COMBUSTION TEMPERATURE AND EMISSION CHARACTERISTICS OF FLUE GAS POLLUTANTS OF WASTE TIRES PYROLYSIS OIL RICH IN AROMATICS

YIN Zhitong; LV Hongbing; ZHANG Dongming; XU Jiao; HUANG Qunxing; ZHONG Yiliu; HUANG Pingan; PAN Yuhan

doi:10.13205/j.hjgc.202210014

Volume 40 Issue 10

Oct. 2022

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > ENVIRONMENTAL ENGINEERING > 2022 > 40(10): 105-111

YIN Zhitong, LV Hongbing, ZHANG Dongming, XU Jiao, HUANG Qunxing, ZHONG Yiliu, HUANG Pingan, PAN Yuhan. COMBUSTION TEMPERATURE AND EMISSION CHARACTERISTICS OF FLUE GAS POLLUTANTS OF WASTE TIRES PYROLYSIS OIL RICH IN AROMATICS[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(10): 105-111. doi: 10.13205/j.hjgc.202210014

Citation:

YIN Zhitong, LV Hongbing, ZHANG Dongming, XU Jiao, HUANG Qunxing, ZHONG Yiliu, HUANG Pingan, PAN Yuhan. COMBUSTION TEMPERATURE AND EMISSION CHARACTERISTICS OF FLUE GAS POLLUTANTS OF WASTE TIRES PYROLYSIS OIL RICH IN AROMATICS[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(10): 105-111. doi: 10.13205/j.hjgc.202210014

Citation:

YIN Zhitong, LV Hongbing, ZHANG Dongming, XU Jiao, HUANG Qunxing, ZHONG Yiliu, HUANG Pingan, PAN Yuhan. COMBUSTION TEMPERATURE AND EMISSION CHARACTERISTICS OF FLUE GAS POLLUTANTS OF WASTE TIRES PYROLYSIS OIL RICH IN AROMATICS[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(10): 105-111. doi: 10.13205/j.hjgc.202210014

PDF( 5366 KB)

COMBUSTION TEMPERATURE AND EMISSION CHARACTERISTICS OF FLUE GAS POLLUTANTS OF WASTE TIRES PYROLYSIS OIL RICH IN AROMATICS

doi: 10.13205/j.hjgc.202210014

1. State Key Laboratory of Clean Energy Utilization, Institute for Thermal Power Engineering, Zhejiang University, Hangzhou 310013, China;
2. Zhejiang Zheneng Xingyuan Energy Saving Technology Co., Ltd, Hangzhou 311121, China

Received Date: 2021-11-16

Abstract

Abstract

Clean combustion is the main way for the efficient energy utilization of pyrolysis oil of organic solid wastes. The content of aromatic hydrocarbons accounted for about 30% of pyrolysis oil from all-steel waste tires. The thermal value and viscosity of the pyrolysis oil were similar to that of diesel, but the flash point was much lower, only 20℃. In this study, combustion experiments were carried out in a self-designed furnace, and the characteristics of the combustion temperature and flue gas emission of pyrolysis oil were studied. It was found that the combustion temperature reached the highest when the excess air ratio was 1.3. When the excess air ratio increased to 1.4, CO content in the flue gas dropped to 0. NO_x content increased with the increase of excess air ratio. When the excess air ratio exceeded 1.3, SO₂ content decreased substantially. The increase of injection oil pressure could increase the combustion temperature, making the combustion more adequate, reducing CO content in the flue gas, and promoting the generation of thermal NO_x. When the pressure rose from 1.5 MPa to 1.75 MPa, the combustion temperature, the CO content and the NO_x content varied the most. The increase of the nozzle orifice diameter could increase the atomization cone angle, expand the oil fog to contact with the air at a larger angle, and CO content dropped accordingly. Meanwhile, the increase of atomization cone angle could reduce the spray penetration distance, which shortened the flame length and the residence time of flue gas in high-temperature area, and reduced NO_x content.
- pyrolysis aromatic-enriched oil,
- excess air ratio,
- oil pressure,
- nozzle,
- combustion temperature,
- flue gas pollutant

FullText(HTML)

References(31)

