高温条件下初始pH值对污泥-餐厨垃圾联合厌氧发酵产氢余物产CH<sub>4</sub>的影响

曹麒; 何雨恒; 卓桂华; 刘常青; 陈建勇; 郑育毅

doi:10.13205/j.hjgc.202209020

高温条件下初始pH值对污泥-餐厨垃圾联合厌氧发酵产氢余物产CH₄的影响

doi: 10.13205/j.hjgc.202209020

曹麒^1,2,
何雨恒³,
卓桂华⁴,
刘常青^3,2, ,,
陈建勇¹,
郑育毅^1,2

1. 福建师范大学环境与资源学院碳中和现代产业学院福建省污染控制与资源循环利用重点实验室, 福州 350007;
2. 福建师范大学地理科学学院碳中和未来技术学院, 福州 350007;
3. 城市废物资源化技术与管理福建省高校工程研究中心, 福州 350007;
4. 福建省环境科学研究院, 福州 350013

基金项目:

福建省科技厅对外合作项目(2021I0010)

福建省科技厅公益类项目(2019R1015-1)

福建省科技厅计划项目(2020N5015)

详细信息

作者简介:
曹麒(1998-),女,研究生在读,主要研究方向为固体废物处理与资源化。481781214@qq.com

通讯作者:
刘常青(1970-),女,博士,副教授,主要研究方向为固体废物处理与资源化。mylcq@126.com

计量
- 文章访问数: 168
- HTML全文浏览量: 42
- PDF下载量: 5
- 被引次数: 0
出版历程
- 收稿日期: 2022-03-11
- 网络出版日期: 2022-11-09

EFFECT OF INITIAL pH VALUE ON METHANE PRODUCTION FROM RESIDUE AFTER ANAEROBIC CO-FERMENTATIVE HYDROGEN PRODUCTION OF SEWAGE SLUDGE AND FOOD WASTE UNDER THERMOPHILIC OPERATION

1. College of Environmental and Resource Sciences and College of Carbon Neutral Modern Industry, Fujian Key Laboratory of Pollution Control and Resource Reuse, Fujian Normal University, Fuzhou 350007, China;
2. School of Geographical Sciences and School of Carbon Neutrality Future Technology, Fujian Normal University, Fuzhou 350007, China;
3. Fujian College and University Engineering Research Center for Municipal Solid Waste Resourceization and Management, Fuzhou 350007, China;
4. Fujian Academy of Environmental Sciences, Fuzhou 350013, China

摘要

摘要: 污泥-餐厨垃圾厌氧消化产氢产CH₄可将城市有机废弃物转化为可再生能源H₂、CH₄,对实现碳减排发挥着重要作用。通过批式试验探究高温条件下(55±1℃),不同初始pH值对污泥和餐厨垃圾联合厌氧发酵产氢余物产CH₄的影响。研究结果表明:适度地增加产氢余物的碱度会提高产CH₄效能,而过低的初始pH则抑制了产氢余物产CH₄效能。初始pH=8时,CH₄最高浓度(79.08%)、累积产甲烷量(101 mL/g DS)和最大CH₄生产速率(12.21 mL/d)均达到最大。不同初始pH下,总糖和总蛋白质的降解量跟累积产甲烷量呈正相关,其中总蛋白的降解量及降解率均高于总糖。初始pH=8时,总糖和总蛋白质的降解量及降解率最高,分别为6078 mg/L、55.70%和4710 mg/L、69.67%。不同初始pH值下,产氢余物厌氧消化后的pH都趋于7.5左右。
- 产氢余物 /
- 产CH₄ /
- pH值 /
- 厌氧消化 /
- 高温
Abstract: Simultaneously producing hydrogen and methane via sewage sludge and food waste anaerobic co-digestion, widely regarded as one of the promising methods for renewable energy, plays an important role in carbon emission reduction. This study explored the effect of different initial pH values on the methane production from the residue from anaerobic co-fermentative hydrogen production of sewage sludge and food waste through batch experiments under thermophilic operation(55±1)℃. The results showed that properly increasing the alkalinity of the initial substrate of residue from hydrogen production improved methanogenic performance, while the initial pH=6 inhibited methane production. The highest value of maximum methane concentration(79.08%), cumulative methane yield(101 mL/g DS), and maximum methane production rate(12.21 mL/d) were all found in the test group of initial pH=8. The degradation ratios of total carbohydrate and total protein with different initial pH values were positively correlated with the cumulative methane yield. And total carbohydrate and total protein degradation were also the highest at initial pH=8, with values of 6078 mg/L~55.70% and 4710 mg/L~69.67%, respectively. Among these, the degradation rate of total protein was higher than total carbohydrate. Meanwhile, the pH value after digestion from different initial pH values tended to be 7.5 or so.
- residue of hydrogen production /
- methane production /
- initial pH /
- anaerobic digestion /
- thermophilic

HTML全文

参考文献(48)

