EFFECT OF pH ON HYDROGEN PRODUCTION BY CODIGESTION OF SEWAGE SLUDGE AND LEACHATE

LI Hua-fan; KE Yi-hong; ZHANG Qing-yi; YANG Lin; ZHENG Yu-yi; LIU Chang-qing

doi:10.13205/j.hjgc.202008010

Volume 38 Issue 8

Nov. 2020

Turn off MathJax

Article Contents

Article Navigation > ENVIRONMENTAL ENGINEERING > 2020 > 38(8): 58-64

LI Hua-fan, KE Yi-hong, ZHANG Qing-yi, YANG Lin, ZHENG Yu-yi, LIU Chang-qing. EFFECT OF pH ON HYDROGEN PRODUCTION BY CODIGESTION OF SEWAGE SLUDGE AND LEACHATE[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(8): 58-64. doi: 10.13205/j.hjgc.202008010

Citation:

LI Hua-fan, KE Yi-hong, ZHANG Qing-yi, YANG Lin, ZHENG Yu-yi, LIU Chang-qing. EFFECT OF pH ON HYDROGEN PRODUCTION BY CODIGESTION OF SEWAGE SLUDGE AND LEACHATE[J]. ENVIRONMENTAL ENGINEERING , 2020, 38(8): 58-64. doi: 10.13205/j.hjgc.202008010

Citation:

PDF( 1992 KB)

EFFECT OF pH ON HYDROGEN PRODUCTION BY CODIGESTION OF SEWAGE SLUDGE AND LEACHATE

doi: 10.13205/j.hjgc.202008010

1. Institute of Environmental Science, Fujian Normal University, Fuzhou 350007, China;
2. College of Geographical Science, Fujian Normal University, Fuzhou 350007, China

Received Date: 2020-03-09

Abstract

Abstract

In this paper, sludge and incineration plant leachate were used as feedstocks for anaerobic hydrogen fermentation by vial batch test, and influences of feedstock proportion and pH of leachate on stability of co-anaerobic fermentation and hydrogen production performance were investigated. The results showed that the sole leachate without adding sludge could also produce hydrogen during anaerobic fermentation. While, when the initial pH of leachate was 5.20, the maximum hydrogen production performance and maximum hydrogen production rate were obtained in co-anaerobic fermentation tests, with the addition proportion of leachate at 90%, and the corresponding peak values were 201.58 mL and 9.56 mL/h, respectively; when the initial pH of leachate was 4.47, the maximum hydrogen production performance occurred at the leachate adding proportion of 60% (57.73 mL) and then declined, while the maximum hydrogen production rate reached the peak value with the addition of 40% leachate, which was 5.11 mL/h.
- sludge,
- leachate,
- anaerobic co-fermentation,
- bio-hydrogen production

FullText(HTML)

References(40)

References

DUNN S. Hydrogen futures:toward a sustainable energy system[J]. International Journal of Hydrogen Energy, 2002, 27(3):235-264.

LIN C Y, THI MAI-LINH N, CHU C Y, et al. Fermentative biohydrogen production and its byproducts:a mini review of current technology developments[J]. Renewable & Sustainable Energy Reviews, 2018, 82:4215-4220.

SERT M, GOKKAYA D S, CENGIZ N, et al. Hydrogen production from olive-pomace by catalytic hydrothermal gasification[J]. Journal of the Taiwan Institute of Chemical Engineers, 2018, 83:90-98.

SONG Z L, YAG G H, FENG Y Z, et al. Pretreatment of rice straw by hydrogen peroxide for enhanced methane yield[J]. Journal of Integrative Agriculture, 2013, 12(7):1258-1266.

YANG J N, LIU X Y, LIU X R, et al. Enhanced dark fermentative hydrogen production from waste activated sludge by combining potassium ferrate with alkaline pretreatment[J]. The Science of the Total Environment, 2020, 707:136105.

KIM D H, KIM S H, KIM H W, et al. Sewage sludge addition to food waste synergistically enhances hydrogen fermentation performance[J]. Bioresource Technology, 2011, 102(18):8501-8506.

BROWNE J D, MURPHY J D. Assessment of the resource associated with biomethane from food waste[J]. Applied Energy, 2013, 104:170-177.

王丹丹, 郭显强, 古励,等. 餐厨垃圾渗滤液强化城市污泥消化作用研究[J].环境科学学报,2014, 34(10):2566-2572.

WONG Y M, WU T Y, JUAN J C. A review of sustainable hydrogen production using seed sludge via dark fermentation[J]. Renewable & Sustainable Energy Reviews, 2014, 34:471-482.

BALDI F, PECORINI I, LANNELLI R. Comparison of single-stage and two-stage anaerobic co-digestion of food waste and activated sludge for hydrogen and methane production[J]. Renewable Energy, 2019, 143:1755-1765.

KIM S, CHOI K, KIM J O, et al. Biological hydrogen production by anaerobic digestion of food waste and sewage sludge treated using various pretreatment technologies[J]. Biodegradation, 2013, 24(6):753-764.

LI Z P, CHEN Z, YE H, et al. Anaerobic co-digestion of sewage sludge and food waste for hydrogen and VFA production with microbial community analysis[J]. Waste Management, 2018, 78:789-799.

SILVA F M S, MAHLER C F, OLIVEIRA L B, et al. Hydrogen and methane production in a two-stage anaerobic digestion system by co-digestion of food waste, sewage sludge and glycerol[J]. Waste Management, 2018, 76:339-349.

