TEST AND ANALYSIS ON FUELING EMISSION OF B10 KITCHEN WASTE GREASE BIODIESEL FOR SHIP

LOU Di-ming; ZHANG Jiu-yang; TAN Pi-qiang; HU Zhi-yuan

doi:10.13205/j.hjgc.202002012

Volume 38 Issue 2

Feb. 2020

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > ENVIRONMENTAL ENGINEERING > 2020 > 38(2): 86-90,76

LOU Di-ming, ZHANG Jiu-yang, TAN Pi-qiang, HU Zhi-yuan. TEST AND ANALYSIS ON FUELING EMISSION OF B10 KITCHEN WASTE GREASE BIODIESEL FOR SHIP[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(2): 86-90,76. doi: 10.13205/j.hjgc.202002012

Citation:

LOU Di-ming, ZHANG Jiu-yang, TAN Pi-qiang, HU Zhi-yuan. TEST AND ANALYSIS ON FUELING EMISSION OF B10 KITCHEN WASTE GREASE BIODIESEL FOR SHIP[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(2): 86-90,76. doi: 10.13205/j.hjgc.202002012

Citation:

PDF( 1167 KB)

TEST AND ANALYSIS ON FUELING EMISSION OF B10 KITCHEN WASTE GREASE BIODIESEL FOR SHIP

doi: 10.13205/j.hjgc.202002012

Automobile College, Tongji University, Shanghai 201804, China

Received Date: 2019-04-27

Abstract

Abstract

Using a portable emission test system (PEMS), a domestic river vessel fueled with B10 kitchen waste grease biodiesel (kitchen waste oil biodiesel volume fraction of 10%, diesel volume fraction of 90%) for actual operating condition test. Under the condition of outbound and inbound port, CO, THC, NO_x and PM emission rates fluctuated significantly. In cruise condition, CO、THC and PM emission rates were relatively stable, and NO_x emission fluctuated within a certain range with changes in air flow. Compared with the emission of gaseous and particulate matter in burning pure diesel, when the ship burning burning B10 biodiesel, the CO emission factor decreased by 20.37%, 24.39% and 6.05% in the outbound, cruise and inbound condition, THC decreased by 8.2%, 8.13% and 25.23%, PM decreased by 53.11%, 22.38% and 36.55%, PN decreased by 14.17%, 18.75% and 46.47%; in the port condition, the NO_x emission factor decreased by 54.28% and 40.39%. In cruise condition, NO_x increased by 10.45%. The particle matters emitted by the two fuels all showed a bimodal distribution with the particle size, and the peak particle size was nearly the same. The amount of nuclear particulate matter decreased significantly when fueling B10 biodiesel. The test proved that ships fueled with B10 biodiesel could effectively reduce emissions of gaseous and particulate matters.
- inland river vessel,
- portable emission test system,
- biodiesel,
- gaseous matter,
- particulate matter,
- emission factor

FullText(HTML)

References(15)

References

梁明, 陈柔笛. 中国海上贸易通道现状及经略研究[J]. 国际经济合作, 2014(11):79-84.

史吉平, 杜风光, 张龙, 等. 生物柴油:绿色能源[J]. 上海节能, 2006(6):75-77.

王雷, 王建, 袁韦韦, 等. 地沟油酯交换法制取生物柴油的研究进展[J]. 环境工程, 2015,33(增刊1):520-525,537.

张允华, 楼狄明, 谭丕强, 等. 公交车燃用生物柴油的排放性、经济性与可靠性[J]. 中国环境科学, 2017,37(7):2773-2778.

吴刚, 江国和, 杨智远, 等. 船用柴油机燃用生物柴油排放与消烟机理[J]. 哈尔滨工程大学学报, 2019, 40(3):468-476.

许广举, 李铭迪, 李学智, 等. 不同掺混比例生物柴油的非常规污染物排放特性[J]. 农业工程学报, 2015, 31(21):227-232.

