RESEARCH PROGRESS IN REGULATION STRATEGIES FOR WATER PURIFICATION EFFICIENCY OF GRAVITY-DRIVEN MEMBRANE FILTRATION TECHNOLOGY

LU Xiaofei; YU Junke; MA Jun; LI Jun; WANG Haidong

doi:10.13205/j.hjgc.202309002

Volume 41 Issue 9

Sep. 2023

Turn off MathJax

Article Contents

Article Navigation > ENVIRONMENTAL ENGINEERING > 2023 > 41(9): 10-17

LU Xiaofei, YU Junke, MA Jun, LI Jun, WANG Haidong. RESEARCH PROGRESS IN REGULATION STRATEGIES FOR WATER PURIFICATION EFFICIENCY OF GRAVITY-DRIVEN MEMBRANE FILTRATION TECHNOLOGY[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(9): 10-17. doi: 10.13205/j.hjgc.202309002

Citation:

LU Xiaofei, YU Junke, MA Jun, LI Jun, WANG Haidong. RESEARCH PROGRESS IN REGULATION STRATEGIES FOR WATER PURIFICATION EFFICIENCY OF GRAVITY-DRIVEN MEMBRANE FILTRATION TECHNOLOGY[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(9): 10-17. doi: 10.13205/j.hjgc.202309002

Citation:

LU Xiaofei, YU Junke, MA Jun, LI Jun, WANG Haidong. RESEARCH PROGRESS IN REGULATION STRATEGIES FOR WATER PURIFICATION EFFICIENCY OF GRAVITY-DRIVEN MEMBRANE FILTRATION TECHNOLOGY[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(9): 10-17. doi: 10.13205/j.hjgc.202309002

PDF( 2794 KB)

RESEARCH PROGRESS IN REGULATION STRATEGIES FOR WATER PURIFICATION EFFICIENCY OF GRAVITY-DRIVEN MEMBRANE FILTRATION TECHNOLOGY

doi: 10.13205/j.hjgc.202309002

LU Xiaofei^{1
,
,},
YU Junke¹,
MA Jun²,
LI Jun¹,
WANG Haidong³

1. School of Municipal and Environmental Engineering, Shenyang Jianzhu University, Shenyang 110168, China;
2. State Key Laboratory of Urban Water Resource and Environment, School of Environment, Harbin Institute of Technology, Harbin 150090, China;
3. School of Energy and Environment, Shenyang Aerospace University, Shenyang 110136, China

Received Date: 2023-04-14
Available Online: 2023-11-15

Abstract

Abstract

Gravity-driven membrane filtration (GDM) technology has shown significant advantages in the field of water treatment, especially in the safety assurance of dispersed drinking water, due to its low operating cost, high effluent quality, stable flux, and no need for backwashing. However, the disadvantages of GDM, such as lower stable flux and limited removal capacity for some contaminants, limit its popularization and application. Based on the research and application requirements for the optimization and improvement of water purification efficiency of GDM, this paper summarizes the research progress in strategies for regulating GDM efficiency from the perspectives of stable flux, contaminant removal efficiency, membrane pollution control, and membrane cleaning. This paper discusses the improvement of influent water quality, structural control of the bio-cake layer, optimization of operating parameters, configuration of membrane components, modification of membrane materials, and the role of combined technologies in improving the water purification efficiency of GDM. It also expounds membrane pollution control methods and membrane cleaning strategies, and looks into the future research and practical directions around GDM technology to provide support in expanding the scope of use of GDM, and accelerating the application of GDM technology in practical projects including water plants.
- gravity-driven membrane filtration,
- water purification efficiency,
- stable flux,
- bio-cake layer,
- membrane fouling

FullText(HTML)

References(58)

