TREATMENT OF SULFATE WASTEWATER BY SULFATE-REDUCING BACTERIA WITH RESIDUAL SLUDGE THERMAL ALKALINE-HYDROLYSATE AS CARBON SOURCE

CUI Tiantian; ZHOU Jiti; JIN Ruofei; LI Xin

doi:10.13205/j.hjgc.202402003

Volume 42 Issue 2

Feb. 2024

Turn off MathJax

Article Contents

Abstract

References

Article Navigation > ENVIRONMENTAL ENGINEERING > 2024 > 42(2): 23-31

CUI Tiantian, ZHOU Jiti, JIN Ruofei, LI Xin. TREATMENT OF SULFATE WASTEWATER BY SULFATE-REDUCING BACTERIA WITH RESIDUAL SLUDGE THERMAL ALKALINE-HYDROLYSATE AS CARBON SOURCE[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(2): 23-31. doi: 10.13205/j.hjgc.202402003

Citation:

CUI Tiantian, ZHOU Jiti, JIN Ruofei, LI Xin. TREATMENT OF SULFATE WASTEWATER BY SULFATE-REDUCING BACTERIA WITH RESIDUAL SLUDGE THERMAL ALKALINE-HYDROLYSATE AS CARBON SOURCE[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(2): 23-31. doi: 10.13205/j.hjgc.202402003

Citation:

CUI Tiantian, ZHOU Jiti, JIN Ruofei, LI Xin. TREATMENT OF SULFATE WASTEWATER BY SULFATE-REDUCING BACTERIA WITH RESIDUAL SLUDGE THERMAL ALKALINE-HYDROLYSATE AS CARBON SOURCE[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(2): 23-31. doi: 10.13205/j.hjgc.202402003

PDF( 4418 KB)

TREATMENT OF SULFATE WASTEWATER BY SULFATE-REDUCING BACTERIA WITH RESIDUAL SLUDGE THERMAL ALKALINE-HYDROLYSATE AS CARBON SOURCE

doi: 10.13205/j.hjgc.202402003

Key Laboratory of Industrial Ecological and Environmental Engineering of Ministry of Education, Dalian University of Technology, Dalian 116024, China

Received Date: 2023-03-15
Available Online: 2024-04-28

Abstract

Abstract

This study aimed at the problem of insufficient carbon sources during the treatment of sulfate wastewater and explored the feasibility of using the alkaline-thermal hydrolysate of residual sludge as the carbon source of sulfate-reducing bacteria(SRBs). Batch experimental results showed that the optimum sludge pretreatment conditions were T=70 ℃, initial pH=13 and t=10 h, and the optimal parameters for SO₄^2- removal by SRBs were ρ(COD)=10000 mg/L, ρ(SO₄^2-)=2500 mg/L, initial pH=7, and T=35 ℃. Under this condition, the removal efficiency of SO₄^2- reached 90% above, and the utilization efficiency of ρ(COD) reached 80%. The SO₄^2- removal efficiency with sludge alkaline-thermal hydrolase was compared with four other SRBs common carbon sources(sodium lactate, sodium propionate, sodium acetate, and glucose), and the experiment showed that the removal efficiency of SO₄^2- using sludge hydrolysate as SRBs carbon source was higher than other carbon sources. The research confirmed that the residual sludge alkaline-thermal hydrolysate can be used as the carbon source of SRBs, which provided favorable support for the treatment of SO₄^2- wastewater and utilization of residual sludge.
- alkaline-thermal hydrolysate,
- residual sludge,
- SRBs,
- sulfate wastewater,
- supplementary carbon source

FullText(HTML)

References(44)

