ENHANCING THE PERFORMANCE OF PARTIAL NITRIFICATION-ANAMMOX BY USING HYDROTALCITE COMPOSITE BIOFILM CARRIERS

KONG Lingrui; LI Xinjue; ZHENG Ru; ZHANG Kuo; LIU Sitong

doi:10.13205/j.hjgc.202401003

Volume 42 Issue 1

Jan. 2024

Turn off MathJax

Article Contents

Article Navigation > ENVIRONMENTAL ENGINEERING > 2024 > 42(1): 16-23

KONG Lingrui, LI Xinjue, ZHENG Ru, ZHANG Kuo, LIU Sitong. ENHANCING THE PERFORMANCE OF PARTIAL NITRIFICATION-ANAMMOX BY USING HYDROTALCITE COMPOSITE BIOFILM CARRIERS[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(1): 16-23. doi: 10.13205/j.hjgc.202401003

Citation:

KONG Lingrui, LI Xinjue, ZHENG Ru, ZHANG Kuo, LIU Sitong. ENHANCING THE PERFORMANCE OF PARTIAL NITRIFICATION-ANAMMOX BY USING HYDROTALCITE COMPOSITE BIOFILM CARRIERS[J]. ENVIRONMENTAL ENGINEERING , 2024, 42(1): 16-23. doi: 10.13205/j.hjgc.202401003

Citation:

PDF( 8915 KB)

ENHANCING THE PERFORMANCE OF PARTIAL NITRIFICATION-ANAMMOX BY USING HYDROTALCITE COMPOSITE BIOFILM CARRIERS

doi: 10.13205/j.hjgc.202401003

Department of Environmental Science and Engineering, Peking University, Beijing 100871, China

Received Date: 2023-10-11
Available Online: 2024-04-29

Abstract

Abstract

One-stage partial nitrification-anammox(PN/A),as an autotrophic nitrogen removal technology, has made the low-carbon treatment of wastewater possible. However, maintaining stable and efficient partial nitrification and increasing the biomass retention of anammox bacteria remain the main challenges for the successful application of the PN/A process. In this study, a novel composite carrier composed of layered silicate minerals and nonwoven fabric was developed to enhance the nitrogen removal performance of the PN/A process. The adsorption characteristics between the carrier and microorganisms, as well as the influence of the composite carrier on the microbial community in the PN/A process, were investigated. The results showed that the reactor with the addition of layered silicate minerals achieved the highest nitrogen removal rate of 131.4 mg/(L·d), which was significantly higher than control group without layered silicate minerals addition(97.2 mg/(L·d)). Surface thermodynamic analysis and the extended DLVO theory indicated that layered silicate minerals formed strong electrostatic attractive forces with the microbial community, promoting microbial adsorption and extracellular polymeric substance secretion. In addition, the surface of the silicate minerals contains abundant metal ion which can promote sludge aggregation and facilitate the retention and growth of anammox bacteria. The hydrotalcite composite carrier provides an effective method for rapid start-up and stable operation of the PN/A process.
- partial nitrification,
- anammox,
- composite carrier,
- hydrotalcite,

FullText(HTML)

References(29)

