白酒酿造固体废弃物资源化利用新进展

卢皓; 田金平; 吕一铮; 叶宁; 万梅; 陈吕军

doi:10.13205/j.hjgc.202211031

白酒酿造固体废弃物资源化利用新进展

doi: 10.13205/j.hjgc.202211031

卢皓¹,
田金平^1,3,
吕一铮¹,
叶宁¹,
万梅²,
陈吕军^1,3, ,

1. 清华大学环境学院, 北京 100084;
2. 浙江清华长三角研究院, 浙江嘉兴 314006;
3. 清华大学生态文明研究中心, 北京 100084

基金项目:

国家重点研发计划"固废资源化"重点专项（2018YFC1901101）

详细信息

作者简介:
卢皓(1996-),男,助理工程师,主要研究方向为产业生态学、生命周期评价。luhaouk@163.com;田金平(1974-),男,博士,研究员,主要研究方向为产业生态学、生态工业园区等。tianjp@tsinghua.edu.cn

通讯作者:
陈吕军(1965-),男,教授,博导,主要研究方向为工业园区绿色发展、清洁生产技术与产业生态学。chenlj@tsinghua.edu.cn

计量
- 文章访问数: 675
- HTML全文浏览量: 78
- PDF下载量: 20
- 被引次数: 0
出版历程
- 收稿日期: 2022-02-11
- 网络出版日期: 2023-03-24

REVIEW ON RESEARCH PROGRESS OF RESOURCE RECOVERY BAIJIU DISTILLER'S GRAIN

LU Hao¹,
TIAN Jinping^1,3,
LV Yizheng¹,
YE Ning¹,
WAN Mei²,
CHEN Lvjun^{1,3
, ,}

1. School of Environment, Tsinghua University, Beijing 100084, China;
2. Yangtze Delta Region Institute of Tsinghua University, Jiaxing 314006, China;
3. Center for Ecological Civilization, Tsinghua University, Beijing 100084, China

摘要

摘要: 白酒酿造产生的酒糟固体废弃物产量大、富含有机质、储存易腐，处理处置成本高，导致资源化利用效率仍较低。聚焦于2017—2021年关于白酒糟资源化利用的文献，从资源化应用途径及处理技术2个角度综述了研究新进展。研究发现：利用白酒糟制取动物饲料是当前资源化应用的主要方向；处理技术方面，混菌发酵技术对纤维素的降解率为24%~42%，对粗蛋白增率在21%~60%，能有效均衡酒糟饲料制品的养分，应用广泛。近年来白酒糟炭化热解制取生物炭研究进展迅速，生物炭产率在33%~43%。构建白酒酿造、白酒糟制生物炭与作物种植的综合处理体系，可为规模化处理酒糟固废建立新模式。
- 白酒酒糟 /
- 资源化 /
- 酒糟饲料化 /
- 酒糟炭化热解
Abstract: The Chinese baijiu industry is facing a challenge in recycling the distiller's grain, which is featured by large yield, rich organic matters, short-lived storage, and high cost of treatment. This study reviewed new research progress on technologies of distiller's grains processing and utilization, with an emphasis on academic articles published between year 2017 and 2021. Animal feeding is still the mainstream of distiller's grains reutilization. The characteristics of processing technologies development are twofold. The microbial processing technique has been extensively employed with the benefit of balancing nutrients in grain-derived animal fodders by degrading cellulose with a rate of 24% to 42%, and increasing crude protein with a rate of 21% to 60%. Carbonization and pyrolysis of distiller grains to produce biochar is currently a hot topic with great promise, and the rate of biochar production is kept between 33% and 43%. At last, this study proposes a new technology paradigm for large-scale treatment of distiller's grains, in conjunction with baijiu production, biochar production and crop planting, to construct a holistic reutilization.
- baijiu distiller's grain /
- resource recovery /
- grain to fodder /
- grain to biochar

HTML全文

参考文献(58)

