Preparation of solid-phase carbon sources with different ratios and their carbon release properties

ZHU Shenghui; ZHOU Gang; ZHU Ye; MIAO Lingzhan; HOU Jun

doi:10.13205/j.hjgc.202604007

Volume 44 Issue 4

Apr. 2026

Turn off MathJax

Article Contents

Article Navigation > ENVIRONMENTAL ENGINEERING > 2026 > 44(4): 57-66

ZHU Shenghui, ZHOU Gang, ZHU Ye, MIAO Lingzhan, HOU Jun. Preparation of solid-phase carbon sources with different ratios and their carbon release properties[J]. ENVIRONMENTAL ENGINEERING , 2026, 44(4): 57-66. doi: 10.13205/j.hjgc.202604007

Citation:

ZHU Shenghui, ZHOU Gang, ZHU Ye, MIAO Lingzhan, HOU Jun. Preparation of solid-phase carbon sources with different ratios and their carbon release properties[J]. ENVIRONMENTAL ENGINEERING , 2026, 44(4): 57-66. doi: 10.13205/j.hjgc.202604007

Citation:

PDF( 1704 KB)

Preparation of solid-phase carbon sources with different ratios and their carbon release properties

doi: 10.13205/j.hjgc.202604007

College of Environment, Hohai University, Nanjing 210024, China

Received Date: 2025-09-08
Available Online: 2026-06-06
Publish Date: 2026-04-01

Abstract

Abstract

Given the widespread occurrence of low C/N ratios in treated wastewater effluent and the instability of conventional liquid carbon sources， it is necessary to investigate solid-phase carbon sources in terms of composition and design. The goal is to optimize both the quantity and quality of carbon release for denitrification under low C/N conditions and to extend research into the environmental behavior of emerging contaminants. In this study， nine composite solid-phase carbon sources were prepared from straw， sawdust， and corncob as natural cellulose materials with different PHBV-to-cellulose mass ratios. Their carbon release characteristics were evaluated via dynamic release experiments combined with dissolved organic carbon （DOC） analysis， UV-Vis spectroscopy， and excitation-emission matrix （EEM） fluorescence spectroscopy. The results showed that with identical carbon-source components， increasing the proportion of cellulose caused corncob-based solid-phase carbon sources to exhibit release patterns that differed from， and in some cases were opposite to， those of straw- and sawdust-based systems. When the carbon-source composition was the same， increasing the proportion of straw or sawdust accelerated the release rate， increased total release and release duration， reduced the aromaticity and molecular weight of the released dissolved organic matter （DOM）， and promoted the release of protein-like DOM such as tryptophan and tyrosine， indicating that material ratios can synergistically regulate DOM bioavailability. Under identical ratio conditions， corncob-based composite carbon sources outperformed straw- and sawdust-based systems on multiple parameters： they achieved a moderate total carbon release while maintaining release durations exceeding 134 hours， thereby ensuring a stable carbon supply. The DOM they released exhibited lower aromaticity， smaller molecular weight， and a lower proportion of humic substances， indicating higher bioavailability. Overall， the corncob-based system demonstrated significant advantages in both bioavailability and engineering application potential.
- solid-phase carbon source,
- sustained release,
- aromaticity,
- humic substances,
- molecular weight size

FullText(HTML)

References(53)

