溢流污水快速过滤工艺的运行效能与机理研究

贾梦飞; 章改; 齐鲁; 范海涛; 王洪臣

doi:10.13205/j.hjgc.202409006

溢流污水快速过滤工艺的运行效能与机理研究

doi: 10.13205/j.hjgc.202409006

1. 中国人民大学化学与生命资源学院, 北京 100872;
2. 尚川水务有限公司, 北京 100081

详细信息

作者简介:
贾梦飞(2002-),女,硕士研究生,主要研究方向为碳源及污水处理工艺开发。mengfeijia@ruc.edu.cn;章改(1999-),男,硕士研究生,主要研究方向为水处理技术。2729953141@qq.com

通讯作者:
王洪臣(1964-),男,教授,主要研究方向为水污染治理理论与技术。whc@ruc.edu.cn

计量
- 文章访问数: 70
- HTML全文浏览量: 16
- PDF下载量: 5
- 被引次数: 14
出版历程
- 收稿日期: 2024-07-10
- 网络出版日期: 2024-12-02

RESEARCH ON OPERATIONAL EFFICIENCY AND MECHANISM OF RAPID FILTRATION PROCESS FOR OVERFLOW SEWAGE

1. School of Chemistry and Life Resources, Renmin University of China, Beijing 100872, China;
2. Shine Water Services Co., Ltd., Beijing 100081, China

摘要

摘要: 我国城市建设的高密度决定了溢流污水治理宜采用占地少的快速处理技术。构建以快速过滤为核心的溢流污水处理工艺,考察了滤料种类、过滤速度、填充量等因素对过滤效果的影响,并在材料表征及机理分析的基础上研究了不同过滤材料效果差异的原因。结果表明:聚酯纤维球和亲水性聚氨酯海绵在20,40 m/h滤速条件下均表现出良好且稳定的过滤效果,聚丙烯PP棉仅在20 m/h滤速条件下具有良好且稳定的过滤效果。在150%填充量条件下,3种滤料均表现出良好的过滤效果。污染物的去除完全取决于悬浮物的去除,因此过滤性能可等同于悬浮物去除性能。中试试验中,以聚酯纤维球为主要滤料,在40 m/h滤速条件下,对COD、SS的平均去除率分别为47.98%、82.37%。为现有成熟高分子弹性材料作为滤料与快速过滤工艺相结合应用于溢流污水处理相关研究提供参考。
- 溢流污水 /
- 快速过滤 /
- 滤料 /
- 滤速 /
- 过滤效果
Abstract: The high density of urban construction in China determines that the treatment of overflow sewage should adopt rapid treatment technology with less land occupation. This study constructs an overflow sewage treatment process with rapid filtration as the core, investigates the influence of factors such as filter material type, filtration speed, and filling amount on the filtration effect, and studies the reasons for the differences in filtration effects of different filtration materials based on material characterization and mechanism analysis. The results showed that both polyester fiber balls and hydrophilic polyurethane sponge exhibited good and stable filtration effects at filtration speeds of 20 m/h and 40 m/h, while polypropylene PP cotton only had good and stable filtration effects at filtration speeds of 20 m/h. Under the condition of a 150% filling amount, all three filter medias showed good filtration effect. The removal of pollutants depends entirely on the removal of suspended solids, therefore filtration performance is equivalent to suspended solids removal performance. In the pilot experiment, polyester fiber balls were used as the main filter material, and under a filtration rate of 40 m/h, the average removal rates of COD and SS were 47.98% and 82.37%, respectively. Provide reference for the application of mature polymer elastic materials as filter material combined with rapid filtration technology in overflow wastewater treatment related research.
- overflow sewage /
- rapid filtration /
- filter material /
- filtration speed /
- filtration effect

HTML全文

参考文献(32)