[1]	2020年1-12月酿酒行业运行情况[EB/OL]. https://www.miit.gov.cn/gxsj/tjfx/xfpgy/sp/art/2021.
[2]	胡志强,李存福,张国顺,等.白酒酒糟综合利用技术研究进展[J].山东化工, 2019, 48(15):76-78.
[3]	时伟,郑红梅,何珺珺,等.白酒糟中功能因子及其提取技术的研究进展[J].中国酿造, 2020, 39(7):1-6.
[4]	李瑞银,李民,张增贤,等.贮存时间对菌糠、白酒糟霉菌毒素及常规营养成分含量的影响[J].饲料研究, 2021, 44(6):118-121.
[5]	袁颉,邱树毅,彭正东,等.固态白酒生产酒糟的资源化利用研究进展[J].酿酒科技, 2012(5):88-91.
[6]	WINKLER J K, RENNICK K A, ELLER F J, et al. Phytosterol and tocopherol components in extracts of corn distiller's dried grain[J]. Agricultural and Food Chemistry, 2007, 55(16):6482-6486.
[7]	GIBREEL A, SANDERCOCK J R, LAN J, et al. Evaluation of value-added components of dried distiller's grain with solubles from triticale and wheat[J]. Bioresource Technology, 2011, 102(13):6920-6927.
[8]	孟庆国.白酒糟发酵料地栽平菇技术[J].食用菌, 2019, 41(6):55-57.
[9]	任海伟,邢雪晔,张湘越,等.白酒糟制备高纯度微晶纤维素工艺优化及其结构表征[J].中国食品学报, 2020, 20(4):108-117.
[10]	周小兵,郑璞.以白酒酒糟为原料发酵产丁二酸[J].食品与发酵工业, 2013, 39(2):7-10.
[11]	国家统计局.统计数据[EB/OL]. http://www.stats.gov.cn/tjsj/. 2021-11-28.
[12]	CINAR S O, KUCHTA K. Evaluation of temperature changes in anaerobic digestion process[J]. Detritus, 2020, 10(6):11-18.
[13]	ZIGANSHIN A M, ZIGANSHINA E E, KLEINSTEUBER S, et al. Comparative analysis of methanogenic communities in different laboratory-scale anaerobic digesters[J]. Archaea, 2016:3401272.
[14]	NIKOLAUSZ M, WALTER R F H, STRAEUBER H, et al. Evaluation of stable isotope fingerprinting techniques for the assessment of the predominant methanogenic pathways in anaerobic digesters[J]. Applied Microbiology and Biotechnology, 2013, 97(5):2251-2262.
[15]	LI X, MUPONDWA E. The commercial feasibility of an integrated closed-loop ethanol-feedlot-biodigester system based on triticale feedstock in Canadian Prairies[J]. Renewable & Sustainable Energy Reviews, 2018, 97:401-413.
[16]	BANDARA N, CHEN L Y, WU J P. Protein extraction from triticale distillers grains[J]. Cereal Chemistry, 2011, 88(6):553-559.
[17]	SOSULSKI F, LEE W, SOKHANSANJ S. Wet milling and separation of wheat distillers grains with solubles into dietary fiber and protein-fractions[J]. Cereal Chemistry, 1991, 68(6):562-565.
[18]	CROMWELL G, HERKELMAN K, STAHLY T. Physical, chemical, and nutritional characteristics of distillers dried grains with solubles for chicks and pigs[J]. Journal of Animal Science, 1993, 71(3):679-686.
[19]	KLOPFENSTEIN T J, ERICKSON G E, BERGER L L. Maize is a critically important source of food, feed, energy and forage in the USA[J]. Field Crops Research, 2013, 153:5-11.
[20]	SHURSON G C. The role of biofuels coproducts in feeding the world sustainably[J]. Annual Review of Animal Biosciences, 2017, 5:229-254.
[21]	MOSER B R, VAUGHN S F. Biodiesel from corn distillers dried grains with solubles:preparation, evaluation, and properties[J]. Bioenergy Research, 2012, 5(2):439-449.
[22]	KALIYAN N, MOREY R V, TIFFANY D G. Reducing life cycle greenhouse gas emissions of corn ethanol by integrating biomass to produce heat and power at ethanol plants[J]. Biomass & Bioenergy, 2011, 35(3):1103-1113.
