中国科学引文数据库（CSCD）来源期刊
中国科技核心期刊
环境科学领域高质量科技期刊分级目录T2级期刊
RCCSE中国核心学术期刊
美国化学文摘社（CAS）数据库 收录期刊
日本JST China 收录期刊
世界期刊影响力指数（WJCI）报告 收录期刊

留言板

尊敬的读者、作者、审稿人, 关于本刊的投稿、审稿、编辑和出版的任何问题, 您可以本页添加留言。我们将尽快给您答复。谢谢您的支持!

姓名
邮箱
手机号码
标题
留言内容
验证码

条形磁铁几何构形对层流中磁性颗粒分离行为影响的数值研究

罗威,  李品一,  彭辉,  叶永

downloadPDF
文章导航 > 环境工程  > 2022 >  40(11): 32-40
罗威, 李品一, 彭辉, 叶永. 条形磁铁几何构形对层流中磁性颗粒分离行为影响的数值研究[J]. 环境工程, 2022, 40(11): 32-40. doi: 10.13205/j.hjgc.202211005
引用本文: 罗威, 李品一, 彭辉, 叶永. 条形磁铁几何构形对层流中磁性颗粒分离行为影响的数值研究[J]. 环境工程, 2022, 40(11): 32-40. doi: 10.13205/j.hjgc.202211005
shu
LUO Wei, LI Pinyi, PENG Hui, YE Yong. NUMERICAL STUDY ON EFFECT OF STRIP MAGNET GEOMETRIC CONFIGURATION ON SEPARATION BEHAVIORS OF MAGNETIC PARTICLES IN LAMINAR FLOW[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(11): 32-40. doi: 10.13205/j.hjgc.202211005
Citation: LUO Wei, LI Pinyi, PENG Hui, YE Yong. NUMERICAL STUDY ON EFFECT OF STRIP MAGNET GEOMETRIC CONFIGURATION ON SEPARATION BEHAVIORS OF MAGNETIC PARTICLES IN LAMINAR FLOW[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(11): 32-40. doi: 10.13205/j.hjgc.202211005
shu

条形磁铁几何构形对层流中磁性颗粒分离行为影响的数值研究

doi: 10.13205/j.hjgc.202211005

  • 1. 三峡大学 三峡库区生态环境教育部工程研究中心, 湖北 宜昌 443002;

  • 2. 三峡大学 水利与环境学院, 湖北 宜昌 443002

基金项目: 

国家重点研发计划（2021YFC3001901）；国家自然科学基金项目（11972216）

详细信息
    作者简介:

    罗威(1984-),男,副教授,主要研究方向为磁分离水处理、环境力学。wluo@lzu.edu.cn

    通讯作者:

    彭辉(1976-),男,教授,主要研究方向为生态与环境水力学。hpeng1976@163.com

    叶永(1969-),男,博士,教授,主要研究方向为生态与环境水力学。yyeeong@aliyun.com

NUMERICAL STUDY ON EFFECT OF STRIP MAGNET GEOMETRIC CONFIGURATION ON SEPARATION BEHAVIORS OF MAGNETIC PARTICLES IN LAMINAR FLOW

  • 1. Engineering Research Center of the Ministry of Ecological Environment and Education in the Three Gorges Reservoir Area, Three Gorges University, Yichang 443002, China;

  • 2. School of Water Conservancy and Environment, Three Gorges University, Yichang 443002, China

