碱性消毒剂耦合低温热处理消毒医疗污泥

张韵洁; 侯江; 雍毅; 邢涛; 张力

doi:10.13205/j.hjgc.202208013

碱性消毒剂耦合低温热处理消毒医疗污泥

doi: 10.13205/j.hjgc.202208013

四川省生态环境科学研究院, 成都 610000

基金项目:

2021YFS0287)

四川省科技计划项目(重点研发项目)(2020YFS0440

详细信息

作者简介:
张韵洁(1984-),女,硕士,主要研究方向为环境微生物开发利用与固体废物处理。23781106@qq.com

通讯作者:
侯江(1974-),男,高级工程师,主要研究方向为固体废物处理与资源化利用。houjiang163@163.com

计量
- 文章访问数: 92
- HTML全文浏览量: 10
- PDF下载量: 6
- 被引次数: 0
出版历程
- 收稿日期: 2021-11-16
- 刊出日期: 2022-11-08

A MEDICAL WASTEWATER SLUDGE DISINFECTION TECHNOLOGY OF ALKALINE DISINFECTANTS COUPLED WITH LOW-TEMPERATURE HEAT TREATMENT

Sichuan Academy of Environmental Sciences, Chengdu 610000, China

摘要

摘要: 为填补医疗污泥清掏后的处理技术空白,以枯草芽孢杆菌黑色变种芽孢为指示菌,评价了碱性消毒剂耦合低温热处理对医疗污泥的消毒效果。结果表明:医疗污泥CaO消毒最适投加量为5%,热处理温度不宜低于70 ℃,在80 ℃条件下处理2 h,或70 ℃条件下处理4 h均可满足医疗污泥消毒要求(生物指示菌杀灭对数值≥4)。与单独使用5% CaO相比,加入1% NaOH可以使80,70 ℃下的热处理时间分别缩短至1,3 h。医疗污泥经碱性消毒后,脱水性能有效改善。该研究结果可为形成医疗污泥集中消毒处理技术提供理论依据和数据支撑。
- 医疗污泥 /
- 碱性消毒 /
- 枯草杆菌黑色变种芽孢 /
- 低温热处理
Abstract: To resolve the lack of medical sludge treatment technologies, the disinfection effect of alkaline disinfectants coupled with low-temperature heat treatment on medical wastewater sludge was evaluated by using Bacillus subtilis var. niger Spore as the indicator bacteria. The results indicated that the optimum dosage of CaO disinfection for medical wastewater sludge was 5%. The heat treatment temperature needed to be 70 ℃ above, and medical wastewater sludge disinfection requirements could be met by treating at 80 ℃ for 2 h, or 70 ℃ for 4 h. Compared with 5% CaO alone, adding 1% NaOH could shorten the treatment time at 80 ℃ and 70 ℃ to 1h and 3 h, respectively. The dewatering performance of medical wastewater sludge was effectively improved after alkaline disinfection. The results of this study can provide a theoretical basis and data support for the formation of centralized disinfection treatment technology for medical wastewater sludge.
- medical wastewater sludge /
- alkaline disinfection /
- Bacillus subtilis var.niger Spore /
- low-temperature heat treatment

HTML全文

参考文献(17)

[1]	TSAI C T,LAI J S,LIN S T.Quantification of pathogenic micro-organisms in the sludge from treated hospital wastewater[J].Journal of Applied Microbiology,2010,85(1):171-176.
[2]	邹宝波,程科萍,周士新,等.医院菌株对常用消毒剂的抗药性测定[J].铁道医学,2002(1),30:28-29.
[3]	ALI M A,AL-HERRAWY A Z,EL-HAWAARY S E.Detection of enteric viruses,Giardia and Cryptosporidium in two different types of drinking water treatment facilities[J].Water Research,2004,38(18):3931-3939.
[4]	吴晗,顾平,朱丹,等.过氧乙酸用于医院污泥消毒的研究[J].给水排水,2012,38(12):50-53.
[5]	张景丽,顾平,张光辉.NaClO和PAA对医院污水MBR污泥消毒的研究[J].中国给水排水,2014,30(3):87-91.
[6]	蒋建国,殷闽,李春萍.添加不同比例的石灰对污泥稳定化的模糊评价[J].环境工程学报,2012,6(2):605-609.
[7]	刘强,陈晓欢,傅金祥,等.粉煤灰与生石灰复合调理剂对市政污泥深度脱水性能的影响[J].环境工程学报,2015,9(7):3468-3472.
[8]	SANTOS A F,VAS T,LOPES V L,et al.Beneficial use of lime mud from kraft pulp industry for drying and microbiological decontamination of sewage sludge[J].Journal of environmental management,2021,296:113255.
[9]	林珊伊,孙德安,朱明瑞,等.芬顿与氧化钙联合处理填埋库污泥的力学特性[J].环境工程学报,2020,14(10):2813-2822.
[10]	谭聪,肖筱瑜,孙伟,等.铜冶炼污泥中砷的固化/稳定化处理[J].矿产与地质,2020,34(3):579-582.
[11]	程毅,黄剑明,周柏明,等.生石灰在污泥重金属钝化中的应用[J].环境工程,2012,30(增刊2):325-326.
[12]	孟国欣,查同刚,巩潇,等.复合添加剂对污泥堆肥化重金属形态及生物有效性的影响[J].生态环境学报,2018,27(1):182-190.
[13]	SANTOS A F,SANTOS C P,MATOS A M,et al.Effect of thermal drying and chemical treatments with wastes on microbiological contamination indicators in sewage sludge[J].Microorganisms,2020,8:376.
[14]	LOPES B C,MACHADO E C,RODRIGUES H F,et al.Effect of alkaline treatment on pathogens,bacterial community and antibiotic resistance genes in different sewage sludges for potential agriculture use[J].Environmental Technology,2020,41:529-538.
[15]	苏建文,郑浩,王彩冬,等.超声波或生石灰单独及联合作用对污泥脱水性能的影响[J].净水技术,2014,33(3):48-51 ,57.
[16]	周健,柴宏祥,龙腾锐.活性污泥胞外聚合物EPS的影响因素研究[J].给水排水,2005,31(8):19-23.
[17]	陆薇儿,修光利.钙离子存在下胞外聚合物及其模拟溶液在膜污染中的差异[J].环境工程学报,2020,14(4):157-166.