退役井场老化油污土壤的生物强化修复技术

丁明山; 刘京煊; 孙楠; 袁长忠; 汪卫东; 李晓栋; 王志坚

doi:10.13205/j.hjgc.202205023

退役井场老化油污土壤的生物强化修复技术

doi: 10.13205/j.hjgc.202205023

丁明山^1,2,
刘京煊³,
孙楠⁴,
袁长忠^1,2,
汪卫东^1,2,
李晓栋⁵,
王志坚³

1. 中国石化微生物采油重点实验室, 山东东营 257000;
2. 中国石化胜利油田分公司石油工程技术研究院, 山东东营 257000;
3. 中国石化新疆新春石油开发有限责任公司, 新疆塔城 833099;
4. 中国石化胜利油田分公司孤东采油厂, 山东东营 257237;
5. 济南弘丰化工有限公司, 济南 251412

基金项目:

中石化科技攻关“新型淋洗-生物工艺修复采油区污染土壤研究”(319005-5)

中石化胜利油田分公司科技攻关“油泥砂及土壤生物修复技术研究与应用”(YG1805-1)

详细信息

作者简介:
丁明山(1985-),男,博士,副研究员,主要研究方向为生物修复与微生物采油。dingmingshan.slyt@sinopec.com

计量
- 文章访问数: 174
- HTML全文浏览量: 24
- PDF下载量: 10
- 被引次数: 0
出版历程
- 收稿日期: 2021-08-16
- 网络出版日期: 2022-07-02

BIOAUGMENTATION REMEDIATION OF AGEING OIL-CONTAMINATED SOIL IN DECOMMISSIONED WELL FIELD

1. Sinopec Key Laboratory of Microbial Enhanced Oil Recovery, Dongying 257000, China;
2. Research Institute of Petroleum Engineering and Technology, Shengli Oilfield Company, Sinopec, Dongying 257000, China;
3. Sinopec Xinjiang Xinchun Petroleum Exploitation Co., Ltd., Tacheng 833099, China;
4. Gudong Oil Production Plant, Shengli Oilfield Company, Sinopec, Dongying 257237, China;
5. Jinan Hongfeng Chemical Co. Ltd., Jinan 251412, China

摘要

摘要: 退役井场油污土壤含油量低、原油重质化严重,为恢复其土壤属性,探索原位生物强化修复技术。在分析油污土壤中原油性质和土著菌群结构的基础上,优选配伍好的外源嗜烃菌,并应用生物促进剂,以及将菌剂固定化以提升其抗环境冲击能力,提升现场生物修复效率。结果表明:井场油污土壤平均含油率为14.6 mg/g,重质组分含量达到57%,土著菌群结构中缺少降解重质组分的微生物。室内优选2株具有协同效应的重质组分降解菌,在生物促进剂用量为500 mg/L和以锯末固定外源菌条件下,降解达标时间由120 d缩减至80 d。现场开展了2700 m²场地原位修复试验,采用地耕法工艺,修复8个月后含油率由14.6 mg/g降至3.30 mg/g,达到GB 36600—2018《土壤环境质量建设用地土壤污染风险管控标准(试行)》建设用地Ⅱ类用地要求。优选的重质油降解菌剂能提升原油污染物的降解速率,通过促进剂和菌剂投加方式的优化,可有效缩短修复周期。
- 老化油污土壤 /
- 生物强化 /
- 烃降解菌 /
- 土著菌 /
- 现场试验
Abstract: Oil contaminated soils from the decommissioned well site were with low oil content with an increasing heavy fraction over time. Therefore, bioaugmentation was performed to restore the original properties of the aging contaminated soil. The physicochemical properties and indigenous microbial communities of the contaminated soil from a decommissioned well site were systematically analyzed. Various hydrocarbon degrading strains and bio-emulsifiers were screened to promote a high degradation value. Moreover, the preparation method of immobilized strains was optimized to enhance the environmental resistance. It was found that the oil content of the contaminated soils was up to 14.6 mg/g with 57% of heavy component. There was a lack of heavy oil degrading microorganisms in the soils. Two functional degrading strains with synergistic effects were screened and immobilized to improve the efficiency of hydrocarbon degradation. With the addition of 500 mg/L F-3 bio-emulsifier, the degradation time of meeting the standard was reduced from 120 d to 80 d. Thereafter, a 2700 m² field test was carried out with the land farming method. After 8 months, the oil content was reduced from 14.6 mg/g to 3.30 mg/g, meeting the requirements of state environmental standards, GB 36600-2018. The screened strains were capable of increasing the degradation rate of the aging oil contaminated soils, where the optimized emulsifier and adding method were in favor of reducing the remediation period.
- ageing oil contaminated soil /
- bioaugmentation /
- hydrocarbon-degrading bacteria /
- indigenous microbial communities /
- field test

HTML全文

参考文献(31)

