ENHANCEMENT OF SO<sub>4</sub><sup>2-</sup> REMOVAL BY SODIUM ALGINATE IN LIME SOFTENING PROCESS OF DESULFURIZATION WASTEWATER

WANG Rui; LI Yongli; ZHANG Hongjiang; GONG Yanzhe; HU Bin; CHEN Xi

doi:10.13205/j.hjgc.202303004

Volume 41 Issue 3

Mar. 2023

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > ENVIRONMENTAL ENGINEERING > 2023 > 41(3): 26-33

Wang Qiong, Wang Ping, Fu Hongyuan, He Zhongming. ADSORPTION OF HEXAVALENT CHROMIUM IN WASTEWATER BY MODIFIED FLY ASH DOPING PYRITE CINDERFLY ASH DOPING PYRITE CINDERWASTEWATER/WASTE TREATMENT[J]. ENVIRONMENTAL ENGINEERING , 2015, 33(10): 1-4. doi: 10.13205/j.hjgc.201510001

Citation:

WANG Rui, LI Yongli, ZHANG Hongjiang, GONG Yanzhe, HU Bin, CHEN Xi. ENHANCEMENT OF SO₄^2- REMOVAL BY SODIUM ALGINATE IN LIME SOFTENING PROCESS OF DESULFURIZATION WASTEWATER[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(3): 26-33. doi: 10.13205/j.hjgc.202303004

Citation:

PDF( 1557 KB)

ENHANCEMENT OF SO₄^2- REMOVAL BY SODIUM ALGINATE IN LIME SOFTENING PROCESS OF DESULFURIZATION WASTEWATER

doi: 10.13205/j.hjgc.202303004

1. North China Electric Power Research Institute Co., Ltd, Beijing 100045, China;
2. School of Urban Planning and Municipal Engineering, Xi'an Polytechnic University, Xi'an 710048, China

Received Date: 2021-11-10
Available Online: 2023-05-26
Publish Date: 2023-03-01

Abstract

Abstract

The mechanism of SO₄^2- removal enhanced by sodium alginate in the lime softening method was explored in this study, by treating the actual desulfurization wastewater with different combinations of lime milk, polymeric ferric sulfate and sodium alginate, through analyzing the SO₄^2- concentration, pH value, Zeta potential, particle size, surface morphology, functional groups and crystal structure after coagulation. The results showed that compared with the dosing of 7 g/L lime and 40 mg/L polymerized iron sulfate at the same time, compounding with sodium alginate could make the SO₄^2- concentration in the effluent decrease from 3991.15 mg/L to 3238.60 mg/L (mean value), and the pH value increase from 9.66 to 9.69 (mean value). Sodium alginate promoted the aggregation of the colloids through the adsorption charge neutralization and adsorption bridging mechanisms, and formed flocs with a median particle size of 30.41 μm at a dosage of 3 mg/L. By adding sodium alginate into the system, the formed CaSO₄ crystals were more regular, and the crystal clusters were relatively smaller but quite dense, thus enhancing the removal of SO₄^2-. The infrared spectroscopy and X-ray diffraction analysis indicated that, the carboxyl group (—COO^-) of the sodium alginate might facilitate the dissolution of lime by chelating the metal ions such as Ca²⁺, and the crystallization of CaSO₄ was better. The orthogonal experiment results showed that the suitable compound for SO₄^2- removal was composed of 7 g/L of lime, 30 mg/L of polymeric ferric sulfate and 2 mg/L of sodium alginate, and then the removal efficiency was 80.94%.
- sodium alginate,
- desulfurization wastewater,
- sulfate ion,
- SEM,
- FTIR

FullText(HTML)

References(22)

