DESIGN AND DEVELOPMENT OF A STABILIZER FOR ARSENIC-CONTAINING RESIDUE BASED ON SIMPLEX-CENTROID DESIGN METHOD

YU Zhiyuan; LI Erping; YANG Ting; DAI Xin

doi:10.13205/j.hjgc.202305012

Volume 41 Issue 5

May 2023

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > ENVIRONMENTAL ENGINEERING > 2023 > 41(5): 84-91

LI Xiaolong, ZHANG Tao, ZHAO Jingchen. INFLUENCE MECHANISM OF ABRASIVE RESISTANCE OF ACTIVATED CARBON FOR FLUE GAS PURIFICATION[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(5): 45-51,60. doi: 10.13205/j.hjgc.202305007

Citation:

YU Zhiyuan, LI Erping, YANG Ting, DAI Xin. DESIGN AND DEVELOPMENT OF A STABILIZER FOR ARSENIC-CONTAINING RESIDUE BASED ON SIMPLEX-CENTROID DESIGN METHOD[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(5): 84-91. doi: 10.13205/j.hjgc.202305012

Citation:

PDF( 11201 KB)

DESIGN AND DEVELOPMENT OF A STABILIZER FOR ARSENIC-CONTAINING RESIDUE BASED ON SIMPLEX-CENTROID DESIGN METHOD

doi: 10.13205/j.hjgc.202305012

1. Hunan Provincial Key Laboratory of Water Pollution Control Technology, Hunan Research Academy of Environmental Science, Changsha 410042, China;
2. Jiangxi Copper Technology Institute Co., Ltd, Research Institute of Chemical Metallurgy, Nanchang 330096, China

Received Date: 2022-06-13

Abstract

Abstract

In this study, the simplex-centroid design method (SCMD) was used to model and optimize the mixing ratio of FeSO₄·H₂O zero-valent iron (ZVI) and manganese dioxide (MnO₂) as the raw materials, and a new composite Fe-based stabilizer was designed and developed, and then applied to the stabilization of arsenic-containing residue. The results showed that the optimum combination for high As stabilization performance and low cost of stabilizer was the mixture of 65.05, 10.00 and 24.95 % FeSO₄·H₂O, ZVI and MnO₂. The leaching concentration of As decreased from 162 mg/L to 0.645 mg/L, lower than the limit value(1.2 mg/L) prescribed in China. The stability mechanism of As in ACR was studied by SEM-EDS, FTIR and XPS, while the available As was stabilized by adsorption, complexation and precipitation of Fe/Mn (hydride) oxide and Fe(Ⅲ), forming stable amorphous Fe/Mn-As. The composite Fe-based stabilizer combined with H₂SO₄ obtained excellent stability of As through a process of release-oxidation-stabilization. This study provides an sound theoretical basis for design of multi-component composite stabilizers and effective stabilization of arsenic-containing residue.
- arsenic-containing residue,
- mixture design,
- stabilizer,
- long-term stability

FullText(HTML)

References(18)

