超高温自发热好氧堆肥工艺处理生活垃圾探究

王晓诚; 郭颖; 颜开红

doi:10.13205/j.hjgc.202010029

超高温自发热好氧堆肥工艺处理生活垃圾探究

doi: 10.13205/j.hjgc.202010029

1. 东南大学土木工程学院, 南京 210096;
2. 上海海洋大学农业经济管理学院, 上海 201306;
3. 江苏科技大学生物与环境工程学院, 江苏镇江 212000

基金项目:

国家自然科学基金项目（51578132）；江苏省自然科学基金（201708106001）。

详细信息

作者简介:
王晓诚(1981-),男,博士。1937316074@qq.com

计量
- 文章访问数: 178
- HTML全文浏览量: 17
- PDF下载量: 10
- 被引次数: 0
出版历程
- 收稿日期: 2019-07-16

TREATMENT OF DOMESTIC WASTE BY ULTRA-HIGH TEMPERATURE SPONTANEOUS HEATING AEROBIC COMPOSTING PROCESS

1. School of Civil Engineering, Southeast University, Nanjing 210096, China;
2. School of Agricultural Economics and Management, Shanghai Ocean University, Shanghai 201306, China;
3. College of Biological and Environmental Engineering, Jiangsu University of Science and Technology, Zhenjiang 212000, China

摘要

摘要: 超高温自发热已被应用于剩余污泥好氧堆肥，然而该技术对生活垃圾好氧堆肥过程的影响尚不清晰。此外，固氮剂过磷酸钙（CS）对超高温自发热好氧堆肥处理生活垃圾的影响也不明确。以生活垃圾为研究对象，建立空白组（R1）和添加CS （R2）的生活垃圾超高温自发热堆肥体系，探究了CS影响下生活垃圾超高温自发热过程中温度、含氧量、含水率、温室气体释放、溶解性COD及腐熟指标的变化规律，分析CS对生活垃圾堆肥后微生物群落特征的影响。结果表明：实验组温度最高为80.3℃，高于空白组，且最低含氧量、含水率均低于R1。实验组中甲烷和N₂O的最大释放速率分别为0.09，1.3 g/（kg·d），均显著低于空白组，CS存在有助于生活垃圾堆肥保氮。此外，实验组中溶解COD的最大含量为42.3 mg/g，略高于R1，CS利于堆体中有机物释放。微生物群落分析表明，实验组中Saccharomonospor和Planifilum的相对丰度分别为25.6%和10.3%，堆体腐熟程度较高。
- 生活垃圾 /
- 超高温自发热 /
- 固氮剂 /
- 温室气体
Abstract: Ultra-high temperature spontaneous heating has been applied to aerobic composting of excess sludge. However, the effect of this technology on aerobic composting of domestic waste was not clear. In addition, the effect of nitrogen fixing agent calcium superphosphate (CS) on ultra-high temperature spontaneous heating aerobic composting for domestic waste treatment was not clear, either. In this study, the blank group (R1) and the composting system with CS (R2) were established. The changes of temperature, oxygen content, moisture content, greenhouse gas release, soluble COD and maturity index, in the process of super-high temperature spontaneous heating of domestic waste under the influence of CS were investigated. The effects of CS on the microbial community characteristics of domestic waste composting were analyzed. The results showed that the highest temperature of R2 was 80.3℃, higher than that of blank group, and the lowest oxygen content and water content were lower than that of R1. The maximum releasing rates of methane and N₂O in R2 were 0.09 g/(kg·d) and 1.3 g/(kg·d), respectively, significantly lower than those in R1. The presence of CS was beneficial to nitrogen conservation in MSW composting. In addition, the maximum soluble COD content in R2 was 42.3 mg/g, slightly higher than that in R1. CS was beneficial to the release of organic matter in the reactor. The relative abundance of Saccharomonospor and Planifilum in R2 was 25.6% and 10.3% respectively, and the maturity of the stack was also higher.
- domestic waste /
- ultra-high temperature spontaneous heating /
- nitrogen fixing agent /
- greenhouse gases

HTML全文

参考文献(18)

崔东宇,何小松,祝超伟,等. 生活垃圾堆肥浸提液组成及其演化规律[J]. 环境工程学报,2014,8(12):5424-5430.

周营,朱能武,刘博文,等. 微生物菌剂复配及强化厨余垃圾好氧堆肥效果分析[J]. 环境工程学报,2018,12(1):294-303.

LIU N, ZHOU J L, HAN L J, et al. Role and multi-scale characterization of bamboo biochar during poultry manure aerobic composting[J]. Bioresource Technology, 2017, 241:190-199.

GU W J, LU Y S, TAN Z Y, et al. Fungi diversity from different depths and times in chicken manure waste static aerobic composting[J]. Bioresource Technology, 2017, 239:447-453.

薛兆骏,周国亚,俞肖峰,等.超高温自发热好氧堆肥工艺处理剩余污泥[J].中国环境科学,2017,37(9):3399-3406.

薛兆骏,彭永臻,王鹏鹞,等.自发热持续高温好氧堆肥碳、氮、腐殖酸变化过程[J].中国环境科学,2018,38(11):4094-4098.

吴娟,何胜洲,李国学,等. 添加过磷酸钙的猪粪堆肥污染气体减排工艺优化[J].农业机械学报,2017,48(5):304-312.

杨岩,孙钦平,李妮,等.不同过磷酸钙添加量对蔬菜废弃物堆肥的影响[J].农业资源与环境学报,2017,34(1):66-72.

杨岩,孙钦平,李妮,等.添加过磷酸钙对蔬菜废弃物堆肥中氨气及温室气体排放的影响[J].应用生态学报,2015,26(1):161-167.

陈是吏,袁京,李国学,等. 过磷酸钙和双氰胺联用减少污泥堆肥温室气体及NH₃排放[J].农业工程学报,2017,33(6):199-206.

姜继韶,党森,王撵, 等.过磷酸钙和腐烂苹果联合添加对猪粪堆肥过程中碳素转化和腐熟的影响[J].环境科学学报,2018,38(11):4422-4430.

BHATTACHARYA S S, KIM K H, ULLAH M A, et al. The effects of composting approaches on the emissions of anthropogenic volatile organic compounds:a comparison between vermicomposting and general aerobic composting[J]. Environmental Pollution, 2016, 208:600-607.

WU J, ZHANG A G, LI G X, et al. Impact of phosphate additive on organic carbon component degradation during pig manure composting[J]. Environmental Science and Pollution Research, 2019,26(22):11805-11814.

吕吉华. 城市污水处理厂污泥好氧堆肥技术研究[D].贵阳:贵州大学,2007.

GUO X B, LU Y Y, LI Q L. Effect of adding flue gas desulphurization gypsum on the transformation and fate of nitrogen during composting[J]. Compost Science & Utilization, 2016, 24(4):230-237.

PAP B, GYÖRKEI Á, BOBOESCU I Z, et al. Temperature-dependent transformation of biogas-producing microbial communities points to the increased importance of hydrogenotrophic methanogenesis under thermophilic operation[J]. Bioresource Technology, 2015, 177:375-380.

李冰, 王昌全,江连强,等. 化学改良剂对稻草猪粪堆肥氨气释放规律及其腐熟进程的影响[J]. 农业环境科学学报,2008,27(4):1653-1661.

TIQUIA S M, TAM N F Y. Elimination of phytotoxicity during co-composting of spent pig-manure sawdust litter and pig sludge[J]. Bioresource Technology, 1998, 65(1/2):43-49.

施引文献

资源附件(0)

访问统计