吸附VOCs活性炭真空热再生及影响因素实验

党小庆; 敬开锐; 马红周; 董浩云; 曹利; 李育; 刘霞; 李世杰

doi:10.13205/j.hjgc.202208008

吸附VOCs活性炭真空热再生及影响因素实验

doi: 10.13205/j.hjgc.202208008

1. 西安建筑科技大学环境与市政工程学院陕西省环境工程重点实验室, 西安 710055;
2. 西安建筑科技大学冶金工程学院陕西省黄金与资源重点实验室, 西安 710055

基金项目:

国家重点研发计划(2017YFC0212204)

陕西省重点研发计划(2018ZDCXL-SF-02-04)

详细信息

作者简介:
党小庆(1964-),男,博士,教授,主要研究方向为大气污染控制。dangxq@163.com

通讯作者:
马红周(1973-),男,博士,副教授,主要研究方向为二次资源综合利用。mhzwyn@126.com

计量
- 文章访问数: 295
- HTML全文浏览量: 47
- PDF下载量: 15
- 被引次数: 0
出版历程
- 收稿日期: 2021-12-28
- 刊出日期: 2022-11-08

EXPERIMENTAL RESEARCH ON VACUUM-THERMAL REGENERATION OF ACTIVATED CARBON FOR ADSORPTION OF VOCs AND THE INFLUENCING FACTORS

1. Shaanxi Key Laboratory of Environmental Engineering, Environmental and Municipal Engineering Department, Xi'an University of Architecture and Technology, Xi'an 710055, China;
2. Shaanxi Key Laboratory of Gold and Resources, Metallurgical Engineering Department, Xi'an University of Architecture and Technology, Xi'an 710055, China

摘要

摘要: 活性炭的再生及循环利用对降低吸附法治理含VOCs废气的成本、减少危废产生量具有重要意义。采用真空热再生法对吸附乙酸乙酯的活性炭进行了再生实验,考察不同再生温度及保温时间对活性炭再生效果的影响及真空热再生法对活性炭的循环再生性能。结果表明:活性炭的损失率随再生温度升高而增大,并且当再生温度<200 ℃时,活性炭损失率最大仅0.7%;在最佳实验条件(200 ℃并保温30 min)下,乙酸乙酯脱附率达到93.8%,再生后活性炭的平衡吸附量为108.1 mg/g。比表面积及孔径分布显示,200 ℃以下的真空热再生对活性炭结构几乎无影响;300,400,500 ℃下真空热再生后活性炭的比表面积较新活性炭分别增加22,19,42 m²/g。在最佳再生条件下循环再生6次后,活性炭对乙酸乙酯的平衡吸附量达到新活性炭的97%,表明真空热再生法对活性炭具有良好的再生性能。
- 活性炭 /
- 真空热再生 /
- 比表面积 /
- 循环再生
Abstract: The regeneration and recycling of activated carbon are important to reduce the cost of VOCs treatment by adsorption method and to reduce the amount of hazardous waste generated. The activated carbon adsorbed ethyl acetate was regenerated by vacuum-thermal regeneration method, the effect of regeneration temperature and holding time on the regeneration effect of activated carbon, and the recycling performance of activated carbon by vacuum-thermal regeneration method were investigated. The results showed that the loss rate of activated carbon increased with the increase of regeneration temperature, and the maximum loss rate of activated carbon was only 0.7%, when the regeneration temperature was less than 200 ℃; the desorption rate of ethyl acetate reached 93.8% and the equilibrium adsorption capacity of activated carbon after regeneration was 108.1 mg/g at the optimal experimental condition of 200 ℃ and holding time of 30 min. The specific surface area and pore size distribution showed that vacuum-thermal regeneration had almost no effect on the structure of activated carbon when the temperature was lower than 200 ℃; the specific surface area of activated carbon increased by 22, 19, 42 m²/g after regeneration at 300, 400, 500 ℃, respectively, compared with that of the new activated carbon. After six cycles of regeneration under optimal regeneration conditions, the equilibrium adsorption capacity of activated carbon for ethyl acetate reached 97% of that of the new activated carbon, indicating that vacuum-thermal regeneration method had good regeneration performance for activated carbon.
- activated carbon /
- vacuum-thermal regeneration /
- specific surface area /
- cycle regeneration

HTML全文

参考文献(28)

