Source Jouranl of CSCD
Source Journal of Chinese Scientific and Technical Papers
Included as T2 Level in the High-Quality Science and Technology Journals in the Field of Environmental Science
Core Journal of RCCSE
Included in the CAS Content Collection
Included in the JST China
Indexed in World Journal Clout Index (WJCI) Report
Volume 40 Issue 5
Jul.  2022
Turn off MathJax
Article Contents
Abstract
References
Article Navigation >  ENVIRONMENTAL ENGINEERING  > 2022  >  40(5): 218-226
TANG Xin-yi, CHEN Xiang-yu, XIAO Ben-yi, LIU Rong-zhan. THERMAL-ALKALINE TREATMENT OF SEWAGE SLUDGE AND ITS ENHANCEMENT ON ANAEROBIC SLUDGE DIGESTION[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(5): 218-226. doi: 10.13205/j.hjgc.202205031
Citation: TANG Xin-yi, CHEN Xiang-yu, XIAO Ben-yi, LIU Rong-zhan. THERMAL-ALKALINE TREATMENT OF SEWAGE SLUDGE AND ITS ENHANCEMENT ON ANAEROBIC SLUDGE DIGESTION[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(5): 218-226. doi: 10.13205/j.hjgc.202205031
shu

THERMAL-ALKALINE TREATMENT OF SEWAGE SLUDGE AND ITS ENHANCEMENT ON ANAEROBIC SLUDGE DIGESTION

doi: 10.13205/j.hjgc.202205031

  • 1. Research Center for Eco-Environmental Sciences, Chinese Academy of Sciences, Beijing 100085, China;

  • 2. University of Chinese Academy of Sciences, Beijing 100049, China;