[1]	BALBA M T,AL-AWADHI N,AL-DAHER R.Bioremediation of oil-contaminated soil:microbiological methods for feasibility assessment and field evaluation[J].Journal of Microbiological Methods,1998,32(2):155-164.
[2]	张强,傅晓文,季蕾,等.生态堆技术修复老化油泥污染土壤[J].环境工程学报,2017,11(11):6142-6146.
[3]	GONG X B.Remediation of weathered petroleum oil-contaminated soil using a combination of biostimulation and modified Fenton oxidation[J].International Biodeterioration& Biodegradation,2012,70:89-95.
[4]	赵晓非,张晓阳,刘立新,等.新型油泥处理技术展望[J].化工进展,2016,35(增刊1):276-280.
[5]	高梦雯.高浓度有机污染土壤处理技术研究进展[J].环境与发展,2019,31(3):41-42.
[6]	BOOPATHY R.Factors limiting bioremediation technologies[J].Bioresource Technology,2000,74(1):63-67.
[7]	SHARMA I.Bioremediation Techniques for Polluted Environment:Concept,Advantages,Limitations,and Prospects[M].Trace Metals in the Environment-New Approaches and Recent Advances,Intecopen,2021,2:2-5.
[8]	董丁,卢彦珍,唐美华,等.一株石油烃高效降解菌的筛选及降解性能研究[J].南京工业大学学报(自然科学版),2017,39(3):6.
[9]	FATIMA M B,FLÁVIO A C,BENEDICT C O,et al.Comparative bioremediation of soils contaminated with diesel oil by natural attenuation,biostimulation and bioaugmentation[J].Bioresource Technology,2005,96(9):1049-1055.
[10]	张宝良,王宝辉,田禹,等.油污土壤生物修复高效菌筛选鉴定[J].哈尔滨工业大学学报,2006,38(12):2180-2184.
[11]	UENO A,HASANUZZAMAN M,YUMOTO I,et al.Verification of degradation of n-alkanes in diesel oil by Pseudomonas aeruginosa strain watg in soil microcosms[J].Current Microbiology,2006,52(3):182-185.
[12]	BANET G,TURAANI A K,FARBER R,et al.The effects of biostimulation and bioaugmentation on crude oil biodegradation in two adjacent terrestrial oil spills of different age,in a hyper-arid region[J].Journal of Environmental Management,2021,286(3/4):112248.
[13]	VARJAIVI S,UPASANI V N.Bioaugmentation of Pseudomonas aeruginosa NCIM 5514-A novel oily waste degrader for treatment of petroleum hydrocarbons[J].Bioresource Technology,2020,319:124240.
[14]	王丽萍,李丹,许锐伟,等.专性菌系对石油烃污染土壤的修复性能[J].中国环境科学,2018,38(4):1417-1423.
[15]	李斌,张随望,黎成,等.安塞油田含油污泥井场微生物降解处理技术研究[J].石油天然气学报,2009,31(3):354-356.
[16]	代小丽,王硕,李佳斌,等.石油污染土壤原位生物修复强化技术研究进展[J].环境工程技术学报,2020,10(3):456-466.
[17]	蔡萍萍,宁卓,何泽,等.采油井场土壤微生物群落结构分布[J].环境科学,2018,39(7):3329-3338.
[18]	DING M S,JIA W H,LV Z F,et al.Improving bitumen recovery from poor processing oil sands using microbial pretreatment[J].Energy& Fuels,2014,28(11):7712-7720.
[19]	胡婧,束青林,孙刚正,等.油藏内源微生物演替规律及其对驱油效果的影响[J].中国石油大学学报(自然科学版),2019,43(1):108-114.
[20]	慕庆峰,于立红,张涛,等.油污土壤修复微生物的筛选及其影响因素[J].水土保持通报,2018,38(5):330-346.
[21]	MOSLEM A,MEHDI H,AKRAMSADAT E.Degradation of phenol at high concentrations using immobilization Pseudomonas putida P53 into sawdust entrapped into sodium-alginate beads[J].Water Science& Technology,2019,79(7):1387-1396.
[22]	孙万虹,陈丽华,徐红伟.氮磷含量对微生物修复油污土壤的影响[J].生物技术通报,2015,31(6):157-164.
[23]	VIDALI M.Bioremediation.An overview[J].Pure& Applied Chemistry,2001,73(7):1163-1172.
[24]	MINAI-TEHRANI D,ROHANIFAR P,AZAMI S.Assessment of bioremediation of aliphatic,aromatic,resin,and asphaltene fractions of oil-sludge-contaminated soil[J].International Journal of Environmental Science& Technology,2015,12(4):1253-1260.
[25]	SIMONE C,RENATA D,MARIA G,et al.Predominant growth of Alcanivorax during experiments on "oil spill bioremediation" in mesocosms[J].Microbiological Research,2007,162(2):185-190.
[26]	SARBASHIS,DAS B M,FREDRIK P,et al.Characterization of three mycobacteriumspp.with potential use in bioremediation by genome sequencing and comparative genomics[J].Genome Biology& Evolution,2015,7(7):1870-1885.
[27]	YUMIKO K,LIES I S,ATSUKO U,et al.Thalassospira tepidiphila sp.nov.,a polycyclic aromatic hydrocarbon-degrading bacterium isolated from seawater[J].International Journal of Systematic& Evolutionary Microbiology,2008,58(3):711-715.
[28]	李晓楼.石油污染对土壤微生物群落多样性的影响[J].生物工程学报,2017,33(6):968-975.
[29]	ELLEN C S,THEREZA C VP,RICARDO P O.Biosurfactant-enhanced hydrocarbon bioremediation:an overview[J].International Biodeterioration& Biodegradation,2014,89(2):88-94.
[30]	张秀霞,耿春香,房苗苗,等.固定化微生物应用于生物修复石油污染土壤[J].石油学报(石油加工),2008,24(4):409-414.
[31]	王京秀,张志勇,孙珊珊,等.植物-固体菌剂联合修复石油污染土壤的基础研究[J].环境工程学报,2016,10(11):6732-6738.