[1]	梁小明,孙西勃,徐建铁,等.中国工业源挥发性有机物排放清单[J].环境科学,2020,41(11):4767-4775.
[2]	蒋彬,陈晨,孙慧,等.活性炭处理汽修喷烤漆废气工艺优化研究[J].环境工程,2017,35(6):78-81.
[3]	许伟,刘军利,孙康.活性炭吸附法在挥发性有机物治理中的应用研究进展[J].化工进展,2016,35(4):1223-1229.
[4]	岳旭,王胜,刘旭,等.不同吸附剂上动态吸附-脱附挥发性有机气体性能研究[J].燃料化学学报,2020,48(1):120-128.
[5]	刘晓咏,欧阳平.吸附材料再生机理研究进展[J].材料导报,2017,31(1):143-148.
[6]	聂欣,曾贵东,刘成龙.饱和活性炭物理类再生方法的研究现状[J].现代化工,2017,37(2):51-56.
[7]	SALVADOR F,MARTIN-SANCHEZ N,SANCHEZ-HERNANDEZ R,et al.Regeneration of carbonaceous adsorbents.Part Ⅰ:thermal regeneration[J].Microporous and Mesoporous Materials,2015,202:259-276.
[8]	刘洋,白金锋,李彬,等.微孔活性炭对对二甲苯的吸附和脱附性能[J].煤炭转化,2017,40(1):53-58.
[9]	JARETEG A,MAGGIOLO D,THUNMAN H,et al.Investigation of steam regeneration strategies for industrial-scale temperature-swing adsorption of benzene on activated carbon[J].Chemical Engineering and Processing-Process Intensification,2021,167:108546.
[10]	李慧,陈哲,钟缘,等.乙酸丁酯废气在活性炭上的吸附和脱附行为研究[J].离子交换与吸附,2020,36(1):31-40.
[11]	CHEN M,HUANG J,WANG J,et al.Thermal behaviors and regeneration of activated carbon saturated with toluene induced by microwave irradiation[J].Journal of Chemical Engineering of Japan,2009,42(5):325-329.
[12]	韩英杰,伍成梁,潘淑杰,等.废旧活性炭的微波再生技术综述[J].化工环保,2021,41(6):666-672.
[13]	黄维秋,蔡道飞,王丹莉,等.微波加热及真空集成再生活性炭[J].环境工程学报,2013,7(11):4457-4462.
[14]	ANIA C O,PARRA J B,MENÉNDEZ J A,et al.Effect of microwave and conventional regeneration on the microporous and mesoporous network and on the adsorptive capacity of activated carbons[J].Microporous and Mesoporous Materials,2005,85(1):7-15.
[15]	SING K S W.Reporting physisorption data for gas/solid systems with special reference to the determination of surface area and porosity (Recommendations 1984)[J].Pure and Applied Chemistry,1985,57:603.
[16]	KOWALCZYK P,USTINOV E A,TERZYK A P,et al.Description of benzene adsorption in slit-like pores.Theoretical foundations of the improved Horvath-Kawazoe method[J].Carbon,2004,42(4):851-864.
[17]	SING K S W,ROUQUEROL F,ROUQUEROL J,et al.Adsorption by Powders and Porous Solids (Second Edition) [M].New York:Academic Press,2014.
[18]	聂欣,陈祁,郑世元,等.煤基失效生物活性炭热再生过程行为特性研究[J].煤炭学报,2021,46(增刊2):1050-1057.
[19]	HE C,TANG C Y,LIU W,et al.Co-pyrolysis of sewage sludge and hydrochar with coals:pyrolytic behaviors and kinetics analysis using TG-FTIR and a discrete distributed activation energy model[J].Energy Conversion and Management,2020,203:112226.
[20]	ROMÁN S,LEDESMA B,ÁLVAREZ-MURILLO A,et al.Comparative study on the thermal reactivation of spent adsorbents[J].Fuel Processing Technology,2013,116:358-365.
[21]	HAN Z W,WANG D,JIANG P,et al.Enhanced removal and recovery of binary mixture of n-butyl acetate and p-xylene by temperature swing-Vacuum pressure swing hybrid adsorption process[J].Process Safety and Environmental Protection,2020,135:273-281.
[22]	PAK S H,JEON Y W.Effect of vacuum regeneration of activated carbon on volatile organic compound adsorption[J].Environmental Engineering Research,2017,22(2):169-174.
[23]	RAMALINGAM S G,SAUSSAC J,PRÉ P,et al.Hazardous dichloromethane recovery in combined temperature and vacuum pressure swing adsorption process[J].Journal of Hazardous Materials,2011,198:95-102.
[24]	VARGAS D C,SALAZAR S,MORA J R,et al.Experimental and theoretical study of the thermal decomposition of ethyl acetate during fast pyrolysis[J].Chemical Engineering Research and Design,2020,157:153-161.
[25]	GUO Y Q,DU E D.The effects of thermal regeneration conditions and inorganic compounds on the characteristics of activated carbon used in power plant[J].Energy Procedia,2012,17:444-449.
[26]	解炜,王鹏,曲思建,等.压块工艺条件下配煤对活性炭孔结构的调控作用[J].煤炭科学技术,2017,45(2):197-202 ,208.
[27]	ZHANG X Y,GAO B,CREAMER A E,et al.Adsorption of VOCs onto engineered carbon materials:a review[J].Journal of Hazardous Materials,2017,338:102-123.
[28]	LI X Q,ZHANG L,YANG Z Q,et al.Adsorption materials for volatile organic compounds (VOCs) and the key factors for VOCs adsorption process:a review[J].Separation and Purification Technology,2020,235:116213.