超声与DNA提取酚试剂协同强化污泥蛋白质溶出

崔静; 苗凤海; 张赟; 张贺; 周涛

doi:10.13205/j.hjgc.202306010

超声与DNA提取酚试剂协同强化污泥蛋白质溶出

doi: 10.13205/j.hjgc.202306010

崔静¹,
苗凤海¹,
张赟¹,
张贺¹,
周涛^2, ,

1. 天津裕川锦鸿环保科技有限公司, 天津 300459;
2. 同济大学环境科学与工程学院, 上海 200092

基金项目:

国家自然基金面上项目（51878470）

详细信息

作者简介:
崔静(1978-),女,博士,高级工程师,主要研究方向为污泥资源化。

通讯作者:
周涛(1991-),博士,助理教授,主要研究方向为固体废弃物处理处置与资源化。zhou410218380@163.com

计量
- 文章访问数: 122
- HTML全文浏览量: 17
- PDF下载量: 7
- 被引次数: 0
出版历程
- 收稿日期: 2022-03-28
- 网络出版日期: 2023-09-02

DISSOLUTION AND EXTRACTION OF PROTEIN FROM SLUDGE VIA A COMBINATION OF ULTRASOUND AND DNA EXTRACTION PHENOL REAGENT ADDITION

1. Tianjin Yuchuan Jinhong Environmental Protection Technology Co., Ltd., Tianjin 300459, China;
2. School of Environmental Science and Engineering, Tongji University, Shanghai 200092, China

摘要

摘要: 与常规污泥处理方式相比，热碱分解处理能得到富含蛋白质的高附加值产品，更有利于城镇污水处理厂污泥的土地利用处置。以利用热碱工艺获得的污泥混合液作为原料，以蛋白质、溶解性有机物（SCOD）、总有机碳（TOC）、总氮（TN）浓度为指标，探究超声和化学药剂处理对于污泥细胞的破坏和蛋白质的提取效果，并根据单因素控制变量实验确定最佳反应条件。结果表明：污泥最佳处理条件为超声功率480 W，时间20 min，环境初始温度38℃，环境pH为7.83和DNA提取酚试剂投加比例6%，此时蛋白质最大溶出量为861.71 mg/L，较对照组提升150%~200%；除超声时间无明显影响外，各因素对于污泥蛋白质浓度的影响均为极显著；在超声作用的基础上，外加DNA提取酚试剂协同处理可将胞内外碳水化合物和蛋白质脱附，6%化学药剂投加比例下，可将滤液中蛋白质的浓度提高至最大值861.71 mg/L。
- 污泥 /
- 热碱水解 /
- 蛋白质提取 /
- 超声 /
- DNA提取酚试剂
Abstract: Compared with the conventional treatment methods of sludge, the thermal alkali decomposition treatment was a preferred technology because of the high value-added protein products obtained. In this investigation, the mixture material from thermal alkali pretreatment was taken as the raw material, and variables including ultrasonic and chemical addition were investigated. Results showed that, the optimal ultrasonic power, time, initial temperature, pH and the ratio of phenol to DNA extraction reagent were 480 W, 20 min, 38℃, 7.83 and 6%, respectively. Under this condition, the protein dissolution reached 861.71 mg/L, 150% to 200% higher than the control groups. Correlation analysis suggested that except for the ultrasonic time, the effects of other factors on sludge protein concentration were extremely significant. Moreover, the addition of DNA extraction phenol reagent could desorb carbohydrates and proteins inside and outside the cell, and further increase the protein concentration to 861.71 mg/L in the filtrate with the 6% dosage.
- sludge /
- thermal alkaline hydrolysis /
- protein extraction /
- ultrasound /
- DNA extraction phenol reagent

HTML全文

参考文献(23)