[1]	胡鞍钢.中国实现2030年前碳达峰目标及主要途径[J].北京工业大学学报(社会科学版),2021,21(3 ):1-15.
[2]	ZHU R,HE L,LI Q,et al.Mechanism study of improving anaerobic co-digestion performance of waste activated sludge and food waste by Fe₃O₄[J].Journal of Environmental Management,2021,300:113745.
[3]	HUANG H N,CHEN Y G,ZHENG X,et al.Distribution of tetracycline resistance genes in anaerobic treatment of waste sludge:the role of pH in regulating tetracycline resistant bacteria and horizontal gene transfer[J].Bioresource Technology,2016,218(1):1284-1289.
[4]	张国华,张志红,黄江丽,等.餐厨垃圾厌氧发酵连续产氢产甲烷的试验研究[J].中国沼气,2016,34(4):8-12.
[5]	AWE O W,ZHAO Y,NZIHOU A,et al.Anaerobic co-digestion of food waste and FOG with sewage sludge-realising its potential in Ireland[J].The International journal of environmental studies,2018,75(3):496-517.
[6]	KUMAR A,SAMADDER S R.Performance evaluation of anaerobic digestion technology for energy recovery from organic fraction of municipal solid waste:a review[J].Energy,2020,197:117253.
[7]	KOCH K,HELMREICH B,DREWES J E.Co-digestion of food waste in municipal wastewater treatment plants:effect of different mixtures on methane yield and hydrolysis rate constant[J].Applied Energy,2015,137:250-255.
[8]	JAVKHLAN A,GIOVANNI E,YEH D H,et al.Enhanced Anaerobic Digestion of Food Waste by Supplementing Trace Elements:role of Selenium (Ⅵ) and Iron (Ⅱ)[J].Frontiers in Environmental Science,2016,4(61):1-11.
[9]	MEHARIYA S,PATEL A K,OBULISAMY P K,et al.Co-digestion of food waste and sewage sludge for methane production:current status and perspective[J].Bioresource Technology,2018,265(1):519-531.
[10]	NGHIEM L D,KOCH K,BOLZONELLA D,et al.Full scale co-digestion of wastewater sludge and food waste:bottlenecks and possibilities[J].Renewable & Sustainable Energy Reviews,2017,72:354-362.
[11]	ARELLI V,MAMINDLAPELLI N K,BEGUM S,et al.Solid state anaerobic digestion of food waste and sewage sludge:impact of mixing ratios and temperature on microbial diversity,reactor stability and methane yield[J].Science of the Total Environment,2021,793:148586.
[12]	WANG P,ZHENG Y,LIN P,et al.Effects of graphite,graphene,and graphene oxide on the anaerobic co-digestion of sewage sludge and food waste:attention to methane production and the fate of antibiotic resistance genes[J].Bioresource Technology,2021,339:125585.
[13]	ZHANG M,WANG Y C.Impact of biochar supported nano zero-valent iron on anaerobic co-digestion of sewage sludge and food waste:methane production,performance stability and microbial community structure[J].Bioresource Technology,2021,340:125715.
[14]	GU J,LIU R,CHENG Y,et al.Anaerobic co-digestion of food waste and sewage sludge under mesophilic and thermophilic conditions:focusing on synergistic effects on methane production[J].Bioresource Technology,2020,301:122765.
[15]	NARAN E,TOOR U A,KIM D J.Effect of pretreatment and anaerobic co-digestion of food waste and waste activated sludge on stabilization and methane production[J].International Biodeterioration & Biodegradation,2016,113:17-21.
[16]	LIN Y Q,WANG D H,LIANG J J,et al.Mesophilic anaerobic co-digestion of pulp and paper sludge and food waste for methane production in a fed-batch basis[J].Environmental Technology,2012,33(22/23/24):2627-2633.
[17]	LUNPROM S,PHANDUANG O,SALAKKAM A,et al.Bio-hythane production from residual biomass of Chlorella sp.biomass through a two-stage anaerobic digestion[J].International Journal of Hydrogen Energy,2019,44(6):3339-3346.
[18]	ROY S,DAS D.Biohythane production from organic wastes:present state of art[J].Environmental Science and Pollution Research,2016,23(10):9391-9410.
[19]	XIAO B Y,QIN Y,QU J,et al.Comparison of single-stage and two-stage thermophilic anaerobic digestion of food waste:performance,energy balance and reaction process[J].Energy Conversion and Management,2018,156:215-223.
[20]	RUGGERI B,TOMMASI T,SASSI G.Energy balance of dark anaerobic fermentation as a tool for sustainability analysis[J].International Journal of Hydrogen Energy,2010,35(19):10202-10211.
[21]	罗鸿信,林鸿,余育方,等.污泥与餐厨垃圾联合厌氧发酵产氢余物产甲烷条件优化研究[J].环境工程学报,2014,8(8):3449-3453.