[1]	BOTTURI A, OZBAYRAM E G, TONDERA K, et al. Combined sewer overflows: a critical review on best practice and innovative solutions to mitigate impacts on environment and human health[J]. Critical Reviews in Environmental Science and Technology, 2021, 51(15): 1585-1618.
[2]	PHILLIPS P J, CHALMERS A T, GRAY J L, et al. Combined sewer overflows: an environmental source of hormones and wastewater micropollutants[J]. Environmental Science & Technology, 2012, 46(10): 5336-5343.
[3]	史秀芳, 卢亚静, 潘兴瑶, 等. 合流制溢流污染控制技术、管理与政策研究进展[J]. 给水排水, 2020, 56(增刊1): 740-747.
[4]	李俊奇, 李小静, 王文亮, 等. 合流制溢流污染的影响及其控制技术发展[J]. 给水排水, 2024, 60(4): 46-53.
[5]	PERRY W B, AHMADIAN R, MUNDAY M, et al. Addressing the challenges of combined sewer overflows[J]. Environmental Pollution, 2024, 343: 123225.
[6]	CHEN W, WANG W, HUANG G, et al. The capacity of grey infrastructure in urban flood management: a comprehensive analysis of grey infrastructure and the green-grey approach[J]. International Journal of Disaster Risk Reduction, 2021, 54: 102045.
[7]	赵泽坤, 车伍, 赵杨, 等. 中美合流制溢流污染控制概要比较[J]. 给水排水, 2018, 54(11): 128-134.
[8]	杨正, 赵杨, 车伍, 等. 典型发达国家合流制溢流控制的分析与比较[J]. 中国给水排水, 2020, 36(14): 29-36.
[9]	ZHOU J, PANG Y, FU G, et al. A review of urban rainwater harvesting in China[J]. Water Reuse, 2023, 13(1): 1-17.
[10]	刘会芳, 田凤瑛, 冯露菲, 等. 中国海绵城市建设的挑战与机遇[J]. 新型城镇化, 2024(4): 77-80.
[11]	XU C, LIU Z, CHEN Z, et al. Environmental and economic benefit comparison between coupled grey-green infrastructure system and traditional grey one through a life cycle perspective[J]. Resources, Conservation and Recycling, 2021, 174: 105804.
[12]	ALVES A, VOJINOVIC Z, KAPELAN Z, et al. Exploring trade-offs among the multiple benefits of green-blue-grey infrastructure for urban flood mitigation[J]. Science of the Total Environment, 2020, 703: 134980.
[13]	刘宇轩, 高雅弘, 王振北, 等. 城镇合流制排水系统溢流污染控制综述[J]. 环境工程, 2023, 41(12): 32-47.
[14]	周杨军, 解铭, 薛江儒, 等. 关于合流制排水系统提质增效方法与措施的思考[J]. 中国给水排水, 2021, 37(16): 1-7.
[15]	SHEWA W A, DAGNEW M. Revisiting chemically enhanced primary treatment of wastewater: a review[J]. Sustainability, 2020, 12(15): 5928.
[16]	TABOADA-SANTOS A, RIVADULLA E, PAREDES L, et al. Comprehensive comparison of chemically enhanced primary treatment and high-rate activated sludge in novel wastewater treatment plant configurations[J]. Water Research, 2020, 169: 115258.
[17]	LEE D, MIN K, KANG J H. Performance evaluation and a sizing method for hydrodynamic separators treating urban stormwater runoff[J]. Water science and technology, 2014, 69(10): 2122-2131.
[18]	孙巍. CSOs污染特点及核心处理工艺的选择[J]. 给水排水, 2021, 57(增刊1): 138-144.
[19]	MOKHTARI F, SHAMSHIRSAZ M, LATIFI M, et al. Compressibility behaviour of warp knitted spacer fabrics based on elastic curved bar theory[J]. Journal of Engineered Fibers and Fabrics, 2011, 6(4): 155892501100600404.
[20]	YAO K M, HABIBIAN M T, O'MELIA C R. Water and waste water filtration. Concepts and applications[J]. Environmental Science & Technology, 1971, 5(11): 1105-1112.
[21]	BARHATE R, LOONG C K, RAMAKRISHNA S. Preparation and characterization of nanofibrous filtering media[J]. Journal of Membrane Science, 2006, 283(1/2): 209-218.
[22]	DU X, LI Y. Experimental comparison and optimization on granular bed filters with three types of filling schemes[J]. Applied Energy, 2019, 253: 113563.
[23]	MORACI N, BILARDI S, MANDAGLIO M. Factors affecting geotextile filter long-term behaviour and their relevance in design[J]. Geosynthetics International, 2022, 29(1): 19-42.
[24]	NIU S, PARK K, YU J, et al. Operation and performance evaluation of high-speed filter using porous non-woven filamentous fibre for the treatment of turbid water[J]. Environmental Technology, 2016, 37(5): 577-589.
[25]	BAE S D, SAGEHASHI M, SAKODA A. Activated carbon membrane with filamentous carbon for water treatment[J]. Carbon, 2003, 41(15): 2973-2979.
[26]	BULEJKO P. Numerical comparison of prediction models for aerosol filtration efficiency applied on a hollow-fiber membrane pore structure[J]. Nanomaterials, 2018, 8(6): 447.
[27]	QI Y, THAPA K B, HOADLEY A F. Application of filtration aids for improving sludge dewatering properties:a review[J]. Chemical Engineering Journal, 2011, 171(2): 373-284.
[28]	LORENZEN S, YE Y, CHEN V, et al. Direct observation of fouling phenomena during cross-flow filtration: influence of particle surface charge[J]. Journal of Membrane Science, 2016, 510: 546-558.
[29]	PALMER M R, NEPF H M, PETTERSSON T J, et al. Observations of particle capture on a cylindrical collector: implications for particle accumulation and removal in aquatic systems[J]. Limnology and Oceanography, 2004, 49(1): 76-85.
[30]	RANADE M. Adhesion and removal of fine particles on surfaces[J]. Aerosol Science and Technology, 1987, 7(2): 161-176.
[31]	XU F, WEI M, ZHANG X, et al. How pore hydrophilicity influences water permeability?[J]. Research, 2019(11):1-10.
[32]	MIAO A, WEI M, XU F, et al. Influence of membrane hydrophilicity on water permeability: an experimental study bridging simulations[J]. Journal of Membrane Science, 2020, 604: 118087.