References

[1]	LOWENSTAM H A. Minerals formed by organisms[J]. Science, 1981, 211(4487): 1126-1131.
[2]	RIVEROS P A, DUTRIZAC J E, SPENCER P. Arsenic disposal practices in the metallurgical industry[J]. Canadian Metallurgical Quarterly, 2001, 40(4): 395-420.
[3]	ZHANG D N, WANG S F, WANG Y, et al. The long-term stability of calcium arsenates: implications for phase transformation and arsenic mobilization[J]. Journal of Environmental Sciences, 2019, 84(10): 29-41.
[4]	MARTINEZ-VILLEGAS N, BRIONES-GALLARDO R, RAMOS-LEAL J A, et al. Arsenic mobility controlled by solid calcium arsenates: a case study in Mexico showcasing a potentially widespread environmental problem[J]. Environmental Pollution, 2013, 176(5): 114-122.
[5]	YOON I H, MOON D H, KIM K W, et al. Mechanism for the stabilization/solidification of arsenic-contaminated soils with Portland cement and cement kiln dust[J]. Journal of Environmental Management, 2010, 91(11): 2322-2328.
[6]	张淑媛, 童宏祥, 徐诗琦, 等. 次氯酸钙/氧化钙对高砷污泥的氧化稳定化处理[J]. 环境工程学报, 2018, 12(2): 625-629.
[7]	WANG X, ZHANG H, WANG L L, et al. Transformation of arsenic during realgar tailings stabilization using ferrous sulfate in a pilot-scale treatment[J]. The Science of the Total Environment, 2019, 668: 32-39.
[8]	CLANCY T M, SNYDER K V, REDDY R, et al. Evaluating the cement stabilization of arsenic-bearing iron wastes from drinking water treatment[J]. Journal of Hazardous Materials, 2015, 300: 522-529.
[9]	罗中秋, 周新涛, 贾庆明, 等. 磷渣基地聚物材料固化砷钙渣的机理[J]. 硅酸盐学报, 2015, 43(5):699-704.
[10]	LI J S, WANG L, CUI J L, et al. Effects of low-alkalinity binders on stabilization/solidification of geogenic As-containing soils: spectroscopic investigation and leaching tests[J]. Science of the Total Environment, 2018, 631/632: 1486-1494.
[11]	LI Y, MIN X B, CHAI L Y, et al. Co-treatment of gypsum sludge and Pb/Zn smelting slag for the solidification of sludge containing arsenic and heavy metals[J]. Journal of Environmental Management, 2016, 181: 756-761.
[12]	LIU D G, MIN X B, KE Y, et al. Co-treatment of flotation waste, neutralization sludge, and arsenic-containing gypsum sludge from copper smelting: solidification/stabilization of arsenic and heavy metals with minimal cement clinker[J]. Environmental Science and Pollution Research, 2018, 25(8): 7600-7607.
[13]	李辕成, 闵小波, 柴立元, 等. 冶炼废渣协同固化/稳定化含砷污泥[C]//第五届重金属污染防治及风险评价研讨会暨重金属污染防治专业委员会2015年学术年会,南宁, 2015: 261-267.
[14]	LI E P, YANG T, WANG Q, et al. Long-term stability of arsenic calcium residue (ACR) treated with FeSO₄ and H₂SO₄: function of H⁺ and Fe(Ⅱ)[J]. Journal of Hazardous Materials, 2021, 420: 126549.
[15]	JING C Y, KORFIATIS G P, MENG X G. Immobilization mechanisms of arsenate in iron hydroxide sludge stabilized with cement[J]. Environmental Science & Technology, 2003, 37(21): 5050-5056.
[16]	JIA Y F, XU L Y, WANG X, et al. Infrared spectroscopic and X-ray diffraction characterization of the nature of adsorbed arsenate on ferrihydrite[J]. Geochimica et Cosmochimica Acta, 2007, 71(7): 1643-1654.
[17]	SONG J, JIA S Y, YU B, et al. Formation of iron (hydr) oxides during the abiotic oxidation of Fe (Ⅱ) in the presence of arsenate[J]. Journal of Hazardous Materials, 2015, 294: 70-79.
[18]	WANG S F, ZHANG D N, LI X L, et al. Arsenic associated with gypsum produced from Fe (Ⅲ)-As (Ⅴ) coprecipitation: implications for the stability of industrial As-bearing waste[J]. Journal of Hazardous Materials, 2018, 360: 311-318.