References

[1]	叶春松, 黄建伟, 刘通,等. 燃煤电厂烟气脱硫废水处理方法与技术进展[J]. 环境工程, 2017, 35(11):10-13 ,51.
[2]	ZHENG L B, JIAO Y Y, ZHONG H, et al. Insight into the magnetic lime coagulation-membrane distillation process for desulfurization wastewater treatment:from pollutant removal feature to membrane fouling[J]. Journal of Hazardous Materials, 2020, 391:122202.
[3]	LI B, YUN Y B, LIU G C, LI C L, et al. Direct contact membrane distillation with softening Pre-treatment for effective reclaiming flue gas desulfurization wastewater[J]. Separation and Purification Technology, 2021, 277:119637.
[4]	郭远建. 火力发电厂脱硫废水处理方式的改进与探讨[J]. 环境工程, 2020, 38(9):109-110.
[5]	张建华, 池毓菲, 邹宜金,等. 燃煤电厂脱硫废水处理技术工程应用现状与展望[J]. 工业水处理, 2020, 40(10):14-19.
[6]	姚温浩, 于飞, 马杰. 海藻酸盐复合凝胶吸附材料的合成及其在水处理中的应用[J]. 化学进展, 2018, 30(11):1722-1733.
[7]	杨晓武, 李志刚, 李培枝,等. 海藻酸钠凝胶海绵体的制备及其对Pb²⁺和Cu²⁺的吸附[J]. 精细化工, 2021, 38(1):162-168.
[8]	WU C H, WANG Y, GAO B Y, et al. Coagulation performance and floc characteristics of aluminum sulfate using sodium alginate as coagulant aid for synthetic dying wastewater treatment[J]. Separation and Purification Technology, 2012, 95:180-187.
[9]	黄立新, 王占全, 尹寿伟,等. 海藻酸钠用于红糖溶液脱钙的试验研究[J]. 华南理工大学学报(自然科学版), 2021, 49(3):106-113.
[10]	国家环境保护总局.水和废水监测分析方法[M]. 4版. 北京:中国环境科学出版集团, 2002.
[11]	张哲, 王磊, 贺苗露,等. UIO-66改性聚酰胺正渗透复合膜的制备及性能研究[J]. 中国环境科学, 2020, 40(6):2418-2425.
[12]	MOHAMMADI R, AZADMEHR A, MAGHSOUDI A. Fabrication of the alginate combusted coal gangue composite for simultaneous and effective adsorption of Zn(Ⅱ) and Mn(Ⅱ)[J]. Journal of Environmental Chemical Engineering, 2019, 7:103494.
[13]	LIU Y M, MA J, LIAN L L, et al. Flocculation performance of alginate grafted polysilicate aluminium calcium in drinking water treatment[J]. Process Safety and Environmental Protection, 2021, 155:287-294.
[14]	ZHU G C, ZHENG H L, ZHANG Z, et al. Characterization and coagulation-flocculation behavior of polymeric aluminium ferric sulfate (PAFS)[J]. Chemical Engineering Journal, 2011, 178:50-59.
[15]	LI S P, KANG Y. Effect of PO₄^3- on the polymerization of polyferric phosphatic sulfate and its flocculation characteristics for different simulated dye wastewater[J]. Separation and Purification Technology, 2021, 276:119373.
[16]	ZHAO Y X, GAO B Y, WANG Y, et al. Coagulation performance and floc characteristics with polyaluminum chloride using sodium alginate as coagulant aid:A preliminary assessment[J]. Chemical Engineering Journal, 2012, 183:387-394.
[17]	LIU C Y, GAO B Y, WANG S E, et al. Synthesis, characterization and flocculation performance of a novel sodium alginate-based flocculant[J]. Carbohydrate Polymers, 2020, 248:116790.
[18]	FERGUSON R I, CHURCH M. A simple universal equation for grain settling velocity[J]. Journal of Sedimentary Research, 2004, 74(6):933-937.
[19]	赖莉. 复配混凝剂(PAC-PDMDAAC)处理嘉陵江水源水试验研究[D].重庆:重庆大学, 2010.
[20]	YANG Z, YUAN B, HUANG X, et al. Evaluation of the flocculation performance of carboxymethyl chitosan-graft-polyacrylamide, a novel amphoteric chemically bonded composite flocculant[J]. Water Research, 2012, 46:107-114.
[21]	LAROSA C, SALERNO M, de LIMA J S, et al. Characterisation of bare and tannase-loaded calcium alginate beads by microscopic, thermogravimetric, FTIR and XRD analyses[J]. International Journal of Biological Macromolecules, 2018, 115:900-906.
[22]	SAKUGAWA K, IKEDA A, TAKEMURA A, et al. Simplified method for estimation of composition of alginates by FTIR[J]. Journal of Applied Polymer Science, 2004, 93:1372-1377.