References

[1]	YADAV S R，KUMAR B S，DAS T R，et al. Integrated advanced natural wastewater treatment system for small communities［J］. Water Science and Technology，2007，55（11）：239- 243.
[2]	ZE S W，WANG Y H，SONG X S，et al. Simultaneous removal of ciprofloxacin in PHBV biofilter denitrification process and its influencing factors［J］. Journal of Environmental Engineering Technology，2023，13（1）：222- 231. 迮思文，王宇晖，宋新山，等. PHBV生物滤池深度脱氮过程中抗生素环丙沙星的同步去除规律及影响因素［J］. 环境工程技术学报，2023，13（1）：222- 231.
[3]	ZHANG Y，WANG X C，CHENG Z，et al. Effect of fermentation liquid from food waste as a carbon source for enhancing denitrification in wastewater treatment［J］. Chemosphere，2016，144：689- 696.
[4]	SUN H，WU Q，YU P，et al. Denitrification using excess activated sludge as carbon source：Performance and the microbial community dynamics［J］. Bioresource Technology，2017，238：624- 632.
[5]	YANG Z，ZHOU Q，SUN H，et al. Metagenomic analyses of microbial structure and metabolic pathway in solid-phase denitrification systems for advanced nitrogen removal of wastewater treatment plant effluent：a pilot-scale study［J］. Water Research，2021，196：117067.
[6]	CHU L，WANG J. Denitrification of groundwater using PHBV blends in packed bed reactors and the microbial diversity［J］. Chemosphere，2016，155：463- 470.
[7]	XU Z，SONG L，DAI X，et al. PHBV polymer supported denitrification system efficiently treated high nitrate concentration wastewater：Denitrification performance，microbial community structure evolution and key denitrifying bacteria［J］. Chemosphere，2018，197：96- 104.
[8]	PAN B，XU L. Enhancement of sulfur autotrophic denitrification by solid-state carbon source PHBV for nitrate removal of aquaculture wastewater［J］. Processes，2025，13（1）：265.
[9]	FENG Y，WANG L，YIN Z，et al. Comparative investigation on heterotrophic denitrification driven by different biodegradable polymers for nitrate removal in mariculture wastewater：Organic carbon release，denitrification performance，and microbial community［J］. Frontiers in Microbiology，2023，14：1141362.
[10]	JIA L，SUN H，ZHOU Q，et al. Pilot-scale two-stage constructed wetlands based on novel solid carbon for rural wastewater treatment in southern China：enhanced nitrogen removal and mechanism［J］. Journal of Environmental Management，2021，292：112750.
[11]	CHAI W Y，GUO Y N，YANG Z，et al. Research progress on the influence of solid carbon source characteristics on biological denitrification technology［J］. Journal of Environmental Engineering Technology，2024，14（3）：963- 972. 柴文云，郭亚南，杨铮，等. 固相碳源的特性对生物反硝化脱氮技术的影响研究进展［J］. 环境工程技术学报，2024，14（3）：963- 972.
[12]	ZHANG H，NI J，QIAN W，et al. Pyrolysis atmospheres and temperatures co-mediated spectral variations of biochar-derived dissolved organic carbon：quantitative prediction and self-organizing maps analysis［J］. Molecules，28（5）：2247.
[13]	HAN Z Y，ZHOU Y Q，GENG C N. Composition and spatio-temporal distribution characteristics of DOM in a high-risk area of algal blooms in Lake Taihu［J］. Spectroscopy and Spectral Analysis，2024，44（12）：3568- 3575. 韩子怡，周永强，耿春女. 太湖藻华高发区DOM的组成和时空分布特征［J］. 光谱学与光谱分析，2024，44（12）：3568- 3575.
[14]	CUI X，YOU J，LIAO K，et al. Carbon source in tertiary denitrification regulates dissolved organic nitrogen in wastewater effluent［J］. Environmental Science& Technology，2024，58（10）：4648- 4661.
[15]	CUI H，FENG Y，YIN Z，et al. Organic carbon release，denitrification performance and microbial community of solid-phase denitrification reactors using the blends of agricultural wastes and artificial polymers for the treatment of mariculture wastewater［J］. Ecotoxicology and Environmental Safety，2023，255：114791.
[16]	CHENG H，MA S，LIAO K，et al. Effect of external carbon source type on effluent dissolved organic nitrogen characteristics in postdenitrifying moving bed biofilm reactors:chemical molecular and microbial insights［J］. Chemical Engineering Journal，2023，466：143338.
[17]	YANG H L，ZHANG D，LAN S H，et al. Preparation of polycaprolactone composite solid carbon source and its tertiary nitrogen removal［J］. Acta Scientiae Circumstantiae，2022，42（5）：263- 273. 杨惠兰，张丹，兰书焕，等. 聚己内酯复合固体碳源的制备及其深度脱氮性能研究［J］. 环境科学学报，2022，42（5）：263- 273.