施引文献

期刊类型引用(8)

1.	欧阳诗昆，周治国，武昊辉，李亚洲，位海强，肖雄，杨前锋，冉旺，罗濯濯，殷勤俭. 合水油田含聚合物采出水处理技术的研究与应用. 化学研究与应用. 2024(01): 135-143 . 百度学术
2.	李同庆，李可，高胜骁. 油田聚合物驱污水处理技术研究进展. 化学工程师. 2024(07): 72-76 . 百度学术
3.	许跃，许洪祝，周启立，陆彩霞，史金卓，孙金龙. 压裂返排液及采出水处理示范工程实例. 水处理技术. 2024(11): 148-152 . 百度学术
4.	曾正宇，于忠臣. 化学驱采出水处理工艺技术研究进展. 化学工程师. 2023(12): 68-72 . 百度学术
5.	杨宗政，董迎春，李芳，吴志国，张忠园. 油水预分离设备的模拟设计及优化. 石油与天然气化工. 2023(06): 124-130 . 百度学术
6.	卢宪辉. 基于臭氧-三维电极工艺的油田采出水处理技术研究. 石油石化节能与计量. 2023(12): 7-11 . 百度学术
7.	中国石油天然气集团公司劳动防护用品质量监督检验中心大庆油田产品质量监督检验所. 石油石化节能与计量. 2023(12): 6 . 百度学术
8.	李蕾. 超低频电磁波处理油田采出水技术应用探讨. 油气田地面工程. 2022(11): 57-60 . 百度学术

其他类型引用(6)

资源附件(0)

访问统计

点击查看大图

计量

文章访问数: 70
HTML全文浏览量: 16
PDF下载量: 5
被引次数: 14

姓名
邮箱
手机号码
标题
留言内容
验证码

留言板

溢流污水快速过滤工艺的运行效能与机理研究

doi: 10.13205/j.hjgc.202409006

作者简介:
贾梦飞(2002-),女,硕士研究生,主要研究方向为碳源及污水处理工艺开发。mengfeijia@ruc.edu.cn;章改(1999-),男,硕士研究生,主要研究方向为水处理技术。2729953141@qq.com

通讯作者:
王洪臣(1964-),男,教授,主要研究方向为水污染治理理论与技术。whc@ruc.edu.cn

计量

RESEARCH ON OPERATIONAL EFFICIENCY AND MECHANISM OF RAPID FILTRATION PROCESS FOR OVERFLOW SEWAGE

期刊类型引用(8)

其他类型引用(6)

计量

目录

期刊在线

作者中心

友情链接

留言板

溢流污水快速过滤工艺的运行效能与机理研究

doi: 10.13205/j.hjgc.202409006

作者简介: 贾梦飞(2002-),女,硕士研究生,主要研究方向为碳源及污水处理工艺开发。mengfeijia@ruc.edu.cn;章改(1999-),男,硕士研究生,主要研究方向为水处理技术。2729953141@qq.com

通讯作者: 王洪臣(1964-),男,教授,主要研究方向为水污染治理理论与技术。whc@ruc.edu.cn

计量

出版历程

RESEARCH ON OPERATIONAL EFFICIENCY AND MECHANISM OF RAPID FILTRATION PROCESS FOR OVERFLOW SEWAGE

期刊类型引用(8)

其他类型引用(6)

计量

出版历程

目录

期刊在线

作者中心

友情链接

作者简介:
贾梦飞(2002-),女,硕士研究生,主要研究方向为碳源及污水处理工艺开发。mengfeijia@ruc.edu.cn;章改(1999-),男,硕士研究生,主要研究方向为水处理技术。2729953141@qq.com

通讯作者:
王洪臣(1964-),男,教授,主要研究方向为水污染治理理论与技术。whc@ruc.edu.cn