), and specific compositions and fraction of organic matter in CPM were analyzed. The results showed that the concentration of organic compositions from CFPPs was 0.082 mg/m³(0~0.331 mg/m³) and 0.060 mg/m³(0~0.254 mg/m³) at the inlet of flue gas desulfurization and stack, accounting for 4.95% and 10.1% of total CPM content, respectively. For iron and steel plants, the concentration and proportion of organic matter were higher in comparison with those from CFPPs, which were 1.9 mg/m³(0.408~3.98 mg/m³) and 0.382 mg/m³(0.149~0.572 mg/m³) at the inlet of flue gas desulfurization and stack, accounting for 22.2% and 11.1% of total CPM content respectively. Major compositions of organic matter in CPM from CFPPs were esters, whereas alkanes and alkanoic acids were the major composition in CPM from iron and steel plants. In a word, the fractions of organic matter at two kinds of stationary sources were relatively low, more attention should be paid on controlling its inorganic gas precursors.
- iron and steel plant /
- coal-fired power plant /
- condensable particulate matter (CPM) /
- in-direct dilution /
- organic compound

HTML全文

参考文献(19)

[1]	中国电力企业联合会.中国电力行业年度发展报告2019[M].北京:中国市场出版社,2019.
[2]	中国钢铁工业协会[EB/OL].http://www.chinaisa.org.cn/gxportal/xfgl/portal/list.html?columnId=50d99531d5dee68346653ca9548f308764ad38410a091e662834a5ed66770174.
[3]	蒋靖坤,邓建国,李振,等.固定污染源排气中PM_2.5采样方法综述[J].环境科学, 2014, 35(5):2018-2024.
[4]	蒋靖坤,邓建国,段雷,等.基于虚拟撞击原理的固定源PM₁₀/PM_2.5采样器的研制[J].环境科学, 2015, 35(10):3639-3643.
[5]	李妍菁,邓建国,王刚,等.固定源可凝结颗粒物稀释采样器的设计[J].环境科学学报, 2020, 40(5):1656-1660.
[6]	MORINO Y, CHATANI S, TANABE K, et al. Contributions of condensable particulate matter to atmospheric organic aerosol over Japan[J]. Environmental Science&Technology, 2018, 52(15):8456-8466.
[7]	FENG Y P, LI Y Z, CUI L. Critical review of condensable particulate matter[J]. Fuel, 2018, 224(1):801-813.
[8]	蒋靖坤,邓建国,王刚,等.固定污染源可凝结颗粒物测量方法研究[J].环境科学, 2019, 40(12):5234-5239.
[9]	WANG G, DENG J, ZHANG Y, et al. Evaluating airborne condensable particulate matter measurement methods in typical stationary sources in China[J]. Environmental Science&Technology, 2020, 54(1):1363-1371.
[10]	裴冰.燃煤电厂可凝结颗粒物的测试与排放[J].环境科学, 2015, 36(5):1544-1549.
[11]	祁建民,孙和泰,黄治军,等.超低排放燃煤电厂SO₃和可凝结颗粒物迁移规律研究[J].热力发电,2021,50(4):72-77.
[12]	LI J W, QI Z F, LI M, et al. Physical and chemical characteristics of condensable particulate matter from an ultralow-emission coal-fired power plant[J]. Energy&Fuels, 2017, 31(2):1778-1785.
[13]	杨柳,张斌,王康慧,等.超低排放路线下燃煤烟气可凝结颗粒物在WFGD、WESP中的转化特性[J].环境科学, 2019, 40(1):121-125.
[14]	邓建国,王刚,张莹,等.典型超低排放燃煤电厂可凝结颗粒物特征和成因[J].环境科学, 2020,41(4):1589-1593.
[15]	朱法华,李军状.我国燃煤电厂SO₃和可凝结颗粒物控制存在问题与建议[J].环境影响评价, 2019, 41(3):1-5.
[16]	YANG H H, LEE K T, HSIEH Y S, et al. Emission characteristics and chemical compositions of both filterable and condensable fine particulate from iron and steel plants[J]. Aerosol and Air Quality research,2015,15(4):1672-1680.
[17]	张莹,邓建国,王刚,等.典型钢铁焦化厂可凝结颗粒物排放特征[J].环境工程,2020,38(9):154-158.
[18]	CORIO L A, SHERWELL J. In-stack condensable particulate matter measurements and issues[J]. Journal of Air&Waste Management Association, 2000, 50(2):207-218.
[19]	邓建国,张莹,王乐冰,等.测量固定源可凝结颗粒物的稀释间接法及系统[J].环境科学学报,2020,40(11):4162-4168.[20] DING X, LI Q, WU D, LIANG Y, et al. Unexpectedly increased particle emissions from the iron and steel industry determined by wet/semidry/dry flue gas desulfurization technologies[J]. Environmental Science&Technology, 2019,53(17):10361-10370.[21] 徐静颖.典型煤种热解与燃烧过程挥发性有机组分生成与排放特性[D].北京:清华大学,2019.[22] HUANG, Y M, HUANG S X, LIN C W, et al. Evaluation of bias in the measurement of condensable particulate matter with Method 202[J]. Aerosol and Air Quality Research, 2021, 21(1)1-12.[23] 廖继勇,何国强.近五年烧结技术的进步与发展[J],烧结球团, 2018, 43(5):1-11.[24] LI J X, HE X P, PEI B, et al. The ignored emission of volatile organic compounds from iron ore sinter process[J]. Journal of Environmental Sciences, 2019,77(1):282-290.[25] 王海风,秦松,姜曦,等.钢铁工业烧结过程VOCs减排研究进展[J].钢铁, 2018,53(1):1-7. [26] YANG H H, LEE K T, HSIEH Y S, et al. Filterable and condensable fine particulate emissions from stationary sources[J]. Aerosol and Air Quality Research, 2014, 14(7):2010-2016.