Relative Articles

[1]	ZHANG Zhong, ZHAO Di, XU Gaojie, NING Pengge, ZHAO Yuehong, CAO Hongbin. INFLUENCE OF IMPURITIES ON DISSOLUTION BEHAVIOR OF SODIUM SULFATE IN COAL CHEMICAL INDUSTRY SALINE WASTEWATER[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(9): 156-166. doi: 10.13205/j.hjgc.202409015
[2]	ZENG Shaogeng, LIU Yao, LIU Zhongyan. DETECTION OF MUSSELS CONTAMINATED WITH CADMIUM BASED ON NEAR-INFRARED SPECTROSCOPY AND LSPTSVM[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(1): 235-242. doi: 10.13205/j.hjgc.202401030
[3]	HU Yuanxiang, LI Yongli, ZHANG Hongjiang, CAO Yinhuan, GONG Yanzhe, CHEN Xi. ANALYSIS OF ORGANIC COMPOUNDS CONTENT AND BIOTOXICITY DURING TREATMENT PROCESS OF FLUE GAS DESULFURIZATION WASTEWATER IN A COAL-FIRED POWER PLANT[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(6): 17-24. doi: 10.13205/j.hjgc.202406003
[4]	TAI Dezhi, YU Jixin, ZHANG Hua, ZENG Honghu, SUN Xiaojie, LU Ze. FULVIC ACID SPECTRAL CHARACTERISTICS DURING COMPOSTING OF BIOLEACHING SLUDGE AND DIFFERENT MATERIALS[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(3): 119-128. doi: 10.13205/j.hjgc.202303016
[5]	WANG Hongliang, XU Yueyang, ZHONG Zhaoping, HAN Lei, HUANG Jiawei, XU Yuanqiang. EFFECT OF DESULFURIZATION WASTEWATER ADDITION ON MERCURY RELEASE CHARACTERISTICS DURING COAL COMBUSTION[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(11): 69-77. doi: 10.13205/j.hjgc.202211010
[6]	XU Min, DU Hongyu, GUO Jiaming, ZHAO Xiaodan, LU Wei, SUN Chao, CHEN Yu, ZHOU Zhen. A PILOT-SCALE EXPERIMENT FOR ZERO LIQUID DISCHARGE AND RESOURCE RECOVERY OF FLUE GAS DESULFURIZATION WASTEWATER IN COAL-FIRED POWER PLANTS[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(10): 169-175. doi: 10.13205/j.hjgc.202210023
[7]	LI Si-qi, LI Zhen-yang, LIU Lin, JIANG Run, WANG Xiao-hui. THE SCREENING OF LOW-TEMPERATURE NITRIFYING BACTERIA STAINS AND THEIR IMMOBILIZATION AND DENITRIFICATION PERFORMANCE[J]. ENVIRONMENTAL ENGINEERING , 2021, 39(12): 51-58,78. doi: 10.13205/j.hjgc.202112008
[8]	LIAO Quan, LUO Hua-yong, RONG Hong-wei, CHEN Bing-wei, LIANG Ying. ADSORPTION PERFORMANCE OF TETRACYCLINE ONTO NANO-ALUMINA MODIFIED GEL BEADS[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(9): 36-42. doi: 10.13205/j.hjgc.202009006
[9]	LU Hong-sheng, GAO Yu-ting, ZHANG Xue, SUN Pei-ming, QIU Meng-meng. REMOVAL OF LEAD(Pb²⁺)FROM SOIL WITH MICROBIAL FUEL CELLS TECHNOLOGY[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(9): 236-240,184. doi: 10.13205/j.hjgc.202009038
[10]	ZHOU Chuan, WU Qi-rong, YU Jiang-tao, QIN Fu-chu. NUMERICAL SIMULATION FOR FGD WASTEWATER EVAPORATION IN THE FLUE DUCT OF A 2×350 MW COAL-FIRED UNIT[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(5): 96-101. doi: 10.13205/j.hjgc.202005017
[19]	Kang Haiyan Yang Zhiguang Huang Xiaonan, . REMOVAL OF HEAVY METALS USING NANOSCALE ZERO-VALENT IRON IMMOBILIZED BY SODIUM ALGINATE/β-CYCLODEXTRIN[J]. ENVIRONMENTAL ENGINEERING , 2015, 33(6): 144-147. doi: 10.13205/j.hjgc.201506032

Supplements(0)

Cited By

Cited by

Periodical cited type(2)

1.	胡远翔，李永立，张洪江，曹银焕，宫延哲，陈希. 燃煤电厂脱硫废水处理过程中有机物组分及生物毒性解析. 环境工程. 2024(06): 17-24 . 本站查看
2.	李俊，杨虎君，王灵芝，辛举贤，彭涛，王黎，张松. 电厂脱硫废水软化除硬实验研究. 安徽化工. 2024(05): 141-144+149 .