References

[1]	EPI Z, MIHAJLOVI V, URI S, et al. Experimental analysis of temperature influence on waste tire pyrolysis[J]. Energies, 2021,14(17):5403.
[2]	史一锋. 砥砺前行中的我国轮胎行业发展状况及展望[J]. 轮胎工业,2020,40(12):707-713.
[3]	VESISLAVA, TOTEVA, KIRIL, et al. Waste tires pyrolysis oil as a source of energy:methods for refining[J]. Progress in Rubber, Plastics and Recycling Technology, 2019,36(2):143-158.
[4]	陆王琳,金余其,池涌,等. 废轮胎热解制油技术及油品应用前景[J]. 化工进展,2007,26(1):13-17.
[5]	蒋智慧,刘洋,宋永猛,等. 废旧轮胎热解及热解产物研究展望[J]. 化工进展,2021,40(1):515-525.
[6]	UPADHYAY, MUKESH, PARTHASARATHY, et al. Influence of process conditions on product yield of waste tyre pyrolysis:a review[J]. Korean Journal of Chemical Engineering, 2016,33(8):2268-2286.
[7]	JANUSZEWICZ K, KAZIMIERSKI P, KOSAKOWSKI W, et al. Waste tyres pyrolysis for obtaining limonene[J]. Materials, 2020,13(6):1359.
[8]	FARHADM. A review on the thennochemical recycling of waste tyres to oil for automobile engine application[J]. Energies, 2021,14(13):3837.
[9]	刘海兵,付兴民,柳树成,等. 初温和终温对废轮胎热解产物分布影响[J]. 环境工程,2012,30(5):144-148.
[10]	CUNLIFFE A M, WILLIAMS P T. Composition of oils derived from the batch pyrolysis of tyres[J]. Journal of Analytical & Applied Pyrolysis, 1998,44(2):131-152.
[11]	MURUGAN S, RAMASWAMY M C, NAGARAJAN G. Performance, emission and combustion studies of a DI diesel engine using distilled tyre pyrolysis oil-diesel blends[J]. Fuel, 2008,87(10):2111-2121.
[12]	MURUGAN S, RAMASWAMY M C, NAGARAJAN G. The use of tyre pyrolysis oil in diesel engines[J]. Waste Management, 2008,28(12):2743-2749.
[13]	WILLIAMS P T, BOTTRILL R P, CUNLIFFE A M. Combustion of tyre pyrolysis oil[J]. Process Safety & Environmental Protection, 1998,76(4):291-301.
[14]	裴宜星. 废轮胎回转窑热解油的应用研究[D]. 杭州:浙江大学,2006.
[15]	中国环境科学研究院. 火电厂大气污染物排放标准:GB 13223-2011[M]. 北京:中国环境科学出版社,2012.
[16]	PAN Y H, SIMA J Y, WANG X W, et al. BTEX recovery from waste rubbers by catalytic pyrolysis over Zn loaded tire derived char[J]. Waste Management, 2021,131:214-225.
[17]	郑璐恺,朱彦澄,周亚波. 芳香烃种类及含量对航空发动机燃烧的排放影响[J]. 航空动力学报,2021,36(6):1244-1252.
[18]	胡园园,王志荣,黄天一. 多组分可燃液体闪点的实验研究[J]. 工业安全与环保,2010,36(5):57-59.
[19]	刘庆磊. 高粘生物质焦油进料喷嘴的数值模拟及实验研究[D]. 济南:山东大学,2013.
[20]	郝斌. 不同燃料对柴油机排气颗粒物的影响研究[D]. 天津:天津大学,2014.
[21]	余鹏,姚宗路,胡乃涛,等. 生物质固体成型燃料NO_<em>x排放规律研究现状[J]. 环境工程,2015,33(增刊1):495-498.
[22]	VELMURUGAN K, SATHIYAGNANAM A P. Effect of biodiesel fuel properties and formation of NO_<em>x emissions:a review[J]. International Journal of Ambient Energy, 2017,38(5/6/7/8):644-651.
[23]	金维平. 燃料型NO_<em>x的生成机理及控制措施[J]. 中国科技信息,2005(22A):17,26.
[24]	艾国红. 锅炉主要污染物形成机理分析[J]. 中国高新技术企业,2010(9):85-87.
[25]	SUN J F, CATON J A, JACOBS T J. Oxides of nitrogen emissions from biodiesel-fuelled diesel engines[J]. Progress in Energy & Combustion Science, 2010,36(6):677-695.
[26]	WILLIAMS P T, BOTTRILL R P. Sulphur-polycyclic aromatic hydrocarbons in tyre pyrolysis oil[J]. Fuel, 1995,74(1):736-742.
[27]	马锐,宋永一,张庆军,等.船用残渣型燃料油脱硫技术进展[J].石油化工高等学校学报,2021,34(1):15-21.
[28]	伏军,王振,袁文华,等. 喷射压力对生物柴油喷雾特性的影响[J]. 邵阳学院学报(自然科学版),2020,17(3):50-60.
[29]	GENG L M, WANG Y J, WANG Y Y, et al. Effect of the injection pressure and orifice diameter on the spray characteristics of biodiesel[J]. Journal of Traffic and Transportation Engineering, 2020,7(3):331-339.
[30]	王鹏里. 喷嘴喷孔结构参数对甲醇燃料雾化特性的影响研究[D]. 太原:太原理工大学,2018.
[31]	杨家俊,张冰洁,刘定平. 螺旋喷嘴雾化特性试验研究[J]. 环境工程,2013,31(5):71-74.