Relative Articles

[1]	XU Jiarui, LIU Hao, LUAN Weihao, WANG Chao, LIU Changqing, YANG Yandong. ADSORPTION PERFORMANCE OF DISSOLVED ORGANIC MATTER BY IRON-MODIFIED ACTIVATED CARBON FROM SECONDARY EFFLUENT OF WASTEWATER TREATMENT PLANTS[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(3): 67-72. doi: 10.13205/j.hjgc.202403008
[2]	TAN Yujie, CHEN Yayi, ZHOU Binjie, LU Xueqin, ZHEN Guangyin, HU Weijie. PROMOTING DEWATERABILITY OF WASTE ACTIVATED SLUDGE BY ACTIVATED CARBON ACTIVATED PERSULFATE OXIDATION[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(5): 70-74. doi: 10.13205/j.hjgc.202405009
[3]	MA Yuhui, ZHANG Yizhong, GUO Jian, HUO Hanxin. PREPARATION OF ACTIVATED CARBON FROM HAWTHORN SEED VIA TWO-STEP PYROLYSIS-CO₂ ACTIVATION METHOD FOR ADSORPTION OF LOMEFLOXACIN FROM AQUEOUS SOLUTION[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(3): 147-155. doi: 10.13205/j.hjgc.202403018
[4]	LIANG Wenjun, LU Dan, HU Wei. EVALUATION OF ADSORPTION PERFORMANCE USING COMMERCIAL ACTIVATED CARBON FOR TYPICAL GASOLINE-VAPOR VOCs AT SERVICE STATIONS[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(10): 65-72. doi: 10.13205/j.hjgc.202410009
[5]	SHI En, ZHANG Shuai, ZHANG Miao, LIU Shasha, ZOU Yuliang, ZHANG Xiangzhi. ENVIRONMENTAL IMPACT ASSESSMENT OF SLUDGE-BASED ACTIVATED CARBON PREPARATION PROCESS BASED ON LIFE CYCLE[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(2): 40-47. doi: 10.13205/j.hjgc.202402005
[6]	SONG Na, ZHAO Pan, GUAN Weijie, CHEN Liwei, ZHANG Shuang, WANG Qunhui. EFFECT OF ELECTRO-FERMENTATION ON HIGH TEMPERATURE ANAEROBIC DIGESTION OF FOOD WASTE AND SPENT MUSHROOM SUBSTRATE[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(7): 145-149. doi: 10.13205/j.hjgc.202307020
[7]	WU Xinming, AN Hao, ZHAO Junyu, OU Zixuan, HAO Liangshan, LI Chao. PREPARATION OF Fe/Mn-PAC CATALYSTS AND DEGRADATION OF REACTIVE BRILLIANT BLUE KN-R BY CATALYTIC OZONATION[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(4): 32-39. doi: 10.13205/j.hjgc.202304005
[8]	YANG Qiling, WANG Ruwei. EVOLUTION CHARACTERISTIC AND KINETIC MODEL FOR FUNCTIONAL GROUPS IN BITUMINOUS COAL DURING PYROLYSIS[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(7): 138-144. doi: 10.13205/j.hjgc.202307019
[9]	DU Minghui, BI Yingying, DONG Li, WANG Yong, SUN Xiaoming. INFLUENCE MECHANISM OF ACTIVATED CARBON PARTICLE SIZE ON O₃-AC TREATMENT OF ORGANIC WASTEWATER[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(4): 22-28. doi: 10.13205/j.hjgc.202204004
[10]	DANG Xiaoqing, JING Kairui, MA Hongzhou, DONG Haoyun, CAO Li, LI Yu, LIU Xia, LI Shijie. EXPERIMENTAL RESEARCH ON VACUUM-THERMAL REGENERATION OF ACTIVATED CARBON FOR ADSORPTION OF VOCs AND THE INFLUENCING FACTORS[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(8): 62-68,130. doi: 10.13205/j.hjgc.202208008
[11]	LIU Zhuan-nian, TENG Ying-ying, FAN Yi-dan. PREPARATION OF GO/AC/Ti COMPOSITE ELECTRODE AND ITS ADSORPTION ELECTROLYSIS PERFORMANCE ON METHYL ORANGE[J]. ENVIRONMENTAL ENGINEERING , 2021, 39(11): 143-148. doi: 10.13205/j.hjgc.202111018
[12]	CHEN Li, LI Jia-bin, FU Wan-yi, ZHANG Xi-hui. EFFECT OF CERAMIC MEMBRANE COMBINED PROCESS IN TREATMENT OF SLUDGE WATER FROM DRINKING WATER TREATMENT PLANT[J]. ENVIRONMENTAL ENGINEERING , 2021, 39(7): 80-87,12. doi: 10.13205/j.hjgc.202107009
[13]	LUO Ya-yue, LI Cui-qing, ZHANG Wei, ZHANG Chen, SONG Yong-ji, WANG Hong. RESEARCH PROGRESS IN CATALYSTS FOR SELECTIVE CATALYTIC OXIDATION OF NITRIC OXIDE[J]. ENVIRONMENTAL ENGINEERING , 2021, 39(1): 101-105,88. doi: 10.13205/j.hjgc.202101015
[14]	LIU Yan-ling, LI Tian-yu, WANG Xiao-mao, XIE Yue-feng, HUANG Xia. INFLUENCE MECHANISM OF SURFACE PROPERTIES ON FOULING BEHAVIORS OF HIGH-PRESSURE MEMBRANES[J]. ENVIRONMENTAL ENGINEERING , 2021, 39(7): 46-53,45. doi: 10.13205/j.hjgc.202107005
[15]	ZHU Tao, HAN Yi-wei, WANG Ruo-nan, ZHANG Xing, LIU Hai-bing, LIU Feng. EXPERIMENTAL STUDY ON VACUUM PRESSURE SWING ADSORPTION OF LOW CONCENTRATION COAL-BED METHANE IN TWIN TOWERS[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(10): 156-161,46. doi: 10.13205/j.hjgc.202010025
[16]	CHEN Mei-feng, LI Xin-li, YANG Pei-lin, LUO Qian, QIN Fan-xin. STABILIZATION OF AS CONTAMINATED SOILS BY MODIFIED NANO-TITANIUM DIOXIDE[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(10): 222-227. doi: 10.13205/j.hjgc.202010035
[17]	SHAN Wei, WANG Yan, ZHENG Kai-kai, LI Ji. TECHNOLOGY COMPARISON AND ANALYSIS ON COD REMOVAL UPGRADING OF WASTEWATER TREATMENT PLANTS FOR HIGH PROPORTION OF INDUSTRY WASTEWATER[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(7): 32-37,24. doi: 10.13205/j.hjgc.202007005
[18]	SHI Hui-min, WANG Qun-hui, NI Jin, GAO Ming, WU Chuan-fu. DEGRADATION OF AMOXICILLIN SIMULATED WASTEWATER USING A THREE-DIMENSIONAL ELECTRODES REACTOR[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(5): 30-35. doi: 10.13205/j.hjgc.202005006
[19]	CHEN Wei-gang, WU Hai-xia, FAN Jia-wei. ACTIVATED CARBON HETEROGENEOUS ACTIVATION OF DIFFERENT PERSULFATES TO DEGRADATION AZO DYE ACID ORANGE Ⅱ[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(8): 113-118,57. doi: 10.13205/j.hjgc.202008019
[20]	Zhang Xiaoxu, Zhang Hongyu, Li Guoxue, . EFFECT OF ADDITIVE QUANTITY OF STALKS ON H2 S AND NH3 EMISSION DURING KITCHEN WASTE COMPOSTING[J]. ENVIRONMENTAL ENGINEERING , 2015, 33(1): 95-99. doi: 10.13205/j.hjgc.201501022