  • 3. College of Textiles and Clothing, Qingdao University, Qingdao 266071, China

  • Received Date: 2021-06-05
    Available Online: 2022-07-02
    Abstract
  • Huge amounts of sludge are produced in wastewater treatment, and the treatment and disposal of sewage sludge had become a rising challenge for the wastewater plant. Anaerobic digestion is a traditional method for sewage sludge treatment, which has some shortages. Recent research showed that thermal-alkaline pretreatment could enhance the anaerobic digestion of sewage sludge. In this study, the research progress of thermal-alkaline pretreatment of sludge was thoroughly reviewed, including the mechanism of thermal-alkaline pretreatment, the impact of thermal-alkaline pretreatment on the sludge properties and anaerobic digestion and the influencing factors. And the feasibility of thermal-alkaline pretreatment for enhancing anaerobic digestion of sewage sludge was discussed through energy consumption analysis. Finally, the enhancement of thermal-alkaline pretreatment on anaerobic digestion and its prospects and problems were also discussed.
    • FullText(HTML)
    • References(48)
  • [1]
    陈丹丹,窦昱昊,卢平,等.污泥深度脱水技术研究进展[J].化工进展,2019,38(10):4722-4746.
    [2]
    LIU X G,WANG Q,TANG Y Z,et al.Hydrothermal pretreatment of sewage sludge for enhanced anaerobic digestion:resource transformation and energy balance[J].Chemical Engineering Journal,2021,410:127430.
    [3]
    王涛,宿宇.污泥处理处置技术路线综述[J].中国环保产业,2020(1):51-55.
    [4]
    NABI M,LIANG J S,ZHANG P Y,et al.Anaerobic digestion of sewage sludge pretreated by high pressure homogenization using expanded granular sludge blanket reactor:feasibility,operation optimization and microbial community[J].Journal of Environmental Chemical Engineering,2021,9(1):104720.
    [5]
    黄宇钊,冼萍,李桃,等.热-碱联合处理改善污泥厌氧消化性能的研究[J].广西大学学报(自然科学版),2019,22(3):110-112.
    [6]
    WANG X,DUAN X,CHEN J G,et al.Enhancing anaerobic digestion of waste activated sludge by pretreatment:effect of volatile to total solids[J].Environmental Technology,2016,37(12):1520-1529.
    [7]
    ZHOU P J,MESHREF M N A,DHAR B R.Optimization of thermal hydrolysis process for enhancing anaerobic digestion in a wastewater treatment plant with existing primary sludge fermentation[J].Bioresource Technology,2021,321:124498.
    [8]
    王磊,谭学军,王逸贤,等.热水解预处理剩余污泥的有机物分布及厌氧消化特性[J].环境工程,2019,37(3):35-39.
    [9]
    郑镇,刘彬,虞旭.碱-热法预处理改善污泥厌氧消化性能的试验研究[J].水资源与水工程学报,2011,22(3):110-112.
    [10]
    肖本益,阎鸿,魏源送.污泥热处理及其强化污泥厌氧消化的研究进展[J].环境科学学报,2009,29(4):673-682.
    [11]
    LI C X,ZHANG G Y,ZHANG Z K,et al.Alkaline thermal pretreatment at mild temperatures for biogas production from anaerobic digestion of antibiotic mycelial residue[J].Bioresource Technology,2016,208:49-57.
    [12]
    CARLSSON M,LAGERKVIST A,MORGAN-Sagastume F.The effects of substrate pre-treatment on anaerobic digestion systems:a review[J].Waste Management,2012,32(9):1634-1650.
    [13]
    MANCUSO G,LANGONE M,ANDREOTTOLA G,et al.Effects of hydrodynamic cavitation,low-level thermal and low-level alkaline pre-treatments on sludge solubilisation[J].Ultrasonics Sonochemistry,2019,59:104750.
    [14]
    LIU H B,WANG Y Y,WANG L,et al.Stepwise hydrolysis to improve carbon releasing efficiency from sludge[J].Water Research,2017,119:225-233.
    [15]
    刘宏波,文湘华,赵芳,等.活性污泥热碱水解释碳的实验研究[J].环境工程学报,2011,5(10):2337-2341.
    [16]
    CHO H U,PARK S K,HA J H,et al.An innovative sewage sludge reduction by using a combined mesophilic anaerobic and thermophilic aerobic process with thermal-alkaline treatment and sludge recirculation[J].Environmental Management,2013,129:274-282.
    [17]
    LIU X L,LIU H,CHEN J H,et al.Enhancement of solubilization and acidification of waste activated sludge by pretreatment[J].Waste Management,2008,28(12):2614-2622.
    [18]
    LIU X R,XU Q X,WANG D B,et al.Thermal-alkaline pretreatment of polyacrylamide flocculated waste activated sludge:process optimization and effects on anaerobic digestion and polyacrylamide degradation[J].Bioresource Technology,2019,281:158-167.
    [19]
    XIANG X Y,CHEN X G,DAI R B,et al.Anaerobic digestion of recalcitrant textile dyeing sludge with alternative pretreatment strategies[J].Bioresource Technology,2016,222:252-260.
    [20]
    NAGLER M,AICHINGER P,KUPRIAN M,et al.A case study for a cost-benefit-based,stepwise optimization of thermo-chemical WAS pre-treatment for anaerobic digestion[J].J Material Cycles Waste Management,2018,20(1):266-273.
    [21]
    盛广宏,陈蓓蓓,刘金凤.热碱处理破解污泥效果研究[J].环境科技,2013,26(2):38-42.
    [22]
    YUAN R X,SHEN Y W,ZHU N W,et al.Pretreatment-promoted sludge fermentation liquor improves biological nitrogen removal:molecular insight into the role of dissolved organic matter[J].Bioresource Technology,2019,293:122082.
    [23]
    蒋昌旺,李靖,何迪,等.热碱预处理对高含固剩余污泥厌氧消化的影响及其动力学研究[J].环境污染与防治,2019,41(8):906-909