Relative Articles

[1]	JIANG Zixuan, ZHANG Lanxin, LI Tianyuan, ZHU Enbin, ZHU Fuhe, WEN Zongguo, ZHANG Liping. Analysis of carbon footprint and deep decarbonization potential of recycled polyester filament from waste PET bottles[J]. ENVIRONMENTAL ENGINEERING , 2025, 43(1): 12-20. doi: 10.13205/j.hjgc.202501002
[2]	TONG Jiaxin, LI Yi, ZHANG Wenlong, HOU Xing. RESEARCH ON WATER NETWORK OPTIMIZATION OF HIGH-TECH INDUSTRIAL PARKS FACING LOW-CARBON CONSTRAINTS[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(11): 153-161. doi: 10.13205/j.hjgc.202411017
[3]	GANG Qinyan, MA Xiaoqian, LIU Chao, WANG Han, WANG Yayi. RESEARCH ON CARBON EMISSION CHARACTERISTICS OF MUNICIPAL SOLID WASTE INCINERATION LEACHATE TREATMENT SYSTEM[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(4): 31-39. doi: 10.13205/j.hjgc.202404004
[4]	XU Xiangyu, LI Huaibo, CHEN Can, ZHANG Haichuan, CHEN Sisi, LI Ji. RESEARCH PROGRESS ON METHANE GENERATION AND EMISSION FROM URBAN SEWAGE SYSTEMS[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(11): 29-39. doi: 10.13205/j.hjgc.202411004
[5]	WANG Zhiqi, LI Jianguo, PENG Binbin, XIANG Wanli. DRIVING FACTORS AND DECOUPLING EFFECT ANALYSIS OF TRANSPORTATION CARBON EMISSIONS IN WESTERN CHINA[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(10): 213-222. doi: 10.13205/j.hjgc.202310025
[6]	REN Hongyang, DU Ruolan, XIE Guilin, JIN Wenhui, LI Xi, DENG Yuanpeng, MA Wei, WANG Bing. RESEARCH STATUS OF INFLUENCING FACTORS AND IDENTIFICATION METHODS OF CARBON EMISSIONS IN CHINA[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(10): 195-203,244. doi: 10.13205/j.hjgc.202310023
[7]	XIA Xue, SHAO Qianqi, CAO Yue, HUANG Wenxuan, FENG Qian, CAO Jiashun, LUO Jingyang. ANALYSIS OF ENERGY RECOVERY AND CARBON EMISSION DURING SLUDGE ANAEROBIC DIGESTION UNDER DIFFERENT TREATMENT ROUTES[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(7): 1-7,13. doi: 10.13205/j.hjgc.202307001
[8]	WANG Lin, YANG Muyan, GAO Yuqiang. CALCULATION AND ANALYSIS OF CARBON EMISSION IN CONSTRUCTION STAGE OF LOESS TUNNEL[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(10): 99-107,172. doi: 10.13205/j.hjgc.202310013
[9]	QUAN Zhaoxi, CHEN Xiangsheng, CHEN Feng, GAO Wang, HAN Wenlong. ANALYSIS OF CARBON REDUCTION EFFECT OF TUNNEL CONSTRUCTION MUCK SOIL UTILIZATION BASED ON LIFE CYCLE ASSESSMENT[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(10): 91-98,162. doi: 10.13205/j.hjgc.202310012
[10]	LIU Jun, PAN Tianqi, ZHAO Huihui, GUO Yan, CHEN Guanyi, HOU Li'an. A MODEL OF CARBON EMISSION REDUCTION CALCULATION FOR AEROBIC REMEDIATION PROCESS IN MSW LANDFILLS BASED ON PRINCIPAL COMPONENT ANALYSIS[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(9): 133-139. doi: 10.13205/j.hjgc.202309016