References

[1]	梁恒,唐小斌,王金龙,等.无清洗重力驱动超滤工艺净水效能及机理[J].哈尔滨工业大学学报,2020,52(6):103-110.
[2]	CHOMIAK A, MIMOSO J, KOETZSCH S, et al. Biofilm formation and permeate quality improvement in gravity driven membrane ultrafiltration[J]. Water Supply,2014,14(2):274-282.
[3]	TANG X B, DING A, QU F S, et al. Effect of operation parameters on the flux stabilization of gravity-driven membrane (GDM) filtration system for decentralized water supply[J]. Environmental Science & Pollution Research, 2016, 23(16):16771-16780.
[4]	CHOMIAK A, DERLON N, TRABER J, et al. Biofilm increases permeate quality by organic carbon degradation in low pressure ultrafiltration[J]. Water Research, 2015, 85(Nov.15):512-520.
[5]	陈楠,李星,杨艳玲,等.低水头、低通量浸没式直接超滤工艺净水效能研究[J].中国给水排水, 2016,32(19):53-57.
[6]	唐小斌,张洪嘉,王元馨,等.缓速滤池耦合重力流超滤工艺净化微污染地表水研究[J].给水排水, 2020,46(11):25-32.
[7]	宋瑞霖.活性炭/沸石强化重力流超滤系统除污染效能及膜污染机制研究[D].哈尔滨:哈尔滨工业大学, 2021.
[8]	AKHONDI E, WU B, SUN S, et al. Gravity-driven membrane filtration as pretreatment for seawater reverse osmosis:linking biofouling layer morphology with flux stabilization[J].Water Research,2015,70:158-173.
[9]	CHOMIAK A, TRABER J, MORGENROTH E, et al. Biofilm increases permeate quality by organic carbon degradation in low pressure ultrafiltration[J].Water Research, 2015,85:512-520.
[10]	PRONK W, DING A, MORG E, et al. Gravity-driven membrane filtration for water and wastewater treatment:a review[J]. Water Research, 2019,149(Feb.1):553-565.
[11]	公维佳, 王嘉硕, 刘宪武, 等. GAC/GDM组合工艺用于村镇饮用水净化机制及调控[J].哈尔滨工业大学学报, 2022,54(8):34-42.
[12]	HUANG Y D, CHENG P, TAN F, et al. Effect of coagulation pretreatment on the performance of gravity-driven membrane filtration with Yangtze River water[J].Journal of Cleaner Production,2021,297:126736.
[13]	杨海洋. 混凝/超滤处理微污染地表水及滤饼调控去除污染物研究[D].哈尔滨:哈尔滨工业大学,2017.
[14]	LEE D, LEE Y, CHOI S S, et al. Effect of membrane property and feed water organic matter quality on long-term performance of the gravity-driven membrane filtration process[J]. Environmental Science and Pollution Research, 2019,26(2):1152-1162.
[15]	刘雨瑶. 蚯蚓生物滤池耦合重力流超滤工艺除污染效能与膜污染调控研究[D].哈尔滨:哈尔滨工业大学,2020.
[16]	TANG X B, DING A, PRONK W, et al. Biological pre-treatments enhance gravity-driven membrane filtration for the decentralized water supply:linking extracellular polymeric substances formation to flux stabilization[J]. Journal of Cleaner Production, 2018,197:721-731.
[17]	REN Y, MA Y L, MIN G Y, et al. A mini review of multifunctional ultrafiltration membranes for wastewater decontamination:additional functions of adsorption and catalytic oxidation[J].Science of the Total Environment,2020,762:143083.
[18]	MA J Y, SHI J, DING H C, et al. Synthesis of cationic polyacrylamide by low-pressure UV initiation for turbidity water flocculation[J]. Chemical Engineering Journal, 2017,312:20-29.