    ,915.
    [24]
    CHEN H,YI H,LI H C,et al.Effects of thermal and thermal-alkaline pretreatments on continuous anaerobic sludge digestion:performance,energy balance and,enhancement mechanism[J].Renewable Energy,2020,147:2409-2416.
    [25]
    NAZARI L,YUAN Z S,SANTORO D,et al.Low-temperature thermal pre-treatment of municipal wastewater sludge:process optimization and effects on solubilization and anaerobic degradation[J].Water Research,2017,113:111-123.
    [26]
    邹雪梅.热碱处理对污泥厌氧消化性能的影响研究[D].哈尔滨:哈尔滨工业大学,2019.
    [27]
    代勤,张文哲,于潘芬,等.热、热碱处理对污泥溶胞和溶解性有机物的影响[J].环境科学,2018,39(5):2283-2288.
    [28]
    宋明阳,李敏,袁溪,等.污水处理厂污泥磷形态及低温热解-碱解联合处理的释磷效果研究[J].环境工程,2018,36(1):112-117.
    [29]
    毛秋燕,赵栩宁,苏宇傲,等.不同预处理方式对剩余污泥中活菌菌群及ARGs的影响[J].中国环境科学,2020,40(6):2537-2545.
    [30]
    DENG Q H,HUANG Y Z,XIAN P,et al.Optimization of thermo-alkaline pretreatment on municipal sludge and enhanced subsequent anaerobic digestion[J].Desalination and Water Treatment,2019,148:88-94.
    [31]
    XIANG Y L,XIANG Y K,WANG L P.Kinetics of activated sludge protein extraction by thermal alkaline treatment[J].Journal of Environmental Chemical Engineering,2017,5(6):5352-5357.
    [32]
    GUO H G,DU L Z,LIANG J F,et al.Influence of alkaline-thermal pretreatment on high-solids anaerobic digestion of dewatered activated sludge[J].Bioresources,2017,12(1):195-210.
    [33]
    LIU H,HAN P,LIU H B,et al.Full-scale production of VFAs from sewage sludge by anaerobic alkaline fermentation to improve biological nutrients removal in domestic wastewater[J].Bioresource Technology,2018,260:105-114.
    [34]
    MASPOLIM Y,ZHOU Y,GUO C H,et al.Comparison of single-stage and two-phase anaerobic sludge digestion systems-Performance and microbial community dynamics[J].Chemosphere,2015,140:54-62.
    [35]
    HUANG Y Y,WANG Y M,LIU S H,et al.Enhanced hydrolysis-acidification of high-solids and low-organic-content sludge by biological thermal-alkaline synergism[J].Bioresource Technology,2019,294:122234.
    [36]
    LU Q H,YU Z H,WANG L,et al.Sludge pre-treatments change performance and microbiome in methanogenic sludge digesters by releasing different sludge organic matter[J].Bioresource Technology,2020,316:123909.
    [37]
    PARK S K,JANG H M,HA J H,et al.Sequential sludge digestion after diverse pre-treatment conditions:sludge removal,methane production and microbial community changes[J].Bioresource Technology,2014,162:331-340.
    [38]
    吴惠玲,王志强,韩春,等.影响美拉德反应的几种因素研究[J].现代食品科技,2010,26(5):441-444

    ,440.
    [39]
    GIANICO A,BRAGUGLIA C M,CESARINI R,et al.Reduced temperature hydrolysis at 134 degrees C before thermophilic anaerobic digestion of waste activated sludge at increasing organic load[J].Bioresource Technology,2013,143:96-103.
    [40]
    XIAO B Y,TANG X Y,YI H,et al.Comparison of two advanced anaerobic digestions of sewage sludge with high-temperature thermal pretreatment and low-temperature thermal-alkaline pretreatment[J].Bioresource Technology,2020,304:122979.
    [41]
    白聪莉.高含固率污泥热碱预处理两相厌氧消化工艺研究[D].武汉:华中科技大学,2012.
    [42]
    RAJAN R V,LIN J G,RAY B T.Low-level chemical pretreatment for enhanced sludge solubilization[J].Research Journal of the Water Pollution Control Federation,1989,61(11/12):1678-1683.
    [43]
    徐慧敏,何国富,戴翎翎,等.低温热水解和超声联合破解污泥优化工艺的参数研究[J].中国环境科学,2016,36(4):1093-1098.
    [44]
    徐慧敏,何国富,戴翎翎,等.基于RSM模型的碱与超声联合破解污泥工艺优化[J].环境工程学报,2016,10(11):6629-6634.
    [45]
    徐慧敏,秦卫华,何国富,等.超声联合热碱技术促进剩余污泥破解的参数优化[J].中国环境科学,2017,37(9):3431-3436.
    [46]
    LIU B W,JIN R F,LIU G F,et al.Effect on sludge disintegration by EDTA-enhanced thermal-alkaline treatment[J].Water Environment Research,2020,92(1):42-50.
    [47]
    SIAMI S,AMINZADEH B,KARIMI R,et al.Process optimization and effect of thermal,alkaline,H2O2 oxidation and combination pretreatment of sewage sludge on solubilization and anaerobic digestion[J].BMC Biotechnology,2020,20(1):21.
    [48]
    王少坡,郑莎莎,王亚东,等.污泥厌氧消化的热预处理研究进展[J].环境工程学报,2016,10(10):5337-5346.
    • Relative Articles