[1]	刘子娟,王寅义,徐肖甜,等.剩余污泥碱性发酵产酸及脱水性能研究[J].中国给水排水, 2022, 38(3):92-98.
[2]	ODRIOZOLA M, LOUSADA M, SPANJERS H, et al. Effect of sludge characteristics on optimal required dosage of flux enhancer in anaerobic membrane bioreactors[J]. Journal of Membrane Science, 2020, 619:776-786.
[3]	孙洋洋,张雨辰,徐苏云.不同来源剩余污泥有机质赋存特征及厌氧消化潜能[J]. 中国给水排水, 2021, 37(11):17-23.
[4]	吴春旭,唐明悦,张鸿涛,等. 我国不同地区市政污泥理化性质及其对脱水性能的影响[J]. 环境工程学报,2021,15(1):271-278.
[5]	戴晓虎. 城镇污水处理厂污泥稳定化处理的必要性和迫切性的思考[J]. 给水排水,2017,43(12):1-5.
[6]	李超. 酶催化污泥水解提取蛋白质研究[D]. 郑州:郑州大学,2018.
[7]	GAO J L, WANG Y C, YAN Y X, et al. Protein extraction from excess sludge by alkali-thermal hydrolysis[J]. Environmental Science and Pollution Research, 2020, 27(8):8628-8637.
[8]	张静,赵建伟,孙英杰,等. 热碱预处理后得克隆对污泥厌氧发酵产酸及污泥特性的影响[J]. 中国环境科学,2021,41(3):1255-1263.
[9]	李萍,雷莹,李登新. 超声波协同生物法提取剩余污泥中蛋白质的研究[J]. 中国给水排水,2014,30(1):22-25.
[10]	夏雄,邓妍,刘威,等. SDS促进复合酶水解法提取剩余污泥蛋白质条件的响应面优化分析[J]. 安全与环境工程,2018,25(6):48-54.
[11]	刘改革. 溶菌酶与鼠李糖脂联用强化污泥破解效能及机制研究[D]. 哈尔滨:哈尔滨工业大学, 2020.
[12]	郭巧云,郭锦,胡骁,等. 活性污泥总蛋白提取方法的比较[J]. 环境科学与技术,2015,38(6):106-109 ,176.
[13]	FROLUND B, PALMGREN R, KEIDING K, et al. Extraction of extracellular polymers from activated sludge using a cation exchange resin[J]. Water Research, 1996, 30:1749-1758.
[14]	国家环境保护总局. 水和废水监测分析方法[M]. 4版. 北京:中国环境科学出版社,2002,258-268.
[15]	LIU L Y, RAN B, HUA C. Improved dewaterability of drilling waste sludge by ultrasonic and potassium permanganate co-treatment[J]. Journal of Environmental Chemical Engineering, 2021, 9(6):356-367.
[16]	丁静雨. 不同强度超声波促进酶解污泥提取蛋白质的研究[D]. 郑州:郑州大学,2018.
[17]	高健磊,李超,闫怡新,等. 超声波强化酶法提取污泥蛋白研究[J]. 四川环境,2018,37(2):38-44.
[18]	陆钧皓,李登新. 超声波与复合酶联合提取剩余污泥蛋白的研究[J]. 环境科学与技术,2015,38(10):53-58.
[19]	YAN Y, QIN L, GAO J, et al. Protein extraction and sludge dewatering performance of ultrasound-assisted enzymatic hydrolysis of excess sludge[J]. Environmental Science and Pollution Research, 2020, 27(15):18317-18328.
[20]	SHI X C, ZHU L, LI B, et al. Surfactant-assisted thermal hydrolysis off waste activated sludge for improved dewaterability, organic release, and volatile fatty acid production[J]. Waste Management, 2021, 124:339-347.
[21]	HE Q Y, XU P, ZHANG C, et al. Influence of surfactants on anaerobic digestion of waste activated sludge:acid and methane production and pollution removal[J]. Critical Reviews in Biotechnology, 2019, 39(5):746-757.
[22]	倪敏,李祥,刘婷婷,等.厌氧氨氧化活性污泥DNA高效提取方法探究[J].环境科学与技术, 2019, 42(10):83-87.
[23]	GIAGNONI L, MAGHERINI F, LANDI L, et al. Soil solid phases effects on the proteomic analysis of Cupriavidus metallidurans CH34[J]. Biology & Fertility of Soils, 2012, 48(4):425-433.