[22]	郑育毅,林鸿,林志龙,等.不同碱剂对污泥与餐厨垃圾联合厌氧发酵产氢余物产甲烷的影响[J].环境工程学报,2016,10(1):393-398.
[23]	CHEN Y,LIU H,ZHENG X,et al.New method for enhancement of bioenergy production from municipal organic wastes via regulation of anaerobic fermentation process[J].Applied Energy,2017,196:190-198.
[24]	BALDI F,PECORINI I,LANNELLI R.Comparison of single-stage and two-stage anaerobic co-digestion of food waste and activated sludge for hydrogen and methane production[J].Renewable Energy,2019,143:1755-1765.
[25]	SAHLSTROM L.A review of survival of pathogenic bacteria in organic waste used in biogas plants[J].Bioresource Technology,2003,87(2):161-166.
[26]	LIN Y,WU S,WANG D.Hydrogen-methane production from pulp & paper sludge and food waste by mesophilic-thermophilic anaerobic co-digestion[J].International Journal of Hydrogen Energy,2013,38(35):15055-15062.
[27]	LUO H X,LI Y,YU Y F,et al.Influence of the Inoculation Volume on Methanogenesis by Thermophilic Anaerobic Digestion with Residue from Hydrogen Production Fermentation Using Combined Substrate of Sludge and Food Waste[J].Advanced Materials Research,2014,878:496-503.
[28]	CHAKRABORTY D,KARTHIKEYAN O P,SELVAM A,et al.Co-digestion of food waste and chemically enhanced primary treated sludge in a continuous stirred tank reactor[J].Biomass & Bioenergy,2018,111:232-240.
[29]	LOGAN B E,OH S E,KIM I S,et al.Biological hydrogen production measured in batch anaerobic respirometers[J].Environmental Science & Technology,2002,36(11):2530-2535.
[30]	谢育红,陆源,刘常青,等.污泥前期处理对测定其总糖的影响研究[J].环境科学与技术,2014,37(4):156-160.
[31]	赵庆祥.污泥资源化技术[M].化学工业出版社,2002.
[32]	悉旦立.环境监测(修订版)[M].高等教育出版社,1995.
[33]	任南琪,马放.污染控制微生物学原理与应用[M].化学工业出版社,2003.
[34]	林加涵.现代生物学实验[M].施普林格出版社,2000.
[35]	WU L J,HIGASHIMORI A,QIN Y,et al.Upgrading of mesophilic anaerobic digestion of waste activated sludge by thermophilic pre-fermentation and recycle:process performance and microbial community analysis[J].Fuel,2016,169:7-14.
[36]	蒲贵兵,吕波,孙可伟,等.初始pH值对泔脚发酵产氢余物甲烷化的强化研究[J].环境工程学报,2010,4(3):633-638.
[37]	NOLLA-Ardevol V,STROUS M,TEGETMEYER H E.Anaerobic digestion of the microalga Spirulina at extreme alkaline conditions:biogas production,metagenome,and metatranscriptome[J].Frontiers in Microbiology,2015,6:1-21.
[38]	RAWOOF S A A,KUMAR P S,VO D-V N,et al.Sequential production of hydrogen and methane by anaerobic digestion of organic wastes:a review[J].Environmental Chemistry Letters,2020:1-21.
[39]	De GIOANNIS G,MUNTONI A,POLETTINI A,et al.Energy recovery from one- and two-stage anaerobic digestion of food waste[J].Waste Management,2017,68:595-602.
[40]	鲁珍,周兴求,伍健东.初始pH对产氢发酵液厌氧产甲烷的影响研究[J].环境工程学报,2011,5(5):1115-1118.
[41]	SILVA F M S,MAHLER C F,OLIVEIRA L B,et al.Hydrogen and methane production in a two-stage anaerobic digestion system by co-digestion of food waste,sewage sludge and glycerol[J].Waste Management,2018,76:339-349.
[42]	HOU T,ZHAO J,LEI Z,et al.Enhanced energy recovery via separate hydrogen and methane production from two-stage anaerobic digestion of food waste with nanobubble water supplementation[J].Science of the Total Environment,2021,761:143234.
[43]	郑育毅,林鸿,罗鸿信,等.污泥与餐厨垃圾联合厌氧发酵产氢余物产甲烷过程底物指标变化[J].环境工程学报,2015,9(1):425-430.
[44]	LI Y,CHEN Y,WU J.Enhancement of methane production in anaerobic digestion process:a review[J].Applied Energy,2019,240:120-137.
[45]	ZOU X M,YANG R J,ZHOU X,et al.Effects of mixed alkali-thermal pretreatment on anaerobic digestion performance of waste activated sludge[J].Journal of Cleaner Production,2020,259:120940.
[46]	YANG Z Y,WANG W,LIU C,et al.Mitigation of ammonia inhibition through bioaugmentation with different microorganisms during anaerobic digestion:selection of strains and reactor performance evaluation[J].Water Research,2019,155:214-224.
[47]	SUNYOTO N M S,ZHU M,ZHANG Z,et al.Effect of biochar addition on hydrogen and methane production in two-phase anaerobic digestion of aqueous carbohydrates food waste[J].Bioresource Technology,2016,219:29-36.
[48]	WANG Q,PENG L,SU H.The effect of a buffer function on the semi-continuous anaerobic digestion[J].Bioresource Technology,2013,139:43-49.