  • Relative Articles

    [1]XU Yi, JIANG Xu, XU Yingming. EFFECT OF ADDING KNO3 AND KH2PO4 ON IMMOBILIZATION REMEDIATION OF CADMIUM IN POLLUTED SOIL[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(12): 229-236. doi: 10.13205/j.hjgc.202412027
    [2]ZHOU Ziyan, HUANG Xiang, GU Jinchuan, XUE Jia, WU Yi, YONG Yi. PASSIVATION OF ZINC, LEAD AND CADMIUM CONTAMINATED SOIL BY INORGANIC SALT MODIFIED BENTONITE[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(7): 150-158. doi: 10.13205/j.hjgc.202307021
    [3]YANG Shu, ZHOU Honghui, LI Ying, ZHANG Yun, TIAN Senlin, CHENG Xia, HU Han, HU Xuewei. EFFECT OF SAPONIN ON BIOLOGICAL OXIDATION OF PYRITE-CONTAINING SOLID WASTE FROM MINING AND DRESSING[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(3): 129-135,215. doi: 10.13205/j.hjgc.202303017
    [4]MAO Xinyu, ZHAI Senmao, JIANG Xiaosan, SUN Jingjing, YU Huaizhi. EFFECT OF MODIFIED BIOCHAR ON PHYSICO-CHEMICAL PROPERTIES OF FARMLAND SOIL AND IMMOBILIZATION OF Pb AND Cd AND THE MECHANISMS[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(2): 113-121,139. doi: 10.13205/j.hjgc.202302016
    [5]LI Yalin, LI Peng, TANG Yifan, ZHANG Wei, WANG Enci, JIN Mingyu. IMPACT OF DC VOLTAGE ON ELECTRO-REMEDIATION OF Pb AND As CONTAMINATED SOIL[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(8): 131-135,184. doi: 10.13205/j.hjgc.202208018
    [6]WANG Jinnan, WU Yufeng, LI Liangzhong, YU Lu, YANG Mengchuan, LI Bin, GUO Lianjie. RESEARCH PROGRESS OF BARRIER TECHNOLOGIES FOR SITE COMBINED HEAVY METAL POLLUTION[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(4): 244-253. doi: 10.13205/j.hjgc.202204034
    [7]LI Zhijian, WEI Li, NI Heng. RESEARCH ADVANCES AND CASE STUDY ON PASSIVATION AND CLOGGING IN PERMEABLE REACTIVE BARRIER（PRB）[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(2): 206-213,224. doi: 10.13205/j.hjgc.202202031
    [8]XU Yi, YANG Shi-hong, YOU Guo-xiang, HOU Jun. REVIEW OF ROLES OF EXTRACELLULAR POLYMERIC SUBSTANCES （EPS） IN MEDIATING THE STRUCTURE, FUNCTION AND SURFACE PROPERTIES OF MICROBIAL AGGREGATES IN WASTEWATER TREATMENT SYSTEMS[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(9): 238-245,269. doi: 10.13205/j.hjgc.202209032
    [9]LI Yajing, WANG Shaopo, LIU Lu, JIA Liyuan. SECRETORY CHARACTERISTICS OF EPS AND THE SIGNAL MOLECULES RELEASE UNDER DIFFERENT ORGANIC LOADING[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(2): 47-52. doi: 10.13205/j.hjgc.202202008
    [10]MAO Xinyu, YU Huaizhi, ZHAI Senmao, JIANG Xiaosan, XU Zhou, WANG Qilin. LONG-TERM STABILIZATION EFFECT AND ECOLOGICAL RISK ASSESSMENT OF SOIL CADMIUM AND LEAD BY USING MODIFIED COCONUT SHELL BIOCHAR[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(4): 140-146. doi: 10.13205/j.hjgc.202204020