References

[1]	LI X,HAN J,LIU Y,et al.Summary of research progress on industrial flue gas desulfurization technology[J].Separation and Purification Technology,2022,281:119849.
[2]	王海棠,钟振成,王靖宇,等.高镁型脱硫废水零排放处理技术研究[J].应用化工,2022,51(9):2762-2766.
[3]	黄超,黄飞平,秦振清,等.GLT络合铁脱硫技术在焦炉煤气钠碱法脱硫装置上的工业应用[J].河南化工,2022,39(10):44-46.
[4]	高泽磊,叶新军,秦茜,等.环集烟气脱硫废液压滤设备及管道材质的选型[J].硫酸工业,2021(2):33-35,38.
[5]	KUSHKEYYCH I,HYZOVA B,VITEZOVA M,et al.Microscopic methods for identification of sulfate-reducing bacteria from various habitats[J].International Journal of Molecular Sciences,2021,22(8):4007.
[6]	祝紫莹,刘倩倩,邓燕萍,等.硫酸盐还原菌介导水铁矿相转化特征及其产物对Cr(Ⅵ)固存的影响[J].环境科学学报,2022,42(12):231-240.
[7]	周磊,徐乐昌,高洁.硫酸盐还原菌复合碳源的筛选[J].铀矿冶,2022,41(1):73-77.
[8]	郭琼,肖琳,于忆潇,等.以圆币草发酵液为碳源时硫酸盐还原菌处理重金属废水[J].微生物学通报,2017,44(9):2019-2028.
[9]	张琳琳,刘亚洁,陈诗怡,等.果皮发酵液为碳源的硫酸盐还原性与酸性含铀废水处理效果[J].有色金属(冶炼部分),2022(6):74-83.
[10]	戴晓虎.我国污泥处理处置现状及发展趋势[J].科学(上海),2020,72(6):30-34.
[11]	李哲,林嘉薇,胡勇有.热碱解—水解预处理剩余污泥的效果研究[J].华南师范大学学报,2019,51(1):42-48.
[12]	GAO J,WANG Y,YAN Y,et al.Protein extraction from excess sludge by alkali-thermal hydrolysis[J].Environmental Science and Pollution Research,2020,27(8):8628-8637.
[13]	徐静阳,大浦宏隆,刘德华,等.剩余污泥热碱解及其用于微生物油脂生产的探索[J].生物工程学报,2011,27(3):482-488.
[14]	XIAO B,DAI Q,YU X,et al.Effects of sludge thermal-alkaline pretreatment on cationic red X-GRL adsorption onto pyrolysis biochar of sewage sludge[J].Journal of Hazardous Materials,2018,343:347-355.
[15]	YU X,ZHANG C,QIU L,et al.Anaerobic digestion of swine manure using aqueous pyrolysis liquid as an additive[J].Renewable Energy,2020,147:2484-2493.
[16]	XU C,DING Y,LIU J,et al.Anaerobic digestion of sulphate wastewater mediated by biochar[J].Environmental Technology,2023,44:1667-1678.
[17]	张小里,刘海洪,陈开勋,等.硫酸盐还原菌生长规律的研究[J].西北大学学报(自然科学版),1999(5):397-402.
[18]	NA S,Shon H,Kim J.Minimization of excess sludge and cryptic growth of microorganisms by alkaline treatment of activated sludge[J].The Korean Journal of Chemical Engineering,2011,28(1):164-169.
[19]	赵虹焰,周集体,金若菲,等.热碱法破解污泥动态实验的条件优化[J].环境工程,2020,38(7):71-74 ,121.
[20]	罗毅,李晓丽,刘晖,等.超声波、碱、超声波/碱预处理污泥对污泥水解效果的影响[J].河北工业科技,2015,32(6):552-556.
[21]	王孝平,邢树礼.考马斯亮蓝法测定蛋白含量的研究[J].天津化工,2009,23(3):40-42.
[22]	董群,郑丽伊,方积年.改良的苯酚—硫酸法测定多糖和寡糖含量的研究[J].中国药学杂志,1996(9):38-41.
[23]	CHAI G,WANG D,ZHANG Y,et al.Effects of organic substrates on sulfate-reducing microcosms treating acid mine drainage:performance dynamics and microbial community comparison[J].Journal of Environmental Management,2023,330:117148.
[24]	HENDERSON R K,BAKER A,MURPHY K R,et al.Fluorescence as a potential monitoring tool for recycled water systems:a review[J].Water Research,2009,43(4):863-881.
[25]	HUANG Y,WANG Y,LIU S,et al.Enhanced hydrolysis-acidification of high-solids and low-organic-content sludge by biological thermal-alkaline synergism[J].Bioresource Technology,2019,294:122234.
[26]	ZHANG Z,ZHANG C,YANG Y,et al.A review of sulfate-reducing bacteria:metabolism,influencing factors and application in wastewater treatment[J].Journal of Cleaner Production,2022,376:134109.
[27]	杨建设,黄玉堂,吴楚施,等.温度和pH对硫酸盐还原菌活性的影响[J].茂名学院学报,2006,16(4):1-3.
[28]	李新荣,沈德中.硫酸盐还原菌的生态特性及其应用[J].应用与环境生物学报,1999(增刊1):10-13.