侯军兴, 文振华, 刘元朋, 等. 二甲醚与生物柴油喷射过程试验研究[J]. 车用发动机, 2014(1):66-69.

尹航, 丁焰, 葛蕴珊, 等. 内河船舶柴油机的实际排放特征[J]. 环境科学研究, 2014, 27(5):470-476.

付明亮, 刘欢, 贺克斌. 实际工况下内河航行船舶NO_x排放测试与分析[J]. 环境工程学报, 2018, 12(4):1065-1070.

郑轶, 陈文, 魏小栋, 等. 餐饮废油基生物柴油对柴油机有害排放特性的影响[J]. 柴油机, 2018,46(5):7-12.

GIAKOUMIS E G, RAKOPOULOS C D, DIMARATOS A M, et al. Exhaust emissions of diesel engines operating under transient conditions with biodiesel fuel blends[J]. Progress in Energy and Combustion Science, 2012, 38(5):691-715.

李瑞娜, 王忠, 刘帅. 十六烷值改进剂对甲醇/生物柴油柴油机排放的影响[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2018, 34(20):67-72.

RAKOPOULOS D C, RAKOPOULOS C D, HOUNTALAS D T, et al. Investigation of the performance and emissions of bus engine operating on butanol/diesel fuel blends[J]. Fuel, 2010, 89(10):2781-2790.

LI R N, WANG Z. Study on status characteristics and oxidation reactivity of biodiesel particulate matter[J]. Fuel, 2018, 218:218-226.

XIAO M Y, LIU H F, BI X J, et al. Experimental and numerical investigation on soot behavior of soybean biodiesel under ambient oxygen dilution in conventional and low-temperature flames[J]. Energy & Fuels, 2014, 28(4):2663-2676.

Relative Articles

[1]	YUAN Shuai, LI Yan, ZHAO Yuxiao, XU Haipeng, CHEN Lei, JIN Fuqiang, HUA Dongliang. INHIBITORY INSTABILITY ANALYSIS OF ANAEROBIC DIGESTION OF KITCHEN WASTE AND MICROECOLOGICAL ANALYSIS OF DIGESTION EFFICIENCY IMPROVEMENT[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(12): 184-192. doi: 10.13205/j.hjgc.202412022
[2]	JIN Hongqi, JIANG Rongjie, WANG Zirui, LI Luyang, LUO Jingyang. RESEARCH PROGRESS ON IMPACT AND REGULATION STRATEGIES OF TYPICAL ANTIBIOTICS ON ANAEROBIC DIGESTION EFFICIENCY OF SLUDGE: A REVIEW[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(7): 49-59. doi: 10.13205/j.hjgc.202407005
[3]	YUE Liangchen, YU Miao, CHENG Jun, LIU Keliang, HUA Junjie, GUO Hao. INFLUENCE OF LIPID CONTENT AND ELECTRIC FERMENTATION VOLTAGE ON METHANE PRODUCTION FROM FOOD WASTE ANAEROBIC DIGESTION[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(7): 200-207. doi: 10.13205/j.hjgc.202407022
[4]	LI Ziyu, LI Zhenzhou, DOU Yuting, LUO Jingyang. INFLUENCES OF HETEROLOGOUS SUBSTANCES OCCURRED IN FOOD WASTE ON ANAEROBIC DIGESTION AND REGULATION STRATEGIES: A REVIEW[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(6): 222-232. doi: 10.13205/j.hjgc.202306029
[5]	SONG Na, ZHAO Pan, GUAN Weijie, CHEN Liwei, ZHANG Shuang, WANG Qunhui. EFFECT OF ELECTRO-FERMENTATION ON HIGH TEMPERATURE ANAEROBIC DIGESTION OF FOOD WASTE AND SPENT MUSHROOM SUBSTRATE[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(7): 145-149. doi: 10.13205/j.hjgc.202307020
[6]	TANG Xin-yi, CHEN Xiang-yu, XIAO Ben-yi, LIU Rong-zhan. THERMAL-ALKALINE TREATMENT OF SEWAGE SLUDGE AND ITS ENHANCEMENT ON ANAEROBIC SLUDGE DIGESTION[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(5): 218-226. doi: 10.13205/j.hjgc.202205031
[7]	TANG Meng-yuan, ZHAO Jia-qi, QIU Chun-sheng, WANG Bing-bing, WANG Ren-jie, ZHONG Liang, SUN Li-ping. RESEARCH PROGRESS ON PHYSICOCHEMICAL CHARACTERISTICS OF BIOCHAR AND ITS IMPROVEMENT EFFECT ON ANAEROBIC DIGESTION EFFICIENCY[J]. ENVIRONMENTAL ENGINEERING , 2021, 39(9): 138-145. doi: 10.13205/j.hjgc.202109020
[8]	LI Xu-sheng, LU Sha-sha, JIANG Yuan-yan, WANG Li-ao. EFFECT AND MECHANISM OF BIOCHAR IN MITIGATING ACIDIFICATION OF ANAEROBIC DIGESTION PROCESS FOR FOOD WASTE[J]. ENVIRONMENTAL ENGINEERING , 2021, 39(12): 179-187. doi: 10.13205/j.hjgc.202112027
[15]	Wang Tao Zhang Dong Dai Lingling Dong Bin Liu Zhigang Dai Xiaohu, . RESEARCH PROGRESS ON EFFECTS OF NANO-PARTICLES ON WASTEWATER/SLUDGE ANAEROBIC DIGESTION SYSTEM[J]. ENVIRONMENTAL ENGINEERING , 2015, 33(6): 1-5. doi: 10.13205/j.hjgc.201506001
[16]	STUDY ON THE START-UP TECHNOLOGY OF TREATING KITCHEN WASTE IN IC ANAEROBIC REACTOR[J]. ENVIRONMENTAL ENGINEERING , 2014, 32(12): 87-90. doi: 10.13205/j.hjgc.201412015