    [11]HUO Jiajia, LUO Shengxu, WANG Yanshi, WANG Xinwei, DENG Qin, LI Jinying. PASSIVATION OF LEAD IN SOIL BY FULVIC ACID-NANO-ZERO-VALENT IRON COMPLEX[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(4): 112-120. doi: 10.13205/j.hjgc.202204016
    [12]PENG Yan, CHEN Di-yun, CHEN Nan, ZENG Lin-wei. PASSIVATION EFFECT OF CALCIUM PHOSPHATE ON URANIUM IN SEDIMENTS IN DOWNSTREAM WATERS OF A URANIUM MINE[J]. ENVIRONMENTAL ENGINEERING , 2021, 39(4): 13-19,24. doi: 10.13205/j.hjgc.202104003
    [13]CHEN Jin-yuan, LIU Xue-wen, LV Ju-feng, LV Bo-sheng, WEI Xiu-zhen. EFFECT OF BIOCHAR ON COMPOSITION OF SMP AND EPS IN ACTIVATED SLUDGE AND NITROGEN AND PHOSPHORUS REMOVAL[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(9): 133-138,207. doi: 10.13205/j.hjgc.202009022
    [14]CHEN Yun-fan, QIAN Meng-meng, KANG Zi-wei, DING Jia-hui, CHEN Jing, JIA Wen-lin. START-UP OF A COMPLETELY AUTOTROPHIC NITROGEN REMOVAL OVER NITRITE PROCESS ENHANCED BY MAGNETIC FIELD[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(8): 142-146. doi: 10.13205/j.hjgc.202008024
    [15]SONG Le-yuan, GUO Xin-chao, YU Jing. EFFECT OF SUSPENDED CARRIERS ADDITION ON PERFORMANCE AND MEMBRANE FOULING OF AnMBR[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(1): 87-92. doi: 10.13205/j.hjgc.202001013
    [16]ZHOU Wen-wu, CHEN Guan-yi, DAN Zeng, QIONGDA Zhuo-ma, ZHOU Peng, WANG Jing. COMPARISON AND SELECTION OF REHABILITATION SCHEMES FOR GROUNDWATER LEAD IN LANDFILL AREA: A CASE STUDY OF LHASA[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(6): 88-93. doi: 10.13205/j.hjgc.202006014
    [17]ZHOU Yu-han, PAN Yang, ZHANG Rui-liang, ZHENG Chao-ting, ZHI Zhong-xiang, ZHEN Guang-yin. EFFECT OF ACID-ALKALI MICROWAVE COMBINED PRETREATMENT ON RUPTURE OF SLUDGE EXTRACELLULAR POLYMERIC SUBSTANCES AND METHANE PRODUCTION[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(12): 19-25,31. doi: 10.13205/j.hjgc.202012004
    [18]CAO Da-qi, SUN Xiu-zhen, FANG Xiao-min, JIN Jing-yi, YANG Xiao-xuan, HAO Xiao-di. RECOVERY OF EXTRACELLULAR POLYMERIC SUBSTANCE: IMPACT FACTORS IN FORWARD OSMOSIS SEPARATION OF SODIUM ALGINATE[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(8): 71-75. doi: 10.13205/j.hjgc.202008012
    [19]Cong Jing Yan Dahai Li Li Jiang Xuguang Zhou Yingnan He Jie Wang Qi, . CONDENSATION AND ABSORPTION KINETICS OF THE CEMENT RAW MEAL ON LEAD AND CADMIUM AT LOW-TEMPERATURES DURING CO-PROCESSING IN CEMENT KILNS[J]. ENVIRONMENTAL ENGINEERING , 2015, 33(4): 103-107. doi: 10.13205/j.hjgc.201504022
    [20]STUDY ON THE START-UP TECHNOLOGY OF TREATING KITCHEN WASTE IN IC ANAEROBIC REACTOR[J]. ENVIRONMENTAL ENGINEERING , 2014, 32(12): 87-90. doi: 10.13205/j.hjgc.201412015
    • Supplements(0)
    • Cited By