Supplements(0)

Cited By

Cited by
Periodical cited type(1)
1. 孟豪，折媛，苗红生，李纪萱，沈正华，邢相栋，张朝晖. 冶炼烟气脱硝用碳基低温NH_3-SCR催化剂研究进展. 功能材料. 2024(08): 8075-8082 .
Other cited types(0)

Proportional views

Proportional views

通讯作者: 陈斌, bchen63@163.com

1.
沈阳化工大学材料科学与工程学院沈阳 110142

Get Citation

PDF

XML

Article Metrics

Article views (88) PDF downloads(2)

DESIGN AND DEVELOPMENT OF A STABILIZER FOR ARSENIC-CONTAINING RESIDUE BASED ON SIMPLEX-CENTROID DESIGN METHOD

doi: 10.13205/j.hjgc.202305012

Abstract

References

Relative Articles

Cited by

Periodical cited type(1)

Other cited types(0)

Proportional views

Catalog

通讯作者: 陈斌, bchen63@163.com

Article Metrics

Proportional views

Related

Journal Online

Authors' Center

Links

DESIGN AND DEVELOPMENT OF A STABILIZER FOR ARSENIC-CONTAINING RESIDUE BASED ON SIMPLEX-CENTROID DESIGN METHOD

doi: 10.13205/j.hjgc.202305012

Abstract

References

Relative Articles

Cited by

Periodical cited type(1)

Other cited types(0)

Proportional views

Catalog

通讯作者: 陈斌, bchen63@163.com

Article Metrics

Proportional views

Related

Journal Online

Authors' Center

Links

Export File

Citation

Format

Content