[23]	CAI H, DUNN J B, WANG Z C, et al. Life-cycle energy use and greenhouse gas emissions of production of bioethanol from sorghum in the United States[J]. Biotechnology for Biofuels, 2013, 6(1):1-15.
[24]	MAHBUB N, GEMECHU E, ZHANG H, et al. The life cycle greenhouse gas emission benefits from alternative uses of biofuel coproducts[J]. Sustainable Energy Technologies and Assessments, 2019, 34:173-186.
[25]	高铭坤,温广宇,钱芳.微生物对白酒酒糟的转化利用研究进展[J].食品与机械, 2018, 34(2):191-194.
[26]	张玉诚,薛白,达勒措,等.混菌固态发酵白酒糟开发为蛋白质饲料的条件优化及营养价值评定[J].动物营养学报, 2016, 28(11):3711-3720.
[27]	宋立立,刘苗.混合菌发酵生产蛋白饲料的研究进展[J].中国饲料, 2020(11):15-19.
[28]	杨丽华,张婷婷,孟建宇.混菌固态发酵白酒酒糟制蛋白饲料的研究[J].中国饲料, 2021(13):135-138.
[29]	宋善丹,陈光吉,饶开晴,等.白酒糟固态发酵条件的筛选及营养价值评定[J].中国畜牧杂志, 2015, 51(15):66-70.
[30]	陈冬梅,韦毅,陈耀,等.巨菌草与无糠壳高粱白酒糟混合青贮品质及营养成分变化[J].饲料研究, 2021, 44(2):85-88.
[31]	任海伟,王莉,朱朝华,等.白酒糟与菊芋渣混合青贮发酵品质及微生物菌群多样性[J].农业工程学报, 2020, 36(15):235-244.
[32]	寇江涛,程钰,张海波,等.不同酶制剂对水稻秸秆和白酒糟混合青贮品质的影响[J].草地学报, 2021, 29(2):396-401.
[33]	金成国,谢玉松,范方勇.宜宾多粮浓香型白酒糟生物炭的成分和结构特征分析[J].中国酿造, 2021, 40(3):139-142.
[34]	张小娟,胡建水,智翠梅,等.超(亚)临界水处理白酒糟制备活性炭[J].化工时刊, 2019, 33(6):1-6 ,19.
[35]	李强,汪印,余剑,等.物理活化白酒糟制备多孔炭材料[J].新型炭材料, 2012, 27(6):440-447.
[36]	贾吉秀,姚宗路,赵立欣,等.连续式生物质炭化设备的研究[J].现代化工, 2015, 35(10):134-138.
[37]	赵立欣,贾吉秀,姚宗路,等.生物质连续式分段热解炭化设备研究[J].农业机械学报, 2016, 47(8):221-226 ,220.
[38]	兰珊,赵立欣,姚宗路,等.外加热式生物质连续热解设备燃气净化系统的研究[J].现代化工, 2018, 38(5):173-176.
[39]	丛宏斌,赵立欣,孟海波,等.内加热移动床生物质炭化中试设备监控系统开发[J].农业工程学报, 2015, 31(3):268-274.
[40]	郑华美,国淑梅,田华英,等.白酒糟栽培鸡腿菇研究[J].北方园艺, 2017(20):167-171.
[41]	王晓力.白酒糟生产高蛋白饲料研究进展及前景[J].中兽医医药杂志, 2013, 32(6):34-36.
[42]	周艳,周晓容.非常规发酵饲料在养猪生产中的应用[J].饲料工业, 2019, 40(12):9-14.
[43]	周建民,马友彪,张海军,等.白酒糟酵母培养物对肉仔鸡生长性能、血清抗氧化指标和肠道形态结构的影响[J].动物营养学报, 2019, 31(5):2357-2366.
[44]	谢亮,吕宏伟,彭鹏,等.发酵白酒糟替代部分玉米DDGS对肉鸡生长性能和屠宰性能的影响[J].饲料工业, 2019, 40(21):25-29.
[45]	张鑫,封伟杰,王玉璘,等.不同水平酿酒酵母发酵白酒糟对蛋鸡生产性能、蛋品质、粪便菌群微生物的影响[J].饲料工业, 2020, 41(20):26-31.
[46]	陈冬梅,陈耀,韦毅,等.无糠壳高粱白酒糟的营养成分分析[J].饲料研究, 2020, 43(7):110-113.
[47]	汪成,王之盛,胡瑞,等.不同类型白酒糟对西杂牛生长性能、养分表观消化率、血清生化指标及瘤胃发酵参数的影响[J].动物营养学报, 2021, 33(2):913-922.
[48]	曹广,王之盛,胡瑞,等.发酵酒糟对育肥牦牛生长性能、养分表观消化率及瘤胃发酵的影响[J].动物营养学报, 2020, 32(7):3255-3262.
[49]	周芯宇,王之盛,胡瑞,等.不同类型白酒糟对奶公牛生长性能、养分表观消化率、血清生化指标和瘤胃发酵参数的影响[J]. 动物营养学报, 2020, 32(8):3708-3716.
[50]	李进春,雷正达,龚洋,等.五粮型白酒糟日粮添加不同饲料添加剂对肉牛生长和血清免疫指标的影响[J].黑龙江畜牧兽医, 2020(4):91-94,98.
[51]	张旺宏,李华伟,祝倩,等.发酵白酒糟对育肥猪血浆生化参数和抗氧化指标的影响[J].动物营养学报, 2018, 30(12):5174-5181.
[52]	郑梓,闫峻,王文杰,等.酵母发酵白酒糟对育肥猪生产性能、血清生化指标及肠道微生物区系的影响[J].黑龙江畜牧兽医, 2018(22):156-160.
[53]	杨志勇,李斌,吴维科,等.酿酒酵母培养物对育肥猪的影响[J].中国畜牧业, 2017(13):56-57.
[54]	张瑞景,汪江波,蔡凤娇,等.白酒糟生产丢糟酒的研究进展[J].中国酿造, 2020, 39(6):17-21.
[55]	宗绪岩,王祥余,李丽,等.芝麻香型丢糟酒生产过程中糖化酶应用[J].食品工业科技, 2018, 39(7):78-82.
[56]	贾盼,赵东,彭志云,等.安琪酿酒曲在固态法白酒丢糟发酵中的应用[J].酿酒科技, 2017(4):57-60.
[57]	程佳丽,袁月,肖霄,等.白酒酒糟生物炭的性质及对土壤无机磷释放的影响[J].化学研究与应用, 2021, 33(5):961-968.
[58]	李哲,张宿义,杨红军,等.利用酿酒废弃物生产有机肥及肥效研究[J].食品与发酵工业, 2021, 47(2):160-166.