References

[1]	李博洋,王少坡,李权,等.一段式短程硝化-厌氧氨氧化生物脱氮技术与工艺[J].环境工程,2017,35(4):15-9 ,25.
[2]	蒙小俊,韩勇,黄志贵,等.Anammox用于主流污水处理的挑战与对策[J].环境工程,2022,40(10):203-14.
[3]	张星星,王昕竹,印雯,等.厌氧氨氧化工艺快速启动策略研究进展[J].水处理技术,2020,46(11):16-23.
[4]	WANG J,LIANG J,NING D,et al.A review of biomass immobilization in anammox and partial nitrification/anammox systems:advances,issues,and future perspectives[J].Sci.Total.Environ.,2022,821:152792.
[5]	WANG P,LU B,CHAI X.Rapid start-up and long-term stable operation of the anammox reactor based on biofilm process:status,challenges,and perspectives[J].Chemosphere,2023,336:139166.
[6]	WANG H,YANG D,Chen Y,et al.Improving the anammox performance in municipal wastewater treatment based on the powder functional carriers:a critical review[J].Chem.Eng.J,2023,470:144167.
[7]	LV Y,PAN J,HUO T,et al.Enhanced microbial metabolism in one stage partial nitritation-anammox system treating low strength wastewater by novel composite carrier[J].Water Res.,2019,163:114872.
[8]	LI X,FENG Y,ZHANG K,et al.Composite carrier enhanced bacterial adhesion and nitrogen removal in partial nitrification/anammox process[J].Sci.Total.Environ.,2023,868:161659.
[9]	吕泓颖,王罗春,杨凯艳,等.水滑石在水处理中的应用进展研究[J].上海电力学院学报,2020,36:57-60.
[10]	班福忱,程宇,杨诗源,等.水滑石/超滤工艺处理微污染水中有机污染物的试验研究[J].水处理技术,2023,49(10):102-107.
[11]	XU X,LIU J,SUN H.Improving granular sludge stability via stimulation of extracellular polymeric substance production by adding layered double hydroxides[J].International Journal of Environmental Science and Technology,2019,16(2):987-94.
[12]	ZHANG C,BROWN P J B,MILES R J,et al.Inhibition of regrowth of planktonic and biofilm bacteria after peracetic acid disinfection[J].Water Res.,2019,149:640-649.
[13]	KONG L,ZHENG R,FENG Y,et al.Anammox bacteria adapt to long-term light irradiation in photogranules[J].Water Res.,2023,241:120144.
[14]	APHA.Standard methods for the Examination of Water & Wastewater[M].1995.
[15]	OSNES T,SANDSTAD O,SKAR V,et al.Total protein in common duct bile measured by acetonitrile precipitation and a micro bicinchoninic acid (BCA) method[J].Scandinavian Journal of Clinical and Laboratory Investigation,1993,53(7):757-763.
[16]	LOEWUS F A.Improvement in anthrone method for determination of carbohydrates[J].Analytical Chemistry,1952,24(1):219.
[17]	VAN OSS C J.Hydrophobicity of biosurfaces:origin,quantitative determination and interaction energies[J].Colloids and Surfaces B:Biointerfaces,1995,5(3):91-110.
[18]	GRASSO D,SUBRAMANIAM K,BUTKUS M,et al.A review of non-DLVO interactions in environmental colloidal systems[J].Reviews in Environmental Science and Biotechnology,2002,1(1):17-38.
[19]	HERMANSSON M.The DLVO theory in microbial adhesion[J].Colloids and Surfaces B:Biointerfaces,1999,14(1):105-119.
[20]	SHARMA P K,HANUMANTHA RAO K.Adhesion of Paenibacillus polymyxa on chalcopyrite and pyrite:surface thermodynamics and extended DLVO theory[J].Colloids and Surfaces B:Biointerfaces,2003,29(1):21-38.
[21]	OLIVEIRA R.Understanding adhesion:a means for preventing fouling[J].Experimental Thermal and Fluid Science,1997,14(4):316-322.
[22]	LIU X M,SHENG G P,WANG J,et al.Quantifying the surface characteristics and flocculability of Ralstonia eutropha[J].Applied Microbiology and Biotechnology,2008,79(2):187-194.
[23]	LIU J,DUAN C,ZHOU J,et al.Adsorption of bacteria onto layered double hydroxide particles to form biogranule-like aggregates[J].Applied Clay Science,2013:39-45.
[24]	JIA F,YANG Q,LIU X,et al.Stratification of extracellular polymeric substances (EPS) for aggregated anammox microorganisms[J].Environ Sci.Technol.,2017,51(6):3260-3268.
[25]	ZHANG H,JIA Y,KHANAL S K,et al.Understanding the role of extracellular polymeric substances on ciprofloxacin adsorption in aerobic sludge,anaerobic sludge,and sulfate-reducing bacteria sludge systems[J].Environ Sci.Technol.,2018,52(11):6476-6486.
[26]	SUN H,CHEN S,LIU J,et al.Role of layered double hydroxide in improving the stability of aerobic granular sludge[J].CLEAN-Soil,Air,Water,2017,45(4):1500943.
[27]	JIN B,WILÉN B M,LANT P.A comprehensive insight into floc characteristics and their impact on compressibility and settleability of activated sludge[J].Chem.Eng.J,2003,95(1):221-234.
[28]	WEI D,LI M,WANG X,ET AL.Extracellular polymeric substances for Zn(Ⅱ) binding during its sorption process onto aerobic granular sludge[J].J.Hazard.Mater.,2016,301:407-415.
[29]	WU J,YE Q,WU P,et al.Heteroaggregation of nanoplastics with oppositely charged minerals in aquatic environment:experimental and theoretical calculation study[J].Chem.Eng.J,2022,428:131191.