TAO Z L, YANG Q, YAO F B, et al. The inhibitory effect of thiosulfinate on volatile fatty acid and hydrogen production from anaerobic co-fermentation of food waste and waste activated sludge[J]. Bioresource Technology, 2020, 297:122428.

WANG G J, LI Q, DZAKPASU M, et al. Impacts of different biochar types on hydrogen production promotion during fermentative co-digestion of food wastes and dewatered sewage sludge[J]. Waste Management, 2018, 80:73-80.

卜银坤. 生活垃圾焚烧发电厂渗滤液全部入炉焚烧技术[J].环境工程技术学报,2019, 9(3):302-310.

李进, 刘宗宽, 贺延龄. 城市生活垃圾焚烧厂渗滤液产甲烷潜力[J].环境工程学报, 2019, 13(2):457-464.

AGDAG O N, SPONZA D T. Investigation of the effects of sewage sludge addition into solid waste digestion and leachate characteristics[J]. Asian Journal of Chemistry, 2013, 25(13):7495-7498.

BERENJKAR P, ISLAM M, YUAN Q. Co-treatment of sewage sludge and mature landfill leachate by anaerobic digestion[J]. International Journal of Environmental Science and Technology, 2019, 16(5):2465-2474.

ABDELHAY A, ALBSOUL A, HADIDI F, et al. Optimization and modeling of biogas production from green waste/biowaste Co-digestion using leachate and sludge[J]. Clean-Soil Air Water, 2016, 44(11):1557-1563.

叶杰旭. 城市生活垃圾焚烧厂渗沥液生物处理工艺及其效能研究[D].哈尔滨:哈尔滨工业大学, 2012.

SIVAGURUNATHAN P, KUMAR G, KIM S H, et al. Enhancement strategies for hydrogen production from wastewater:a review[J]. Current Organic Chemistry, 2016, 20(26):2744-2752.

BUNDHOO Z M A. Potential of bio-hydrogen production from dark fermentation of crop residues:A review[J]. International Journal of Hydrogen Energy, 2019, 44(32):17346-17362.

WAINAINA S, LUKITAWESA, AWASTHI M K, et al. Bioengineering of anaerobic digestion for volatile fatty acids, hydrogen or methane production:a critical review[J]. Bioengineered, 2019, 10(1):437-458.

MASUKO T, MINAMI A, IWASAKI N, et al. Carbohydrate analysis by a phenol-sulfuric acid method in microplate format[J]. Analytical Biochemistry, 2005, 339(1):69-72.

任南琪, 王爱杰. 厌氧生物技术原理与应用[M]. 北京:化学工业出版社, 2004.

LOGAN B E, OH S E, KIM I S, et al. Biological hydrogen production measured in batch anaerobic respirometers[J]. Environmental Science & Technology, 2002, 36(11):2530-2535.

LAY J J, LEE Y J, NOIKE T. Feasibility of biological hydrogen production from organic fraction of municipal solid waste[J]. Water Research, 1999, 33(11):2579-2586.

刘常青, 林志龙, 朱旭彬,等.初始pH对原污泥厌氧发酵产氢的影响[J].环境工程学报,2016, 10(11):6685-6691.

WATANABE H, YOSHINO H. Biohydrogen using leachate from an industrial waste landfill as inoculum[J]. Renewable Energy, 2010, 35(5):921-924.

KIM I S, HWANG M H, JANG N J, et al. Effect of low pH on the activity of hydrogen utilizing methanogen in bio-hydrogen process[J]. International Journal of Hydrogen Energy, 2004, 29(11):1133-1140.

杨帅, 张轶凡, 陈剑, 等.生活垃圾渗滤液与市政污泥协同厌氧消化的研究[J].科技资讯,2016, 14(35):133-135.

NIU D J, WANG J Y, WANG B Y, et al. Effect of Mo-containing additives on biohydrogen fermentation from cassava's stillage[J]. International Journal of Hydrogen Energy, 2011, 36(9):5289-5295.

ABREU A A, DANKO A S, COSTA J C, et al. Inoculum type response to different pHs on biohydrogen production from L-arabinose, a component of hemicellulosic biopolymers[J]. International Journal of Hydrogen Energy, 2009, 34(4):1744-1751.

FENG X Q, WANG H, WANG Y, et al. Biohydrogen production from apple pomace by anaerobic fermentation with river sludge[J]. International Journal of Hydrogen Energy, 2010, 35(7):3058-3064.

MA S H, WANG H, WANG Y, et al. Bio-hydrogen production from cornstalk wastes by orthogonal design method[J]. Renewable Energy, 2011, 36(2):709-713.

SEIFERT K, WALIGORSKA M, WOJTOWSKI M, et al. Hydrogen generation from glycerol in batch fermentation process[J]. International Journal of Hydrogen Energy, 2009, 34(9):3671-3678.

ZHAO M X, YAN Q, RUAN W Q, et al. Effects of butyric acid stress on anaerobic sludge for hydrogen production from kitchen wastes[J]. Journal of Chemical Technology and Biotechnology, 2010, 85(6):866-871.

WANG W, XIE L, CHEN J R, et al. Biohydrogen and methane production by co-digestion of cassava stillage and excess sludge under thermophilic condition[J]. Bioresource Technology, 2011, 102(4):3833-3839.

SHI X X, SONG H C, WANG C R, et al. Enhanced bio-hydrogen production from sweet sorghum stalk with alkalization pretreatment by mixed anaerobic cultures[J]. International Journal of Energy Research, 2010, 34(8):662-672.

Relative Articles

Supplements(0)

Cited By

Proportional views