[18]	DAI W D，LI H，ZHAO K F，et al. Effective control of the carbon release of starch/polyvinyl alcohol based on a polyamide coating in solid-phase denitrification［J］. Environmental Science：Water Research& Technology，2020，6（12）：3293- 3305.
[19]	SONG J，ZHANG S，DU L，et al. Synthesis，characterization and application of oligomeric proanthocyanidin-rich dual network hydrogels［J］. Scientific Reports，2023，13（1）：17754.
[20]	VORONOVA M I，GURINA D L，SUROV O V. Properties of poly（3-hydroxybutyrate-co-3-hydroxyvalerate）/polycaprolactone polymer mixtures reinforced by cellulose nanocrystals:experimental and simulation studies［J］. Polymers，2022，14（2）：340.
[21]	YANG L，GUO L K，REN Y X，et al. Denitrification performance，biofilm formation and microbial diversity during startup of slow sand filter using powdery polycaprolactone as solid carbon source［J］. Journal of Environmental Chemical Engineering，2021，9（4）：105561.
[22]	DEMEREC M. Cold spring harbor symposia on quantitative biology［M］. Cold Spring Harbor：Cold Spring Harbor Laboratory Press，1950.
[23]	LI C，WANG H，YAN G，et al. Initial carbon release characteristics，mechanisms and denitrification performance of a novel slow release carbon source［J］. Journal of Environmental Sciences，2022，118：32- 45.
[24]	SHAO L，XU Z X，WANG S，et al. Performance of new solid carbon source materials for denitrification［J］. Environmental Science，2011，32（8）：2323- 2327. 邵留，徐祖信，王晟，等. 新型反硝化固体碳源释碳性能研究［J］. 环境科学，2011，32（8）：2323- 2327.
[25]	SHAO Z H，HE P J，ZHANG D Q，et al. Characterization of water-extractable organic matter during the biostabilization of municipal solid waste［J］. Journal of Hazardous Materials，2009，164（2-3）：1191- 1197.
[26]	RITSON J P，GRAHAM N J D，TEMPLETON M R，et al. The impact of climate change on the treatability of dissolved organic matter（DOM）in upland water supplies:a UK perspective［J］. Science of the Total Environment，2014，473-474：714- 730.
[27]	LI P，HUR J. Utilization of UV-Vis spectroscopy and related data analyses for dissolved organic matter（DOM）studies:A review［J］. Critical Reviews in Environmental Science and Technology，2017，47（3）：131- 154.
[28]	ZSOLNAY A，BAIGAR E，JIMENEZ M，et al. Differentiating with fluorescence spectroscopy the sources of dissolved organic matter in soils subjected to drying［J］. Chemosphere，1999，38（1）：45- 50.
[29]	HUGUET A，VACHER L，RELEXANS S，et al. Properties of fluorescent dissolved organic matter in the gironde estuary［J］. Organic Geochemistry，2008，40（6）：706- 719.
[30]	YANG X L，JIANG Q，SONG H L，et al. Selection and application of agricultural wastes as solid carbon sources and biofilm carriers in MBR［C］// Proceedings of the International Conference on Environmental Science and Engineering，Xi'an：Science Press，2014：156- 162.
[31]	XIONG R，YU X，ZHANG Y，et al. Comparison of agricultural wastes and synthetic macromolecules as solid carbon source in treating low carbon nitrogen wastewater［J］. Science of the Total Environment，2020，739：139885.
[32]	ZHOU G Z，SUN J，ZHANG X，et al. Carbon source study on biological denitrification in groundwater［J］. Environmental Science& Technology，2008，31（7）：14- 17. 周贵忠，孙静，张旭，等. 地下水生物反硝化碳源材料研究［J］. 环境科学与技术，2008，31（7）：14- 17.
[33]	ZHONG S Q，YANG Y，TAO R，et al. Carbon releasing characteristics and denitrification effects of five plant materials［J］. Chinese Journal of Environmental Engineering，2014，8（5）：1921- 1927. 钟胜强，杨扬，陶然，等. 5种植物材料的水解释碳性能及反硝化效率［J］. 环境工程学报，2014，8（5）：1921- 1927.
[34]	ONI F M，OLOFINTOYE O F，IDOWU I O. Effective substrate loading for saccharification of corn cob and concurrent production of lignocellulolytic enzymes by fusarium oxysporum and sporothrix carnis［J］. Current Biotechnology，2019，8（2）：102- 110.
[35]	LI Y P. Solid carbon sources as external carbon to enhance the nitrogen removal performance of low C/N wastewater［D］. Taiyuan：Taiyuan University of Technology，2021. 李跃平. 固体碳源作为外加碳源提高低C/N污水脱氮性能研究［D］. 太原：太原理工大学，2021.
[36]	SUN Q，LI Y Q，PAN Q，et al. Exploring recycled agricultural wastes for high-rate removal of nitrogen in wastewater：Emphasizing on the investigation of the inner driving force and comparison with conventional liquid carbon sources［J］. Water Research，2022，226：119292.