[19]	MUHAMMAD, BILAL A, HONGYU K, et al. Assembling CoAl-layered metal oxide into the gravity-driven catalytic membrane for Fenton-like catalytic degradation of pharmaceuticals and personal care products[J].Chemical Engineering Journal, 2023,463:142340.
[20]	TANG X B, PRONK W, DING A, et al. Coupling GAC to ultra-low-pressure filtration to modify the biofouling layer and bio-community:flux enhancement and water quality improvement[J].Chemical Engineering Journal,2018,333:289-299.
[21]	鹿晓菲,王晨熹,马放,等.重力驱动型膜滤技术在水处理中的应用研究进展[J]. 水处理技术, 2022,48(2):18-22.
[22]	唐小斌. 生物滤饼层/超滤耦合工艺净化水源水机理及优化研究[D].哈尔滨:哈尔滨工业大学,2018.
[23]	聂中林,马赫,梁鹏,等.不同填料曝气生物滤池处理微污染河水的效果[J].中国给水排水, 2020, 36(17):41.
[24]	DERLON N, PETER-VARBANETS M, SCHEIDEGGER A, et al. Predation influences the structure of biofilm developed on ultrafiltration membranes[J]. Water Research, 2012,46(10):3323-3333.
[25]	TANG X B, PRONK W, TRABER J, et al. Integrating granular activated carbon (GAC) to gravity-driven membrane (GDM) to improve its flux stabilization:respective roles of adsorption and biodegradation by GAC[J]. Science of the Total Environment, 2020, 768:144758.
[26]	KUS B, KANDSAMY J, VIGNESWARAN S, et al. Gravity driven membrane filtration system to improve the water quality in rainwater tanks[J]. Water Supply, 2013,13(2):479-485.
[27]	TANG X B, DING A, QU F S, et al. Effect of operation parameters on the flux stabilization of gravity-driven membrane (GDM) filtration system for decentralized water supply[J]. Environ Sci Pollut Res Int, 2016,23(16):16771-16780.
[28]	CHEN R, LIANG H, WANG J L, et al. Effects of predator movement patterns on the biofouling layer during gravity-driven membrane filtration in treating surface water[J]. The Science of the Total Environment, 2021,771:145372.
[29]	SHAO S L, SHI D T, LI Y Q, et al. Effects of water temperature and light intensity on the performance of gravity-driven membrane system[J]. Chemosphere, 2019, 216:324-330.
[30]	LI C, CARL G, WA G,et al. Effect of cold water temperature on membrane structure and properties[J]. Journal of Membrane Science,2017,540:19-26.
[31]	PERTER-VARBANETS M, MARGOT J, TRABER J, et al. Mechanisms of membrane fouling during ultra-low pressure ultrafiltration[J]. Journal of Membrane Science, 2011, 377(1/2):42-53.
[32]	DING A, LIANG H, LI G B, et al. A low energy gravity-driven membrane bioreactor system for grey water treatment:permeability and removal performance of organics[J]. Journal of Membrane Science, 2017,542:408-417.
[33]	MARYNA, PERTER-VARBANETS, WILLI, et al. Intermittent operation of ultra-low pressure ultrafiltration for decentralized drinking water treatment[J]. Water Research, 2012, 46(10):3272-3282.
[34]	王元馨. 重力驱动超滤处理二级出水的效能调控与机理[D].哈尔滨:哈尔滨工业大学,2021.
[35]	WU B, HOCHSTRASSER F, AKHONDI E, et al. Optimization of gravity-driven membrane (GDM) filtration process for seawater pretreatment[J]. Water Research, 2016, 93:133-140.
[36]	陈简素璇,戴若彬,田晨昕,等.多孔纳米材料改性水处理超滤膜的研究进展[J].化工进展,2022,41(1):264-276.