[11]	WU Cuihua, YU Xiaohua, GAO Junzheng, YAN Haochun, LU Yintao, YAO Hong. CARBON EMISSION ACCOUNTING AND REDUCTION ANALYSIS OF WASTE COLLABORATIVE DISPOSAL IN TYPICAL CEMENT KILNS[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(7): 30-36,60. doi: 10.13205/j.hjgc.202307005
[12]	WANG Shuo, LU Yunping, LIU Shuyang, CHEN Kangli. CARBON EMISSIONS OF URBAN AND INDUSTRIAL SEWAGE TREATMENT PLANTS OF SUZHOU[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(10): 173-184. doi: 10.13205/j.hjgc.202310021
[13]	FU Bin, XU Ping. EXAMPLE ANALYSIS OF CARBON EMISSION STRUCTURE OF RESIDENTIAL WATER SYSTEMS AND THEIR REDUCTION POTENTIAL[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(4): 178-184,194. doi: 10.13205/j.hjgc.202304025
[14]	ZHAO Gang, TANG Jianguo, XU Jingcheng, LUO Jingyang, JIANG Ming, YUAN Xianchen, ZHOU Chuanting. COMPARATIVE ANALYSIS ON ENERGY AND CARBON EMISSION OF TYPICAL SLUDGE TREATMENT PROJECTS IN CHINA AND THE UNITED STATES[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(12): 9-16. doi: 10.13205/j.hjgc.202212002
[15]	ZHANG Ke, LONG Jisheng, LIU Yihang, WANG Xianghui, LOU Ziyang. CARBON EMISSION CHARACTERISTICS AND REDUCTION FROM LANDFILL THROUGH FORCED AEROBIC STABILIZATION PROCESS[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(12): 17-21,60. doi: 10.13205/j.hjgc.202212003
[16]	LUO Yuli, PAN Yirong, MA Jiaxin, WANG Jiayuan, LI Chunyao, CHEN Zhenpeng, WANG Xu. RESEARCH ADVANCES ON CARBON EMISSION OF WASTEWATER RESOURCE RECOVERY AND VALORIZATION[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(6): 83-91,187. doi: 10.13205/j.hjgc.202206011
[17]	CHEN Xueming, LI Fuyi. BIBLIOMETRIC ANALYSIS OF N₂O RESEARCH IN WASTEWATER SYSTEMS IN 2000-2020[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(6): 92-96,279. doi: 10.13205/j.hjgc.202206012
[18]	WANG Zhaoyue, ZHAO Xiaying, TANG Linhui, LIU Yu, CHENG Huiyu, PAN Yirong, YAN Xu, WANG Xu. RESEARCH ADVANCES IN CARBON EMISSION MONITORING AND ASSESSMENT OF URBAN DRAINAGE AND WASTEWATER TREATMENT SYSTEMS[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(6): 77-82,161. doi: 10.13205/j.hjgc.202206010
[19]	YANG Nan, LI Yan-xia, LV Chen, ZHAO Meng, LIU Zhong-liang, LIU Hao. CARBON EMISSION ACCOUNTING AND PEAK FORECASTING OF IRON & STEEL INDUSTRY IN TANGSHAN[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(11): 44-52. doi: 10.13205/j.hjgc.202011008
[20]	CALCULATION OF CARBON EMISSION REDUCTION OF NEW ENERGY VEHICLES AND ANALYSIS OF ITS INFLUENCING FACTORS[J]. ENVIRONMENTAL ENGINEERING , 2014, 32(12): 148-152. doi: 10.13205/j.hjgc.201412027

Supplements(0)

Cited By

Cited by

Periodical cited type(2)

1.	吴允红，李俊奇，张哲，李小静. 渗排型透水铺装运行维护研究进展. 给水排水. 2022(08): 151-159 .
2.	李婷，宋新山，丁相毅，王宇晖. 海绵体透水铺装水动力过程初步研究. 南水北调与水利科技(中英文). 2022(06): 1220-1230 .

Other cited types(3)

Proportional views

Proportional views

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Get Citation

PDF

XML

Article Metrics

Article views (143) PDF downloads(2)