[29]	JANYASUTHIWONG S,RENE E R,ESPOSITO G,et al.Effect of pH on the performance of sulfate and thiosulfate-fed sulfate reducing inverse fluidized bed reactors[J].Journal of Environmental Engineering,2016,9(142):C4015012.
[30]	YANG G,ZHANG G,ZHUAN R,et al.Transformations,inhibition and inhibition control methods of sulfur in sludge anaerobic digestion:a review[J].Current Organic Chemistry,2016,26(20):2780-2789.
[31]	SHARMA K,DERLON N,HU S,et al.Modeling the pH effect on sulfidogenesis in anaerobic sewer biofilm[J].Water Research,2014,49:175-185.
[32]	NIELSEN G,COUDERT L,JANIN A,et al.Influence of organic carbon sources on metal removal from mine impacted water using sulfate-reducing bacteria bioreactors in cold climates[J].Mine Water and the Environment,2019,38(1):104-118.
[33]	LUO H,TENG W,LIU G,et al.Sulfate reduction and microbial community of autotrophic biocathode in response to acidity[J].Process Biochemistry,2017,54:120-127.
[34]	HEMALATHA M,SHANTHIS J,VENKATA M S.Self-induced bioelectro-potential influence on sulfate removal and desalination in microbial fuel cell[J].Bioresource Technology,2020,309:123326.
[35]	LI J,CAI M,MIAO Y,et al.Bacterial community structure and predicted function in an acidogenic sulfate-reducing reactor:effect of organic carbon to sulfate ratios[J].Bioresource Technology,2019,293:122020.
[36]	WASMUND K,MUßMANN M,LOY A.The life sulfuric:microbial ecology of sulfur cycling in marine sediments[J].Environmental Microbiology Reports,2017,9(4):323-344.
[37]	LEE Y W,HOANG T S,RHEE M,et al.Sinirhodobacter hankyongi sp.nov.,a novel denitrifying bacterium isolated from sludge[J].International Journal of Systematic and Evolutionary Microbiology,2020,70(1):668.
[38]	LI W,LIU J,ZHEN Y,et al.Simultaneous removal of nitrite and organics in a biofilm-enhanced high-salt wastewater treatment system via mixotrophic denitrification coupled with sulfate reduction[J].Journal of Water Process Engineering,2021,40:101976.
[39]	KESHRI J,PRADEEP R A,SIME-NGANDO T.Distinctive patterns in the taxonomical resolution of bacterioplankton in the sediment and pore waters of contrasted freshwater lakes[J].Environmental Microbiology,2018,75(3):662-673.
[40]	YAN J,YE W,JIAN Z,et al.Enhanced sulfate and metal removal by reduced graphene oxide self-assembled Enterococcus avium sulfate-reducing bacteria particles[J].Bioresource Technology,2018,266:447-453.
[41]	RAMPELOTTO P H.Ecophysiology and Application of Acidophilic Sulfur-Reducing Microorganisms[M].Switzerland:Springer International Publishing AG,2016:141-175.
[42]	ZHANG L,LIN X,ZHANG Z,et al.Elemental sulfur as an electron acceptor for organic matter removal in a new high-rate anaerobic biological wastewater treatment process[J].Chemical Engineering Journal,2018,331:16-22.
[43]	HORN E J,VAN HILLE R P,OYEKOLA O O,et al.Functional microbial communities in hybrid linear flow channel reactors for desulfurization of tannery effluent[J].Microorganisms,2022,10(11):2305.
[44]	QIAN Y,XU M,DENG T,et al.Synergistic interactions of Desulfovibrio and Petrimonas for sulfate-reduction coupling polycyclic aromatic hydrocarbon degradation[J].Journal of Hazardous Materials,2021,407:124385.