Supplements(0)

Cited By

Cited by

Periodical cited type(10)

1.	吴福祥，刘欢. 基于水力旋流制浆技术的餐厨垃圾预处理工程应用. 环境科技. 2024(02): 30-33 .
2.	焦敏娜，任秀娜，王权，李荣华，木开石，张增强. 垃圾分类背景下易腐有机垃圾资源化处理模式探讨. 环境卫生工程. 2022(01): 28-35+40 .
3.	周俊，王梦瑶，王改红，马利钦，罗丽雯，黄焕忠. 餐厨垃圾资源化利用技术研究现状及展望. 生物资源. 2020(01): 87-96 .
4.	徐阳，李书航，陈轲，韩东苏，曹潇，高文通. 餐厨垃圾资源化循环利用技术的研究进展. 中国环保产业. 2020(11): 24-28 .
5.	陶雨蒙，高树梅，韩思超，唐天明. 餐厨垃圾与纤维素类有机废弃物混合发酵研究进展. 上海环境科学. 2019(01): 20-24 .
6.	朱丽可，汤晓艳，吴元，屈阳，张进锋. 沉砂浮渣分离技术在餐厨垃圾处理中的应用研究. 环境卫生工程. 2019(04): 59-64 .
7.	李志强，曹秀芹，张达飞，李彩斌. 餐厨垃圾干式厌氧消化的试验研究. 科学技术与工程. 2018(08): 343-348 .
8.	曹秀芹，徐国庆，袁海光，张达飞，江坤. 餐厨垃圾厌氧消化系统运行恢复实验分析. 环境科学与技术. 2018(11): 126-131 .
9.	汤晓艳，朱丽可，吴元，屈阳，张进锋. 餐厨垃圾处理系统中有机浆料加热试验研究. 广东化工. 2018(21): 39-40 .
10.	张达飞，曹秀芹，盛迎雪，兰效宁，郭非凡，李彩斌. 餐厨垃圾厌氧消化运行试验研究. 环境工程. 2017(06): 93-97 . 本站查看