[37]	张洪嘉.铁锰对重力流超滤工艺的影响机制及基于预涂动态膜的调控原理[D].哈尔滨:哈尔滨工业大学,2021.
[38]	张怡文,孙秀花,高昌录.PVDF膜的亲水改性及其研究进展[J].塑料科技,2021,49(10):95-99.
[39]	何强, 左庆扬, 陈子惟, 等. 预沉积生物炭强化重力驱动超滤膜处理受污染地表水的效能研究[J].中国环境科学, 2023,43(3):1122-1130.
[40]	SHAO S L, FENG Y J, YU H R, et al. Presence of an adsorbent cake layer improves the performance of gravity-driven membrane (GDM) filtration system[J]. Water Research, 2016,108:240-249.
[41]	HU M, ZHAO L,YU N B, et al. Application of ultra-low concentrations of moderately-hydrophobic chitosan for ultrafiltration membrane fouling mitigation[J]. Journal of Membrane Science,2021,635:119540.
[42]	LIU C H, SONG D, ZHNAG W J, et al. Constructing zwitterionic polymerbrush layer to enhance gravity-driven membrane performance by governing biofilm formation[J]. Water Research,2020,168:115181.
[43]	朱腾义,严和婷,李毛.聚偏氟乙烯膜改性方法研究进展[J].化学通报,2018,81(12):1089-1095.
[44]	ARYANTI P T P, NUGROHO F A, ANWAR N, et al. PVC-based gravity driven ultrafiltration membrane for river water treatment[J]. Materials Today:Proceedings, 2023, 3:103.
[45]	DING A, SONG R L. Presence of powdered activated carbon/zeolite layer on the performances of gravity-driven membrane (GDM) system for drinking water treatment:ammonia removal and flux stabilization[J]. Science of the Total Environment,2021,799:149415.
[46]	刘婷. 三种预处理技术对超滤膜污染的影响及其机理研究[D]. 哈尔滨:哈尔滨工业大学,2011.
[47]	CHEN R, ZHANG H, WANG J L, et al. Insight into the role of biogenic manganese oxides-assisted gravity-driven membrane filtration systems toward emerging contaminants removal[J]. Water Research, 2022, 224:119111.
[48]	龚曼瑀. Mn(Ⅲ)预氧化强化重力驱动超滤膜去除水中阿特拉津的效能[D]. 哈尔滨:哈尔滨工业大学, 2019.
[49]	宋丹,刘彩虹,程巍,等.重力驱动微滤膜给水处理工艺特性与除污效能[J].中国给水排水,2020,36(3):22-26.
[50]	王吉超. 基于多巴胺仿生改性聚醚砜超滤膜及其抗污染性能研究[D]. 哈尔滨:哈尔滨工业大学, 2020.
[51]	贾宝辉. 重力驱动膜处理含藻水的效能与机理[D]. 哈尔滨:哈尔滨工业大学, 2017.
[52]	XUE W J, JIAN M P, LIN T, et al. A novel strategy to alleviate ultrafiltration membrane fouling by rotating membrane module[J]. Chemosphere, 2020, 260:1275351-1275358.
[53]	ZHAO F C, LI Z X, ZHOU X L, et al. The comparison between vibration and aeration on the membrane performance in algae harvesting[J]. Journal of Membrane Science, 2019, 592.
[54]	柳斌,瞿芳术,施周,等.低压重力驱动式超滤工艺处理引黄水库水中试研究[J].给水排水,2018,44(6):40-44.
[55]	RUAN H, YANG Z R, LIN J Y, et al. Biogas slurry concentration hybrid membrane process:pilot-testing and RO membrane cleaning[J]. Desalination, 2015, 368:171-180.
[56]	HUBE S, LEE S, CHONG T H, et al. Biocarriers facilitated gravity-driven membrane filtration of domestic wastewater in cold climate:combined effect of temperature and periodic cleaning[J]. Science of the Total Environment, 2022, 833:155248.
[57]	刘雷,郑雨,王岳,等.重力流超滤长期净水效果评价及其清洗方法[J]. 环境工程学报, 2022, 16(6):1797-1806.
[58]	SHAMI I U, WU B. Gravity-driven membrane reactor for decentralized wastewater treatment:effect of reactor configuration and cleaning protocol[J]. Membranes, 2021(11):388.