Relative Articles

[1]	PANG Heliang, DING Jiangbo, WANG Yan, LIU Jiawei, QIN Qiwen, ZHANG Ruiyang, XU Bing, DU Juanjuan, ZHANG Bo, LU Jinsuo. Research progress of component separation technology of sewer sludge in urban drainage network[J]. ENVIRONMENTAL ENGINEERING , 2025, 43(1): 89-96. doi: 10.13205/j.hjgc.202501010
[2]	PAN Yuan, SUN Ruizhe, YU Hanqing. RESEARCH ADVANCES IN BIOLOGICAL DENITRIFICATION TECHNOLOGY DRIVEN BY EXOGENOUS ELECTRON DONORS[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(9): 1-12. doi: 10.13205/j.hjgc.202409001
[3]	LAN Rui, YANG Xiaofan, CUI Haoran, YAN Lingjian, LIU Xinyi, GAO Xiaozhong, SUN Dezhi, CHENG Xiang. RESEARCH PROGRESS ON VIVIANITE CRYSTALLIZATION-BASED PHOSPHORUS REMOVAL AND RECOVERY FROM WASTEWATER[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(9): 91-99. doi: 10.13205/j.hjgc.202409008
[4]	XIAO Chenxi, WANG Hongwu, DAI Xiaohu. A REVIEW OF CHARACTERISTICS AND CONTROL TECHNOLOGIES OF URBAN NON-POINT SOURCE POLLUTION[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(12): 21-31. doi: 10.13205/j.hjgc.202312003
[5]	FAN Yu, HUA Yu, YANG Donghai, DAI Xiaohu. RESEARCH PROGRESS ON SEPARATION AND RECOVERY OF ALUMINUM COAGULANTS FROM WASTEWATER SLUDGE IN THE CONTEXT OF CIRCULAR ECONOMY[J]. ENVIRONMENTAL ENGINEERING , 2023, 41(9): 210-220. doi: 10.13205/j.hjgc.202309026
[6]	GUO Yun, LI Zhouyan, WANG Zhiwei. RESEARCH PROGRESS OF ELECTROCHEMICAL MEMBRANE FILTRATION FOR WATER TREATMENT[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(12): 253-269. doi: 10.13205/j.hjgc.202212034
[7]	WANG Zhaoyue, ZHAO Xiaying, TANG Linhui, LIU Yu, CHENG Huiyu, PAN Yirong, YAN Xu, WANG Xu. RESEARCH ADVANCES IN CARBON EMISSION MONITORING AND ASSESSMENT OF URBAN DRAINAGE AND WASTEWATER TREATMENT SYSTEMS[J]. ENVIRONMENTAL ENGINEERING , 2022, 40(6): 77-82,161. doi: 10.13205/j.hjgc.202206010
[8]	WU You, GAO Shu-jia, WANG Tian-yu, SUN Jing-qiu, HU Cheng-zhi. RESEARCH PROGRESS OF ELECTRO-DRIVEN SELECTIVE MEMBRANE SEPARATION TECHNOLOGY[J]. ENVIRONMENTAL ENGINEERING , 2021, 39(7): 30-37,115. doi: 10.13205/j.hjgc.202107003
[9]	WANG Ya-qi, CHANG Tian, CHEN Qing-cai. RESEARCH PROGRESS OF COMPOSITION CHARACTERISTICS AND TREATMENT TECHNOLOGIES OF VOLATILE ORGANIC COMPOUNDS FROM COOKING FUME[J]. ENVIRONMENTAL ENGINEERING , 2021, 39(6): 90-98. doi: 10.13205/j.hjgc.202106014
[10]	ZHANG Xing, QIAN Zhen-qing, ZHANG De-feng, ZHU Tao, YUAN Qian-cheng, YE Ze-fu. RESEARCH PROGRESS OF COOKING FUME EMISSION CHARACTERISTICS AND PURIFICATION TECHNOLOGIES[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(1): 37-41,20. doi: 10.13205/j.hjgc.202001005
[14]	Shi Wenping, Zhu Jia, Zhang Chaosheng, Gao Jingsi. RELATIONSHIP BETWEEN SEDIMENT NUTRIENT RELEASE AND ALGAE GROWTH IN THE SHALLOW AREA OF THE RESERVOIR[J]. ENVIRONMENTAL ENGINEERING , 2015, 33(5): 75-80. doi: 10.13205/j.hjgc.201505016

Supplements(0)

Cited By

Cited by

Periodical cited type(6)

1.	刘闯，吴志博，马兴冠，王超军，姜悦，张黎. 尿液制备磷酸铵镁对茼蒿生长及品质的影响. 北方园艺. 2024(08): 1-8 .
2.	刘闯，王超军，马兴冠，姜悦，吴志博，张黎，傅金祥. 厕所粪尿制备有机肥与磷酸铵镁对茼蒿生产的影响. 浙江农业学报. 2023(12): 2914-2922 .
3.	吕弈成，刘洪波，方月英，孙圣广. 电化学沉淀/复合黏土吸附法回收黄水中的营养盐. 中国给水排水. 2020(03): 1-7 .
4.	刘雪瑜，林郁，王方舟，颜秉斐，肖书虎，魏东洋. 晶种对磷回收效率的影响及其产物分析. 环境工程. 2020(02): 81-85+139 . 本站查看
5.	张奇誉，刘来胜. 农村分散式生活污水源分离技术现状与发展趋势分析. 中国农村水利水电. 2020(08): 20-24 .
6.	朱国荣，谢倍珍，刘红. 载人深空探测活动中的尿液处理回收技术分析. 深空探测学报. 2018(06): 582-590 .