[37]	LI C，WANG H，YAN G，et al. Initial carbon release characteristics，mechanisms and denitrification performance of a novel slow release carbon source［J］. Journal of Environmental Sciences，2022，118：32- 45.
[38]	SIMONIN J P. On the comparison of pseudo-first order and pseudo-second order rate laws in the modeling of adsorption kinetics［J］. Chemical Engineering Journal，2016，298：254- 263.
[39]	ZHANG H，QIAN W，WU L，et al. Spectral characteristics of dissolved organic carbon（DOC）derived from biomass pyrolysis:Biochar-derived DOC versus smoke-derived DOC，and their differences from natural DOC［J］. Chemosphere，2022，302：134869.
[40]	LING Y，YAN G K，WANG H Y，et al. Release mechanisms of carbon source and dissolved organic matter of six agricultural wastes in the initial stage［J］. Environmental Science，2021，42（5）：2312- 2320. 凌宇，闫国凯，王海燕，等. 6种农业废弃物初期碳源及溶解性有机物释放机制［J］. 环境科学，2021，42（5）：2312- 2320.
[41]	LING Y，YAN G，WANG H，et al. Release mechanism，secondary pollutants and denitrification performance comparison of six kinds of agricultural wastes as solid carbon sources for nitrate removal［J］. International Journal of Environmental Research and Public Health，2021，18（3）：1232.
[42]	CUI Y，ZHAO B，ZHANG X，et al. Denitrification performance and in-situ fermentation mechanism of the wastepaper-flora slow-release carbon source［J］. Bioresource Technology，2023，387：129074.
[43]	WEISHAAR J L，AIKEN G R，BERGAMASCHI B A，et al. Evaluation of specific ultraviolet absorbance as an indicator of the chemical composition and reactivity of dissolved organic carbon［J］. Environmental Science& Technology，2003，37（20）：4702- 4708.
[44]	WANG Y，QIN F，TANG Y H，et al. Agricultural wastes as additional carbon sources for denitrification［J］. Journal of Forestry Engineering，2019，33（5）：14- 18. 王玥，秦帆，唐燕华，等. 农业废弃物作为反硝化脱氮外加碳源的研究［J］. 林业科技开发，2019，33（5）：14- 18.
[45]	FANG Y H，LIU Y D. Selection of agricultural wastes as potential solid carbon sources for denitrification of wastewater［J］. Water Technology，2017，11（3）：7- 13. 方远航，刘昱迪. 基于农业废弃物的反硝化脱氮固体碳源比选［J］. 供水技术，2017，11（3）：7- 13.
[46]	LAI F F，YANG Q，SONG K S，et al. Remote sensing estimation of DOC concentration of reservoirs in Northeast China based on CDOM absorption［J］. Journal of Lake Sciences，2023，35（1）：224- 235. 赖锋发，杨倩，宋开山，等. 基于CDOM吸收特性的东北地区水库DOC浓度遥感估算［J］. 湖泊科学，2023，35（1）：224- 235.
[47]	HAYES A J，LAMB B D H，SINGH S B H. Comparison of the structural，spectroscopic and phenanthrene binding characteristics of humic acids from soils and lake sediments［J］. Organic Geochemistry，2009，40（10）：1091- 1099.
[48]	CHEN S，YANG D L，WANG Q X，et al. Study on the advanced nitrogen removal under low temperature by biofilm on weak magnetic carriers［J］. Bioresource Technology，2022，360：127580.
[49]	SUI Z N，ZHI E Q，YAO J，et al. Characterization of DOM composition and origin using three-dimensional fluorescence spectroscopy coupled with region integration method in Qixing wetland［J］. Journal of Environmental Engineering Technology，2015，5（2）：114- 120. 隋志男，郅二铨，姚杰，等. 三维荧光光谱区域积分法解析辽河七星湿地水体DOM组成及来源［J］. 环境工程技术学报，2015，5（2）：114- 120.
[50]	LI M R，WU D，ZHAO Z R，et al. Enhancing 2，6-dichlorophenol degradation and nitrate removal in the nano-zero-valent iron（nZVI）solid-phase denitrification system［J］. Chemosphere，2022，287：132249.
[51]	CHAI L，HUANG M，FAN H，et al. Urbanization altered regional soil organic matter quantity and quality：Insight from excitation emission matrix（EEM）and parallel factor analysis（PARAFAC）［J］. Chemosphere，2019，220：249- 258.
[52]	MU M，GAO L，ZHANG H，et al. Characterization of dissolved organic matter components of agricultural waste sources in water bodies based on EEMs［J］. Polish Journal of Environmental Studies，2023，32（3）：2145- 2154.
[53]	LING Y，YAN G，WANG H，et al. Release mechanism，secondary pollutants and denitrification performance comparison of six kinds of agricultural wastes as solid carbon sources for nitrate removal［J］. International Journal of Environmental Research and Public Health，2021，18（3）：1232.