  • Cited by

    Periodical cited type(1)

    1. 党秀丽，阿娜尔，苏燕，管秀静，欧成浩，田楚琪，王坚. 基于文献计量法对场地土壤重金属污染修复研究进展的知识图谱分析. 土壤通报. 2024(01): 277-287 .

    Other cited types(2)

  • Created with Highcharts 5.0.7Amount of accessChart context menuAbstract Views, HTML Views, PDF Downloads StatisticsAbstract ViewsHTML ViewsPDF Downloads2024-052024-062024-072024-082024-092024-102024-112024-122025-012025-022025-032025-0402.557.510
    Created with Highcharts 5.0.7Chart context menuAccess Class DistributionFULLTEXT: 14.0 %FULLTEXT: 14.0 %META: 85.3 %META: 85.3 %PDF: 0.7 %PDF: 0.7 %FULLTEXTMETAPDF
    Created with Highcharts 5.0.7Chart context menuAccess Area Distribution其他: 19.1 %其他: 19.1 %[]: 0.7 %[]: 0.7 %上海: 2.9 %上海: 2.9 %临汾: 0.7 %临汾: 0.7 %丽水: 0.7 %丽水: 0.7 %北京: 2.2 %北京: 2.2 %十堰: 0.7 %十堰: 0.7 %天津: 0.7 %天津: 0.7 %常德: 0.7 %常德: 0.7 %扬州: 1.5 %扬州: 1.5 %昆明: 2.2 %昆明: 2.2 %晋城: 1.5 %晋城: 1.5 %朝阳: 0.7 %朝阳: 0.7 %杭州: 1.5 %杭州: 1.5 %武汉: 0.7 %武汉: 0.7 %泰安: 1.5 %泰安: 1.5 %济源: 1.5 %济源: 1.5 %漯河: 1.5 %漯河: 1.5 %芒廷维尤: 30.1 %芒廷维尤: 30.1 %芝加哥: 1.5 %芝加哥: 1.5 %苏州: 1.5 %苏州: 1.5 %西宁: 11.0 %西宁: 11.0 %贵阳: 0.7 %贵阳: 0.7 %运城: 7.4 %运城: 7.4 %遵义: 0.7 %遵义: 0.7 %邯郸: 0.7 %邯郸: 0.7 %郑州: 2.2 %郑州: 2.2 %重庆: 0.7 %重庆: 0.7 %长沙: 0.7 %长沙: 0.7 %长治: 1.5 %长治: 1.5 %其他[]上海临汾丽水北京十堰天津常德扬州昆明晋城朝阳杭州武汉泰安济源漯河芒廷维尤芝加哥苏州西宁贵阳运城遵义邯郸郑州重庆长沙长治

Catalog

    通讯作者: 陈斌, bchen63@163.com
    • 1. 

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索
    Get Citation
    PDF
    XML

    Article Metrics

    Article views (384) PDF downloads(16) Cited by(3)
    Proportional views
    Related

    Journal Online

    Authors' Center

    Links

    Copyright © 《工业建筑》杂志社有限公司 京ICP备11033253号-1

    Supported by: Beijing Renhe Information Technology Co. Ltd     百度统计

    /

    DownLoad:  Full-Size Img  PowerPoint
    Return
    Return