    摘要
  • 摘要: 增强磁场对流体中磁性颗粒或团聚物的分离回收作用是开梯度磁分离技术中的关键问题。通过建立数值模型，研究条形磁体4种排列方式（轴向交替、轴向并发、横向交替和横向并发）及不同磁端间距对颗粒捕获率的影响，并结合颗粒运动轨迹和磁场力分布情况对颗粒捕获结果进行分析，同时研究了磁体长宽比、颗粒磁化率、流体流速、磁体磁化强度对颗粒捕获率的影响。结果表明：对于条形磁体，当磁端间距足够远时，轴向布置优于横向布置；在小磁端间距下，轴向交替排列方式最优；对于横向交替排列，在同等磁通量和截面面积的矩形磁体下，长宽比为1：1的方形磁体对颗粒的捕获作用最优。该成果可为多磁体组合的磁分离器设计提供理论参考。
    Abstract: Enhancing the separation and recycling of magnetic particles or agglomerates in fluid by the applied magnetic field is a key problem in the open gradient magnetic separation technology. By establishing a numerical model, the effects of four arrangement modes of strip magnets (the axial alternating arrangement, the axial concurrent arrangement, the transverse alternating arrangement, and the transverse concurrent arrangement) and different magnetic end spacings on the particle capture rate were studied, and also the particle capture results were analyzed, in combination with the particle trajectory and the magnetic force distribution. At the same time, the ratio of magnet length to width, the effects of particle susceptibility, the fluid flow velocity, and the magnet magnetization on particle capture rate were studied. The results showed that, for strip magnets, when the magnetic end spacing was far enough, the axial placement was better than the transverse placement; for a low magnetic end spacing, the axial alternating arrangement was the best; for the rectangular magnets with the same magnetic flux and cross-sectional area, the square magnet with the aspect ratio of 1:1 had the best trapping effect on the particles. The results could provide theoretical guidance for the design of a multi-magnet magnetic separator.
    • HTML全文
    • 参考文献(25)
  • [1] IRANMANESH M, HULLIGER J. Magnetic separation:its application in mining, waste purification, medicine, biochemistry and chemistry[J]. Chemical Society Reviews, 2017, 46(19):5925-5934.
    [2] GÓMEZ-PASTORA J, XUE X Z, KARAMPELAS I H, et al. Analysis of separators for magnetic beads recovery:from large systems to multifunctional microdevices[J]. Separation and Purification Technology, 2017, 172:16-31.
    [3] NAKAJIMA H, KANEKO H, OIZUMI M, et al. Separation characteristics of open gradient magnetic separation using high-temperature superconducting magnet[J]. Physica C:Superconductivity and its Applications, 2003, 392/293/294/295/396:1214-1218.
    [4] EISENTRÄGER A, VELLA D, GRIFFITHS I M. Particle capture efficiency in a multi-wire model for high gradient magnetic separation[J]. Applied Physics Letters, 2014, 105(3):033508.
    [5] 黄自力, 胡岳华."磁种-高梯度磁分离"污水除磷技术的研究[J].环境污染治理技术与设备, 2003,4(5):70-73.
    [6] ESKANDARPOUR A, IWAI K, ASAI S. Superconducting magnetic filter:performance, recovery, and design[J]. IEEE Transactions on Applied Superconductivity, 2009, 19(2):84-95.
    [7] GE W, ENCINAS A, ARAUJO E, et al. Magnetic matrices used in high gradient magnetic separation (HGMS):a review[J]. Results in Physics, 2017, 7:4278-4286.
    [8] XUE Z X, WANG Y H, ZHENG X Y, et al. Particle capture of special cross-section matrices in axial high gradient magnetic separation:a 3D simulation[J]. Separation and Purification Technology, 2020, 237:116375.
    [9] ZHENG X Y, WANG Y H, LU D F, et al. Comparative study on the performance of circular and elliptic cross-section matrices in axial high gradient magnetic separation:role of the applied magnetic induction[J]. Minerals Engineering, 2017, 110:12-19.
    [10] CHOOMPHON-ANOMAKHUN N, EBNER A D, NATENAPIT M, et al. Simulation of dynamic magnetic particle capture and accumulation around a ferromagnetic wire[J]. Journal of Magnetism and Magnetic Materials, 2017, 428:493-505.
    [11] REN P, CHEN L Z, LIU W B, et al. Comparative investigation on magnetic capture selectivity between single wires and a real matrix[J]. Results in Physics, 2018, 8:180-183.
    [12] HARTIKAINEN T, MIKKONEN R. Open-gradient magnetic separator with racetrack coils suitable for cleaning aqueous solutions[J]. IEEE Transactions on Applied Superconductivity, 2006, 16(2):1130-1133.
    [13] CAO Q L, HAN X T, LI L. Numerical analysis of magnetic nanoparticle transport in microfluidic systems under the influence of permanent magnets[J]. Journal of Physics D:Applied Physics, 2012, 45(46):465001.
    [14] 张勤, 王哲晓, 李灿.超磁分离水体净化技术在黑臭水体治理中的应用案例[J].环境工程学报, 2021, 15(9):3128-3135.
    [15] 胡卓祺, 陈泉源.磁性氧化石墨处理乳化含油废水及磁致增强效应[J].中国环境科学, 2020, 40(7):2970-2977.
    [16] ZHAO Y, XI B D, LI Y R, et al. Removal of phosphate from wastewater by using open gradient superconducting magnetic separation as pretreatment for high gradient superconducting magnetic separation[J]. Separation and Purification Technology, 2012, 86:255-261.
    [17] TOH P Y, YEAP S P, KONG L P, et al. Magnetophoretic removal of microalgae from fishpond water:feasibility of high gradient and low gradient magnetic separation[J]. Chemical Engineering Journal, 2012, 211:22-30.
    [18] FUKUI S, NAKAJIMA H, OZONE A, et al. Study on open gradient magnetic separation using multiple magnetic field sources[J]. IEEE Transactions on Applied Superconductivity, 2002, 12(1):959-962.
    [19] CHONG P H, TAN Y W, TEOH Y P, et al. Continuous flow low gradient magnetophoresis of magnetic nanoparticles:separation kinetic modelling and simulation[J]. Journal of Superconductivity and Novel Magnetism, 2021, 34(8):2151-2165.
    [20] DIMOVA T. Theoretical and experimental study of drum electromagnetic separator for waste material[C]//202021st International Symposium on Electrical Apparatus & Technologies (SIELA), June 2020:1-4.
    [21] HARTIKAINEN T, NIKKANEN J P, MIKKONEN R. Magnetic separation of industrial waste waters as an environmental application of superconductivity[J]. IEEE Transactions on Appiled Superconductivity, 2005, 15(2):2336-2339.
    [22] WANG F W, ZHAO H M, DAI H X, et al. Fully coupled multi-physics modeling of the multi-type magnetic particles dynamic behavior in low intensity magnetic separator[J]. Physicochemical Problems of Mineral Processing, 2019, 55(1):163-172.
    [23] YAP A C W, LEE H S, LOO J L, et al. Investigation of the magnetic effects on water properties using permanent magnets[J]. 2019, 2157(1):020016.
    [24] AMBASHTA R D, SILLANPAA M. Water purification using magnetic assistance:a review[J]. J Hazard Mater, 2010, 180(1/2/3):38-49.
    [25] 魏红港, 史佩伟, 冉红想,等.永磁筒式磁选机开放式磁场特性的分析[J].有色金属, 2011(增刊1):146-149.
    • 相关文章
    • 施引文献
  • 资源附件(0)
  • 加载中
WeChat 点击查看大图
计量
  • 文章访问数:  133
  • HTML全文浏览量:  21
  • PDF下载量:  1
  • 被引次数: 0
出版历程
  • 收稿日期:  2022-04-07
  • 网络出版日期:  2023-03-24

目录

    /

    返回文章
    返回

    期刊在线

    作者中心

    友情链接

    版权所有 ©《工业建筑》杂志社有限公司 京ICP备11033253号-1

    本系统由北京仁和汇智信息技术有限公司 设计开发   百度统计